2008 GMC Sierra 1500 Body & structure Problems

The contact owns a 2008 GMC Sierra 1500. The contact stated that while driving at 60 MPH, the spare tire detached from underneath. After a visual inspection of the underneath of the vehicle, he observed that the spare tire hoist and frame were severely corroded, potentially compromising the structural integrity of the vehicle. No warning lights were illuminated. The vehicle was not repaired. The manufacturer was not notified of the failure. The VIN was not available. The failure mileage was 197,000.

NHTSA ID

11578944

Incident

Mar 22, 2024

Mileage

197,000 mi

left side frame is defective, I have welded 4 patches on frame.from the bend by wheel well and fuel tank to front wheel well all by were frame has bracket welded and bottom of inside of frame . if hit on left side can cause frame to crumble and fuel tank to explode. it needs to be looked at for recall. i have spoken to many oweners of 2007 to 2009 gm trucks. and all have same problem. my truck only has around 112 thousand on it this is 3rd year i had to repair.

NHTSA ID

11503763

Incident

Feb 20, 2019

VEHICLE'S AIRBAGS DID NOT DEPLOY UPON COLLISION WITH TWO CONCRETE WALLS, CAUSING A LIFE THREATENING TBI AND ALSO SEVERE DAMAGE TO THE LEFT ARM WHICH RESULTED IN IT'S INABILITY TO CONTROL/USE BELOW THE ELBOW, AND ESPECIALLY THE HAND. THIS WAS DUE TO THE BRACHIAL PLEXUS INJURY THAT WAS CAUSED WHEN THE AIRBAGS DID NOT DEPLOY AS THEY WERE SUPPOSED TO. I HAVE ATTACHED THE REPORT FROM POLICE AND INSURANCE COMPANY (WITH PHOTOS).

NHTSA ID

11384655

Incident

Jun 23, 2012

Mileage

81,723 mi

TL* THE CONTACT OWNS A 2008 GMC SIERRA 1500. THE CONTACT STATED THAT THERE WAS A FRACTURE ON THE PASSENGER SIDE DASHBOARD ALONG THE AIR BAG ENCLOSURE UP TO THE WINDSHIELD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS CONCERNED OF THE LOCATION OF THE FRACTURE AND THE FACT THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V383000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.

NHTSA ID

11245166

Incident

Aug 17, 2019

Mileage

36,000 mi

SEVERELY CRACKED DASH. CRACKED IN 5 PLACES. WORRIED WHAT WOULD HAPPEN IF PASSENGER AIRBAG IS EVER DEPLOYED.

NHTSA ID

11191451

Incident

Mar 7, 2018

Mileage

195,000 mi

ABOVE THE INSTRUMENT PANEL AND FRONT LEFT OF THE PASSENGER AIR BAG. IF AIRBAG GOES OFF SHARDS ARE GOING TO FLY AT FACES. SAFETY HAZARD IF THE AIRBAG WAS DEPLOYED AND IS NOT AESTHETICALLY PLEASING MAKING A FINE GM VEHICLE LOOK SLOPPY

NHTSA ID

11184342

Incident

Mar 1, 2019

Mileage

100,000 mi

DASH BOARD CRASH ALL OVER AND BY THE AIR BAG

NHTSA ID

11109945

Incident

Jun 21, 2010

THE DASH BOARD HAS RANDOM HAIR LINE CRACKS THROUGHOUT THAT HAVE RECENTLY SHOWN UP. THE VEHICLE HAS NEVER BEEN IN AN ACCIDENT

NHTSA ID

11073045

Incident

Feb 12, 2018

Mileage

140,000 mi

DASHBOARD CRACKED IN TWO PLACES. THE PASSENGER SIDE CRACKED ON THE PORTION COVERING THE PASSENGER AIR BAG. I AM WORRIED THAT IF INFLATED, THE PLASTIC SHARDS WILL IMPALE ANY PASSENGER. ALSO THE DASHBOARD CRACKED ON THE DRIVER SIDE ABOVE THE INSTRUMENT CLUSTER. IT IS BEGINNING TO CAVE IT.

NHTSA ID

11046937

Incident

Jan 3, 2017

Mileage

145,000 mi

THE PANELS OVER THE REAR WHEELS ARE BOTH RUSTING THROUGH. BUBBLES ON THE PAINT AS IT RUST TO THE SURFACE. TRUCK IS NOT DRIVEN DURING WINTER SNOW MONTHS IT STAYS IN GARAGE OVER THE WINTER MONTHS. SURPRISED IT WOULD RUST THROUGH ALREADY. IS THERE ANY BODY WARRANTY FOR RUST BEFORE 10 YEARS?

NHTSA ID

11015260

Incident

May 1, 2017

FAILURE OF UNDERBODY/FRAME RUST UNDERCOATING. THE UNDERCOATING HAS COMPLETELY FLAKED OFF THE FRAME OF MY TRUCK WITH 90K MILES. I AM THE ONLY OWNER OF THIS VEHICLE WHICH HAS BEEN GARAGED SINCE DAY ONE. THE VEHICLE IS ALSO RUSTING THRU FROM THE UNDERSIDE OF THE HOOD. I HAVE CONTACTED GMC ABOUT THIS ISSUE BOTH IN PERSON & ON THE PHONE. THEY HAVE DENIED ANY LIABILITY IN THIS MATTER.

NHTSA ID

10959038

Incident

Feb 1, 2016

Mileage

85,000 mi

DASHBOARD IS CRACKED IN MULTIPLE PLACES. ONE CRACK IS ALONG THE PASSENGER AIRBAG AND THE SECOND IS ALONG THE DRIVERS SIDE IN FRONT OF THE INSTRUMENT GLUSTER. THE FIRST CRACK APPEARED AS I WAS LEAVING MY DRIVEWAY AND THE OTHER WAS WHILE DRIVING DOWN THE STREET. I AM WORRIED THAT THE AIRBAG CRACK COULD CAUSE SHARP PIECES OF THE DASH TO PROJECT IN THE CASE OF A DEPLOYMENT OF THE AIRBAG.

NHTSA ID

10956660

Incident

May 16, 2016

Mileage

110,000 mi

I HAVE A LARGE SECTION OF MY DASH PAD BROKEN ON THE DRIVERS SIDE. I ALSO HAVE A CRACK ON THE PASSENGER SIDE. THIS WAS NOT CAUSED FROM ABUSE BUT FROM INFERIOR MATERIALS. IT APPEARED SOMETIME IN 2015 WITH ABOUT 130,000 MILES ON IT. I HAVE OWNED IT SINCE NEW. MY CONCERN IS IN THE EVENT OF A CRASH, ALONG WITH THE DANGEROUS TAKATA AIRBAGS THAT I'M STILL WAITING TO BE REPLACED, WILL PLASTIC BE SENT THROUGH THE AIR FROM AIRBAG DEPLOYMENT?, OR WILL WE WAIT FOR SOMEONE TO BE INJURED OR KILLED TO GET GM TO RESOLVE THIS SITUATION.BY THE WAY GM HAS SENT ME A RECALL NOTICE AND TOLD ME THEY ARE WAITING ON PARTS. THAT HAS BEEN OVER 3 MONTHS AGO. I ALSO HAVE ANOTHER TRUCK FOR AIRBAG RECALL.JUST FOR THE RECORD MY WIFES 2007 CHEVY SILVERADO 1500 RECEIVED A CRACK IN THE DASH AT ABOUT 80,000 MILES. THIS IS AN EPIDEMIC BUT I SURE GM WILL ESCAPE AGAIN JUST LIKE IN THE PAST. IT TAKES ONE SMALL FRAGMENT IN THE RIGHT PLACE SUCH AS AN EYE TO CHANGE SOMEONES LIFE FOREVER. JUST THINK IF IT WAS SOMEONE YOU LOVED SITTING IN THAT TRUCK.

NHTSA ID

10947054

Incident

Jul 1, 2015

Mileage

80,000 mi

DASHBOARD CRASHESD NEAR FRONT PASSANGER AIRBAG THAT MAY POTENTIALLY ALLOW MOISTURE INTRUTION INTO THE PASSANGER AIRBAG INFLATOR SYSTEM

NHTSA ID

10928995

Incident

Nov 21, 2016

FRAME AT SWAY BAR MOUNT AND TRANSMISSION CROSSMEMBER RUSTING AWAY ON BOTH SIDES OF TRUCK

NHTSA ID

10914978

Incident

Oct 9, 2016

Mileage

75,000 mi

MY DASHBOARD HAS SEVERAL CRACKS EXPOSING THE ELECTRICAL COMPONENTS WITHIN THE DASH. THESE CRACKS ARE IN VARIOUS PLACES ACROSS THE ENTIRE DASH. I PURCHASED THIS VEHICLE BRAND NEW AND IT IS CURRENTLY IN EXCELLENT CONDITION (WITH THE EXCEPTION OF THE DASH) I AM CONCERNED THAT IF THE AIR BAG WERE TO BE DEPLOYED THE PLASTIC DASHBOARD WOULD EXPLODE AND EXPOSE MY PASSENGERS OR MYSELF TO ADDITIONAL HAZARDS WITHIN THE VEHICLE. I AM ALSO CONCERNED THAT THE ELECTRICAL SYSTEM IN MY DASH BOARD IS NOW EXPOSED TO ADDITIONAL HAZARDS DUE TO THE ADDITIONAL EXPOSURE TO THE SUN. I AM FILING THIS INCIDENT WITH THE HOPES THAT IT WILL HELP A RECALL TO BE ISSUED. I NOTICED THE FIRST SMALL CRACK IN 2011. I HAVE KEPT AN EYE ON IT OVER THE YEARS AND AS OF TODAY, THERE ARE EXPOSED OPENINGS IN THE DASH IN SEVERAL PLACES. UNTIL TODAY, I THOUGHT THAT I MIGHT HAVE JUST BEEN UNLUCKY, HOWEVER AFTER DOING SOME RESEARCH ONLINE, IT IS APPARENT THAT I AM NOT ALONE, AND THIS SHOULD BE RECALLED UNDER A MANUFACTURERS DEFECT. THANK YOU FOR TAKING THE TIME TO FILE THIS REPORT ON MY BEHALF. FEEL FREE TO EMAIL ME WITH ADDITIONAL INFORMATION AS NEEDED. BEST REGARDS. *TR

NHTSA ID

10903689

Incident

Sep 2, 2016

Mileage

131,879 mi

TL* THE CONTACT OWNS A 2008 GMC SIERRA 1500. THE CONTACT STATED THAT THE DASHBOARD HAD A CRACK FROM THE DASHBOARD TO THE AIR BAGS. THE DEALER AND MANUFACTURER STATED THAT THE CONTACT WAS LIABLE FOR THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 138,197.

NHTSA ID

10898025

Incident

Apr 14, 2016

Mileage

138,197 mi

THE PAINT IS PEELING OFF THE TRUCK AT THE HOOD AND TOP OF THE TRUCK. THE HOOD PEELED FIRST 2015. THE TOP OF THE TRUCK MAY, 2016

NHTSA ID

10883805

Incident

Jun 1, 2016

DASH PAD CRACKS IN BOTH UPPER CORNERS AROUND PASSENGER SIDE AIRBAG, TRUCK WAS PARKED, NOTICED CRACKS IN MORNING

NHTSA ID

10851818

Incident

Feb 14, 2016

Mileage

60,000 mi

BOUGHT THE TRUCK NEW IN 2008 .AFTER A YEAR TO 1 1/2 DEVELOPED CRACK IN DASH IN CORNER BY AIRBAG. HAD DASH REPLACED UNDER WARRANTY. DASH CRACKED AGAIN WITHIN 1 1/2 WAS OUT OF WARRANTY THEN AND THEY WANTED ME TO PAY A PERCENTAGE. I REFUSED TO PAY FOR THERE DEFECT

NHTSA ID

10820703

Incident

Jun 15, 2010

APPROX 26,000 MILES. THE CHROME HANDLES ON THE DOORS, 2 HAVE COME LOOSE. I CALLED THE CHEVY/GMC DEALER AND WAS TOLD IT WOULD BE A COST OF APPROX. $125 PER DOOR TO FIX.

NHTSA ID

10785190

Incident

Aug 19, 2009

Mileage

26,000 mi

AT 35K THE DRIVERS SIDE FRONT DOOR ACTUATOR FAILED AND WAS REPLACED UNDER WARRANTY. AT 40K THE PASSENGER SIDE DOOR ACTUATOR FAILED. I WAS TOLD THIS IS A COMMON PROBLEM WITH THIS VEHICLE DUE TO DEFECTIVE PARTS USED BY GMC. WITH NO ABILITY TO OPEN OR CLOSE THE PASSENGER DOOR FROM THE DRIVERS CONTROL, A POTENTIAL SAFETY ISSUE EXISTS. E.G. UNABLE TO PREVENT AN INTRUDER FROM ENTERING THE CAR AT A STOP LIGHT, OR ALLOW A SCARED CHILD TO EXIT AFTER AN ACCIDENT. *TR

NHTSA ID

10638572

Incident

Dec 8, 2010

Mileage

34,000 mi

DASH IS CRACKING IN MULTIPLE LOCATIONS. MY TRUCK IS HARDLY IN THE SUN AND I ALWAYS USE A SUN SHADE IN THE WINDSHIELD. THERE ARE SEVERAL CRACKS AROUND THE DASH AND I AM WORRIED THIS WILL HAVE AN IMPACT ON THE AIR BAG SYSTEMS. THIS IS UNACCEPTABLE FROM GMC. *TR

NHTSA ID

10561696

Incident

Mar 20, 2013

TWO LARGE CRACKS ON DASHBOARD. ONE IS ABOVE INSTRUMENT CLUSTER HUMP AND IT'S APPROXIMATELY 5" IN LENGTH. THE OTHER IS JUST ABOVE PASSENGER SIDE AIRBAG AND THAT ONE IS APPROXIMATELY 3" IN LENGTH. *TR

NHTSA ID

10482819

Incident

Jan 1, 2011

POWER DOOR LOCK FAILED ON DRIVER DOOR. YOU CAN NOT OPEN DOOR WITH OUT LIFTING HAND LATCH. THIS IS VERY DANGEROUS-- MEANING YOU CAN NOT OPEN DOOR BY DOOR HANDLE-- THERE IS NO OVERRIDE LIKE PROVIDED ON OTHER VEHICLES. OTHER DOOR FAILED 2 MONTHS LATER. TRUCK LOCKS AND UNLOCKS DOORS WHEN MOVING SHIFTER FROM PARK TO DRIVE, THERE IS NO PROGRAM OPTION TO DELETE THIS OPTION. SO YOU LOCK AND UNLOCK DOORS EVERY TIME YOU SHIFT TRUCK TRANSMISSION TO PARK OR IN DRIVE. THIS IS NOT NEEDED IN MY CASE, SINCE YOU CAN MANUALLY DO SAME. THIS IS MANUFACTURE DEFECT AND SHOULD BE RECALLED. *TR

NHTSA ID

10448301

Incident

Nov 16, 2011

Mileage

11,500 mi