RoadVitals

1985 GMC Safari Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest May 19, 2006
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
5 investigations on file

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

06E043000

FUEL SYSTEM, GASOLINE

May 19, 2006
88,303 units potentially affected
The defect: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
The risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
The remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
HONEYWELL INTERNATIONAL, INC.View on NHTSA.gov
93V187000

SEATS

Nov 16, 1993
604,207 units potentially affected
The defect: THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
The risk: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
The remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
GENERAL MOTORS CORP.View on NHTSA.gov
85V160000

STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

Dec 3, 1985
26,741 units potentially affected
The defect: A PART OF THE STEERING GEAR HOUSING WHICH ATTACHES TO THE FRAME MAY BREAK. CONSEQUENCE OF DEFECT: STEERING DIFFICULTIES WILL OCCUR AND THE STEERING GEAR TO THE FRAME MAY FRACTURE RESULTING IN LOSS OF STEERING CONTROL. THIS COULD RESULT IN A VEHICLE CRASH.
The remedy: REPLACE BROKEN OR CRACKED STEERING GEAR OR INSTALL A BRACE IF STEERING GEAR IS NOT BROKEN OR CRACKED.
GENERAL MOTORS CORP.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA92022ClosedEngineering Analysis

SEAT BACK BOLT BREAKAGE

Opened Jun 24, 1992
Closed Nov 19, 1993

There is no summary currently available

SEATSLed to recall 93V187000
PE90039ClosedPreliminary Evaluation

SPARE TIRE CARRIER FAILURE

Opened Feb 5, 1990
Closed Jun 29, 1990

There is no summary currently available

SUSPENSION
PE89106ClosedPreliminary Evaluation

REAR AXLE SEAL FAILURE

Opened Mar 23, 1989
Closed Sep 19, 1989

===

SUSPENSION
EA87009ClosedEngineering Analysis

REAR BRAKES

Opened Jan 21, 1987
Closed Aug 16, 1988

ANALYSIS: THE PROPOSED GM CHANGES SHOULD REDUCE THE FRONT-BIAS IN THEREAR BRAKE SYSTEM.HOWEVER THERE IS NO INDICATION THAT GM WILL RETROFITTHE 1985 AND 1986 MODEL YEAR VEHICLES.REPORTS INDICATE THAT THE PROBLEMMAY NOT LIE IN THE BRAKE BIASING SYSTEM, BUT RATHER IN MALFUNCTIONINGOR IMPROPERLY DESIGNED REAR BRAKE ADJUSTERS.STATUS: ANALYZING RESPONSE FROM GM DATED 5/12/87.AWAITING REPLY FROM NHTSA'S LEGAL STAFF CONCERNING GM'S RESPONSE.TOLD TO SIT ON IT A WHILE BY MR. PARKER AT 8/20/87 BRIEFING.AFTER LEGAL'S REPLY, THE DATA WILL BE UPDATED AND AN ACTIONDECISION WILL BE FORWARDED FOR SUPERVISOR'S REVIEW.===

SERVICE BRAKES, HYDRAULIC
PE86053ClosedPreliminary Evaluation

INADEQUATE REAR BRAKES

Opened May 1, 1986
Closed Jan 20, 1987

SUMMARY OF INFORMATION FROM MANUFACTURER:NO TSB'S OR RECALLS HAVE BEENISSUED ON THIS MATTER.THE 1985 CAMIP PHASE II SURVEY RATED THE GM M-VANBRAKE EFFECTIVENESS LOWEST AMONG VEHICLE LINES TESTED.IN RESPONSE TO THECONCERN OF VAN OWNERS, CHANGES IN THE REAR WHEEL CYLINDER DIAMETER AND THEPROPORTIONING VALVE WERE PLANNED FOR THE 1987 MODEL M-VANS.ANALYSIS:THE PROPOSED MANUFACTURER CHANGES WILL REDUCE THE FRONT-BIAS OFTHE BRAKE SYSTEM.HOWEVER, THERE IS NO INDICATION THAT GM WILL RETROFITTHE 1985 AND 1986 MODELS.OVER THE NINE MONTHS SINCE THE PE WAS OPENED,THE NUMBER OF ODI REPORTS HAS INCREASED BY 300%.THESE REPORTS INDICATETHAT THE PROBLEM MAY NOT BE AN OVERLY FRONT-BIASED BRAKING SYSTEM, BUTTED M-VAN'SBRAKE ADJUSTER WAS NOT OPERATING PROPERLY, ALLOWING THE LEFT REAR WHEEL TOROTATE, EVEN WITH 200 POUNDS APPLIED PEDAL FORCE.THE VEHICLE DID PASSMODIFIED COMPLIANCE TESTS FOR BRAKE STOPPING DISTANCES.PROPOSED ACTION:TO UPGRADE THIS TO AN ENGINEERING ANALYSIS.===

SERVICE BRAKES, HYDRAULIC

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .