2001 GMC Sierra 1500 Problems

Truck has just over 150k miles. Maintained well and garaged when possible. 1) Noticed a fuel smell from the driver side door area and after parking for a long weekend, a small pool of liquid formed in front of the driver side rear wheel. It was fuel dripping from the line leaving the evap canister that had rusted through. Resulted in a $600 repair to replace all rusted fuel lines so as to eliminate the risk of fire. 2) When approaching an intersection to make a left turn and slowing down the brake pedal pushes to the floor with no stopping power at all. Used the engine/trans in manual mode to slow the truck down and avoid an accident. Driver side brake lines are blown out in multiple spots near the ABS module due to corrosion. Potential cost based on research is in the $1000 ballpark. This level of rust on critical vehicle components is irresponsible and potentially deadly. GM needs to take this more seriously and realize that their cost-cutting measures are putting people and their families in grave danger.

THE ABS AND BREAK SYSTEM WARNING LIGHT HAS BEEN COMING ON AND STAYING ON. I LOST MY BREAKS LEAVING A PARKING SPOT AT MY LOCAL WALMART AS I WAS PULLING OUT OF A PARKING SPOT! WE THEN MADE APPOINTMENT FOR THE BREAK SYSTEM TO BE CHECKED/REPAIRED. THE ABS CONTROL SYSTEM LIGHT WENT OFF FOR AWHILE BUT THEN COMES BACK ON EVEN AFTER THE REPAIR OF SAID REPAIR TO BREAK LINES. MY TRUCK ALSO HAS NO FUEL GAUGE THAT DOES NOT WORK. WITH THESE ISSUES ON MY VEHICLE MAKES IT VERY SCARY TO DRIVE AND MAKES DRIVING LIMITED. I AM NOT ABLE TO DRIVE MY TRUCK LONG DISTANCES DUE TO CONCERNS OF SAFETY AND POSSIBLY OF ABS WARNING LIGHT, BREAK ISSUES, AND FUEL GAUGE! I WAS DRIVING MY TRUCK TO PICK ONE OF MY DAUGHTERS UP FROM SCHOOL TO LOSE POWER WHILE PUSHING ON GAS THEN SOME JERKING AND A FOUL SMELL OF RUBBER BURNING COMING FROM THE FRONT RIGHT TIRE AREA. I THEN HAD SOMEONE LOOK AT THE TRUCK AND WAS TOLD THAT WHAT EVER IT WAS HAPPENING THAT EVERYTHING LOOKED OKAY AND IT WAS POSSIBLE JUST A BREAK STICKING. IT HAS HAPPENED 3 DIFFERENT TIMES. MY TRUCK STILL HAS APPROXIMATELY 98,000 OR SO MILES ON IT. THIS TRUCK ALSO HAS BAD CORROSION ON BOTTOM BASEBOARDS OF THE TRUCK. I SAW BELOW THAT I AM ASKED FOR SPECIFIC DATE OF ISSUES. I CAN NOT PROVIDE SPECIFIC DATES SINCE THERE HAS BEEN SO MANY THINGS WRONG WHICH HAS HAPPENED AT DIFFERENT TIMES.

Truck has just over 150k miles. Maintained well and garaged when possible. 1) Noticed a fuel smell from the driver side door area and after parking for a long weekend, a small pool of liquid formed in front of the driver side rear wheel. It was fuel dripping from the line leaving the evap canister that had rusted through. Resulted in a $600 repair to replace all rusted fuel lines so as to eliminate the risk of fire. 2) When approaching an intersection to make a left turn and slowing down the brake pedal pushes to the floor with no stopping power at all. Used the engine/trans in manual mode to slow the truck down and avoid an accident. Driver side brake lines are blown out in multiple spots near the ABS module due to corrosion. Potential cost based on research is in the $1000 ballpark. This level of rust on critical vehicle components is irresponsible and potentially deadly. GM needs to take this more seriously and realize that their cost-cutting measures are putting people and their families in grave danger.

MY ANTI LOCK KEEP KICKING IN, THE PANHEAD BY GAS TANK IS COMPLETELY SHOT AND THERE IS A BOX BY THE GAS TANK FOR EMISSIONS AND NOT ABLE TO GET 1 AND THE FRAME IN THE FRONT IS SHOT ALSO ALONG WITH THE BODY THAT'S COMPLETELY SHOT AND THE GAS GAUGE KEEPS TELLING EMPTY 1 TIME AND THEN IT GOES TO FULL TO EMPTY EVEN AFTER I FILL IT UP...

MY ANTI LOCK KEEP KICKING IN, THE PANHEAD BY GAS TANK IS COMPLETELY SHOT AND THERE IS A BOX BY THE GAS TANK FOR EMISSIONS AND NOT ABLE TO GET 1 AND THE FRAME IN THE FRONT IS SHOT ALSO ALONG WITH THE BODY THAT'S COMPLETELY SHOT AND THE GAS GAUGE KEEPS TELLING EMPTY 1 TIME AND THEN IT GOES TO FULL TO EMPTY EVEN AFTER I FILL IT UP...

THE FRAME IS SEVERELY ROTTED BEHIND THE CAB ON BOTH SIDES. I HAVE NEVER SEEN A FRAME THAT IS THIS AGE ROTTED SO BAD. THIS REMINDS ME OF THE PROBLEM TOYOTA HAD WITH THEIR TACOMAS. BUT ATLEAST TOYOTA PUT OUT A RECALL TO REMEDY THE PROBLEM.

MY ABS CONTROL MODULE IS NOT FUNCTIONING PROPERLY. ABS IS DISABLED AND COSTS $1000 TO REPLACE. THIS IS A SAFETY HAZARD AS THE BRAKES CAN LOCK UP AT ANY MOMENT OR ABS IS DISABLED AND MAY CAUSE BRAKES TO LOCK UP. THE ABS LIGHT ON DASHBOARD IS ON CONTINUOUSLY AND THE MODULE WILL NEED TO BE REPLACED OR FURTHER DAMAGE WILL OCCUR. *TR

IT STARTED WITH THE FUEL GAUGE FLUCTUATING BETWEEN FULL AND EMPTY WITH A FULL TANK OF GAS AND THE ABS AND BRAKE LIGHT ON DASH LIGHTING UP FOR APPARENTLY NO REASON. THEN IT STARTED GIVING ME TROUBLE STARTING AND MAKING A WEIRD WHINING NOISE. I CHECKED ALL THE FLUID LEVELS AND FUSES, EVERYTHING WAS OK. I WAS AT THE CAMP(MIDDLE OF NOWHERE) AT NIGHT WHEN I NOTICED THAT THERE WERE SPARKS COMING FROM AROUND THE AREA OF THE STARTER WHEN MY HUSBAND TRIED TO START IT.(IT JUST HAPPENED TO BE DARK AND I WAS SITTING WITH A VIEW OF THE RIGHT WHEEL WELL) I CHECKED THE WIRES AND FOUND WHAT MIGHT HAVE BEEN A BREAK IN THE INSULATION, TAPED IT AND THE SPARKS QUIT. HAD NO CHOICE BUT TO DRIVE IT HOME THE NEXT DAY AS THERE WAS NO PHONE SERVICE. STARTED RIGHT UP , AND DROVE FINE, EXCEPT FOR THE LOW WHINNY NOISE THAT NO ONE COULD PINPOINT. I WAS ALMOST HOME WHEN THE TRANSMISSION STARTED TO SLIP. I BROUGHT IT TO OUR MECHANIC WHO REPLACED THE TRANSMISSION BUT NONE OF US CAN FIGURE OUT WHAT THE DEVIL IS CAUSING THE ELECTRICAL PROBLEMS. BEFORE THE TRANSMISSION WENT OUT THE TOW/ HAUL BUTTON DIDN'T DO ANY THING, NOW THE LIGHT ACTUALLY COMES ON-WHEN IT FEELS LIKE IT,BUT I CAN'T GET IT TO GO OFF. THE GAS GAUGE IS STILL ACTING NUTS AND THE ABS AND BRAKE LIGHT STILL COME AND GO. PLEASE POST INSTRUCTIONS FOR TROUBLESHOOTING THIS THING! *TR

MANIFOLD BOLT(S) BROKEN. HEARD IT'S A COMMON THING. REALLY DISAPPOINTS ME ABOUT MY TRUST IN GM.

AS FAR AS I KNOW THE TRUCK WENT AROUND CORNER AND VEERED OFF THE ROAD IN TO A SNOW BANK DUE TO BLACK ICE AND INTO A TREE ON PASSENGER SIDE OF TRUCK .IT WAS A HARD HIT AND THE AIR BAGS DID NOT WORK .WHEN I GET THE ACCIDENT REPORT I WILL PUT EXACT SPEED. *TR

THE ABS AND BREAK SYSTEM WARNING LIGHT HAS BEEN COMING ON AND STAYING ON. I LOST MY BREAKS LEAVING A PARKING SPOT AT MY LOCAL WALMART AS I WAS PULLING OUT OF A PARKING SPOT! WE THEN MADE APPOINTMENT FOR THE BREAK SYSTEM TO BE CHECKED/REPAIRED. THE ABS CONTROL SYSTEM LIGHT WENT OFF FOR AWHILE BUT THEN COMES BACK ON EVEN AFTER THE REPAIR OF SAID REPAIR TO BREAK LINES. MY TRUCK ALSO HAS NO FUEL GAUGE THAT DOES NOT WORK. WITH THESE ISSUES ON MY VEHICLE MAKES IT VERY SCARY TO DRIVE AND MAKES DRIVING LIMITED. I AM NOT ABLE TO DRIVE MY TRUCK LONG DISTANCES DUE TO CONCERNS OF SAFETY AND POSSIBLY OF ABS WARNING LIGHT, BREAK ISSUES, AND FUEL GAUGE! I WAS DRIVING MY TRUCK TO PICK ONE OF MY DAUGHTERS UP FROM SCHOOL TO LOSE POWER WHILE PUSHING ON GAS THEN SOME JERKING AND A FOUL SMELL OF RUBBER BURNING COMING FROM THE FRONT RIGHT TIRE AREA. I THEN HAD SOMEONE LOOK AT THE TRUCK AND WAS TOLD THAT WHAT EVER IT WAS HAPPENING THAT EVERYTHING LOOKED OKAY AND IT WAS POSSIBLE JUST A BREAK STICKING. IT HAS HAPPENED 3 DIFFERENT TIMES. MY TRUCK STILL HAS APPROXIMATELY 98,000 OR SO MILES ON IT. THIS TRUCK ALSO HAS BAD CORROSION ON BOTTOM BASEBOARDS OF THE TRUCK. I SAW BELOW THAT I AM ASKED FOR SPECIFIC DATE OF ISSUES. I CAN NOT PROVIDE SPECIFIC DATES SINCE THERE HAS BEEN SO MANY THINGS WRONG WHICH HAS HAPPENED AT DIFFERENT TIMES.

AS FAR AS I KNOW THE TRUCK WENT AROUND CORNER AND VEERED OFF THE ROAD IN TO A SNOW BANK DUE TO BLACK ICE AND INTO A TREE ON PASSENGER SIDE OF TRUCK .IT WAS A HARD HIT AND THE AIR BAGS DID NOT WORK .WHEN I GET THE ACCIDENT REPORT I WILL PUT EXACT SPEED. *TR

MY ANTI LOCK KEEP KICKING IN, THE PANHEAD BY GAS TANK IS COMPLETELY SHOT AND THERE IS A BOX BY THE GAS TANK FOR EMISSIONS AND NOT ABLE TO GET 1 AND THE FRAME IN THE FRONT IS SHOT ALSO ALONG WITH THE BODY THAT'S COMPLETELY SHOT AND THE GAS GAUGE KEEPS TELLING EMPTY 1 TIME AND THEN IT GOES TO FULL TO EMPTY EVEN AFTER I FILL IT UP...

AS FAR AS I KNOW THE TRUCK WENT AROUND CORNER AND VEERED OFF THE ROAD IN TO A SNOW BANK DUE TO BLACK ICE AND INTO A TREE ON PASSENGER SIDE OF TRUCK .IT WAS A HARD HIT AND THE AIR BAGS DID NOT WORK .WHEN I GET THE ACCIDENT REPORT I WILL PUT EXACT SPEED. *TR

TL* THE CONTACT OWNS A 2001 GMC SIERRA 1500. THE CONTACT STATED THAT THE VEHICLE WAS EQUIPPED WITH SIGMA STAMPEDE TIRES, SIZE 265/75/16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 72 MPH, A LOUD NOISE EMITTED OUTSIDE THE VEHICLE AS IT SPUN AROUND AND TRAVELED ONTO A DITCH BEFORE CRASHING INTO A FENCE. THE VEHICLE CAME TO A STOP AFTER TRAVELING ONTO A NEARBY ROAD. THERE WERE NO PERSONAL INJURIES AND A POLICE REPORT WAS NOT FILED. THE CONTACT NOTICED THAT THE REAR DRIVER'S SIDE TIRE SLIGHTLY EXPLODED WITH SEVERE TIRE SEPARATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT TIRE CENTER WHERE BOTH REAR DRIVER AND PASSENGER'S TIRE WERE REPLACED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. THE VIN AND DOT NUMBER WAS UNAVAILABLE. THE MILEAGE OF THE TIRE WAS UNAVAILABLE.

TL* THE CONTACT OWNS A SET OF COOPER MASTER CRAFT COURSER A/T 2 TIRES ON A 2001 GMC SIERRA. WHILE DRIVING BETWEEN 25-55 MPH THE VEHICLE STARTED DRIFTING TO THE LEFT. UPON FURTHER INSPECTION HE NOTICED THAT THE TREAD ON THE TIRES WERE SEPARATING. HE HAD THREE SETS OF TIRES REPLACED. HOWEVER THE MANUFACTURER WILL NOT ASSUME RESPONSIBILITY FOR THE FOURTH SET. A REPRESENTATIVE CONCLUDED THAT THE TIRES ARE SEPARATING BECAUSE OF STONE DRILLING ON THE ROADS. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 115,000. UPDATED 10/27/09 *BF THE CONSUMER STATED HE REPLACED THREE OF THE TIRES. THE FOURTH TIRE IS SPLITTING IN THE CENTER WITH WIRES COMING THROUGH THE CENTER OF THE TIRE. UPDATED 10/29/09

TL* THE CONTACT OWNS A 2001 GMC SIERRA 800 (NA). ON SEVERAL OCCASIONS, THE CONTACT NOTICED FLUID LEAKING FROM THE STEERING GEAR ASSEMBLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO HILEY BUICK GMC (3535 W LOOP 820 S, FORT WORTH, TX 76116 (817) 632-8800 WHERE IT WAS DIAGNOSED THAT THE STEERING GEAR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. ON ANOTHER OCCASION, THE CONTACT NOTICED THAT THE LEAKAGE FROM THE STEERING GEAR ASSEMBLY FAILED AGAIN. THE VEHICLE WAS TAKEN BACK TO HILEY BUICK GMC WHERE IT WAS THEN DIAGNOSED THAT THE STEERING GEAR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. DURING THE THIRD FAILURE, THE CONTACT PARKED THE VEHICLE IN HIS GARAGE AND NOTICED A TRAIL OF FLUID ON THE GROUND. UPON FURTHER INSPECTION, HE NOTICED FLUID COMING FROM THE STEERING AGAIN. THE VEHICLE WAS THEN TAKEN BACK TO HILEY BUICK GMC WHERE IT WAS DIAGNOSED THAT THE STEERING GEAR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT WITH A DIFFERENT PART NUMBER (19330428). THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 146,650.

I OWN A 2001 GMC SIERRA 1500. I HAVE ALWAYS TAKEN EXCEPTIONAL CARE OF MY VEHICLE. THE MOTOR HAS ALWAYS HAD A KNOCK WHEN YOU START IT,WHICH DEVALUES THE TRUCK & IT ALSO HAS ALWAYS USED OIL. THE RACK & PINION HAS STARTED LEAKING. I HAVE ALWAYS OWNED A TRUCK & HAVE NEVER HAD A RACK & PINION GO OUT LET ALONE AT 152000 MILES.IT ALSO IS LOSING ANTIFREEZE BUT THERE ARE NO LEAKS. THE FUEL GAUGE HAS NEVER WORKED PROPERLY,NOW ITS ALSO FLASHES LOW COOLANT LIGHT WHEN ITS NOT LOW. I HAVE SEEN NUMEROUS COMPLAINTS ON LINE CONCERNING THESE SAME ISSUES & LAWSUITS. I DO NOT FEEL THE CONSUMER SHOULD BE HAVING TO FOOT THESE BILLS. I HAVE CALLED GM ABOUT MY CONCERNS & THEY SAY THERE IS NOTHING THEY CAN DO. WHAT CAN WE DO TO GET A RECALL FOR ALL THESE PROBLEMS. MY TRUCK IS ONE OF THE ONES THAT HAVE DEX-COOL ANTIFREEZE. *TR

WAS ABOUT TO GO SHOPPING FOR CHRISTMAS GIFTS, STEPPED ON BRAKE AT TOP OF COURT AND THE PEDDLE WENT TO FLOOR. NOT JUST LOSS OF HYDROS FULL ON BRAKE MALFUNCTION , NO BRAKES AT ALL. I LIVE IN NEW YORK AND TRUCK WAS PURCHASED FROM CONNECTICUT. DECIDED TO MAKE LEFT TURN AND MISSED GETTING HIT BY 18 WHEELER BY INCHES. I AM LUCKY TO BE ALIVE TO BE TYPING THIS NOW, NO THANKS TO GM. NO WARNING LIGHTS NOTHING AT ALL JUST NO BRAKES. TO ADD EMERGENCY BRAKE DID NOT WORK. *TR

THE VEHICLE EXPERIENCED REAR AXLE PROBLEMS. *AK *JB

IT STARTED WITH THE FUEL GAUGE FLUCTUATING BETWEEN FULL AND EMPTY WITH A FULL TANK OF GAS AND THE ABS AND BRAKE LIGHT ON DASH LIGHTING UP FOR APPARENTLY NO REASON. THEN IT STARTED GIVING ME TROUBLE STARTING AND MAKING A WEIRD WHINING NOISE. I CHECKED ALL THE FLUID LEVELS AND FUSES, EVERYTHING WAS OK. I WAS AT THE CAMP(MIDDLE OF NOWHERE) AT NIGHT WHEN I NOTICED THAT THERE WERE SPARKS COMING FROM AROUND THE AREA OF THE STARTER WHEN MY HUSBAND TRIED TO START IT.(IT JUST HAPPENED TO BE DARK AND I WAS SITTING WITH A VIEW OF THE RIGHT WHEEL WELL) I CHECKED THE WIRES AND FOUND WHAT MIGHT HAVE BEEN A BREAK IN THE INSULATION, TAPED IT AND THE SPARKS QUIT. HAD NO CHOICE BUT TO DRIVE IT HOME THE NEXT DAY AS THERE WAS NO PHONE SERVICE. STARTED RIGHT UP , AND DROVE FINE, EXCEPT FOR THE LOW WHINNY NOISE THAT NO ONE COULD PINPOINT. I WAS ALMOST HOME WHEN THE TRANSMISSION STARTED TO SLIP. I BROUGHT IT TO OUR MECHANIC WHO REPLACED THE TRANSMISSION BUT NONE OF US CAN FIGURE OUT WHAT THE DEVIL IS CAUSING THE ELECTRICAL PROBLEMS. BEFORE THE TRANSMISSION WENT OUT THE TOW/ HAUL BUTTON DIDN'T DO ANY THING, NOW THE LIGHT ACTUALLY COMES ON-WHEN IT FEELS LIKE IT,BUT I CAN'T GET IT TO GO OFF. THE GAS GAUGE IS STILL ACTING NUTS AND THE ABS AND BRAKE LIGHT STILL COME AND GO. PLEASE POST INSTRUCTIONS FOR TROUBLESHOOTING THIS THING! *TR

I JUST WANT TO LET YOU KNOW ABOUT A LITTLE PROBLEM I'M HAVING WITH MY 2001 GMC 4X4 TRUCK. THERE ARE TWO CERTAIN GROCERY STORES I GO TO AND WHEN I START MY TRUCK BACK AT THESE STORES THE GAS GAUGE GOES TO EMPTY AND THE GAS PEDAL LOCKS UP AND CAN NOT BE PUSHED DOWN.THEN I HAVE TO TURN OFF THE ENGINE , THEN WHEN I GET THE GAS PEDAL FREED THEN START THE TRUCK BACK THE GAS PEDAL IS OK. I'M THINKING MY TRUCK'S COMPUTER IS GETTING CONFUSED WITH SOME KIND OF MICRO WAVES OR SOMETHING COMING FROM THE STORES ELECTRICAL DEVICES. I'M WONDERING IF ANYONE ELSE HAS THESE PROBLEMS. *TR

WHILE DRIVING I TILTED MY STEERING WHEEL AND THE HEADLIGHTS STOPPED WORKING. I FOUND THAT AS I MOVED THE WHEEL UP AND DOWN THERE WAS A SPOT AT WHICH THE LIGHTS WOULD STOP WORKING. AFTER GOING TO THE DEALERSHIP I THEY FOUND THAT A WIRE IN THE JUNCTION BLOCK OF THE MULTIFUNCTION SWITCH (BLINKER ASSEMBLY) HAD SHORTED OUT CAUSING THE LIGHTS TO GO OUT. DEALERSHIP REPLACED THE MULTIFUNCTION SWITCH. *TR

VEHICLE WAS STOPPED IN LEFT TURN LANE WHEN IMPACTED HEAD ON BY SMALLER CAR ONCOMING TRAFFIC. VEHICLE WAS KNOCKED BACK APPROXIMATELY 40 FEET AND 16 FEET SIDE WAYS. NEITHER AIRBAG DEPLOYED OR SEAT BELT LOCKED TO PREVENT DRIVER FROM IMPACTING STEERING WHEEL AND DASH BOARD, RESULTING IN FACE ,CHEST, ARM, AND LEG INJURIES. *TR

THE REAR END WAS REPLACED FOUR TIMES. VEHICLE STARTED TO SCREAM. AFTER TAKING IT TO THE DEALER IT WAS DISCOVERED THE REAR END WAS DEFECTIVE.*AK