Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 36 NHTSA owner-reported complaints for the 1999 GMC Sierra 2500. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 36 · page 1 of 2
2 YEARS AGO I HAD ALL OF THE BRAKE LINES REPLACED BECAUSE OF FAILURE DUE TO RUST AT A COST OF $1000.00 I BELIEVE THE CAUSE WAS POOR METAL IN THE BRAKE LINES AND THE WAY THE LINES ARE ATTACHED TO THE BODY & FRAME HELP TO CAUSE THE PROBLEM.
TRUCK WAS IN SHOP FOR UNRELATED MAINTENANCE. BRAKE LINE FAILURE OCCURRED WHILE MOVING TRUCK OUT OF SERVICE BAY. TRUCK IS CURRENTLY UNDRIVEABLE. MECHANIC INDICATED THAT THIS IS COMMON FAILURE AS LOWER QUALITY MATERIAL WAS USED IN THE BRAKE LINES. ADDITIONAL RESEARCH ON WEB INDICATED THIS IS A WIDESPREAD ISSUE. THIS IS THE FIRST I HAD HEARD OF THE PROBLEM. I AM THE ORIGINAL OWNER. I FEEL BLESSED THAT THIS FAILURE OCCURRED IN A NON-TRAFFIC SITUATION. I FREQUENTLY DRIVE THIS TRUCK IN HEAVY TRAFFIC ON I-94. THANKS,[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
GOT HARD ON THE BRAKES TO AVOID A DEER THAT HAD JUMPED OUT OF A DITCH AND THE BRAKE PEDAL WENT TO THE FLOOR AND BRAKES GAVE OUT. DEALER REPLACED ALL THE ROTTED LINES TO THE TUNE OF 1250.00. *TR
BRAKES FAILED AS BRAKE LINE CORROSION ALLOWED FLUID LEAK. THIS WAS FIRST OF MULTIPLE LINE FAILURES IN THE LAST THREE YEARS. THREE DIFFERENT FACTORY LINES FAILED THEN ONE TRANSMISSION LINE. THIS TRUCK IS NOT USED DURING WINTER AND WAS UNDER COATED MULTIPLE TIMES. NO OTHER PART ON THIS TRUCK IS CORRODED NEARLY AS MUCH AS EVERY STEEL LINE ON IT, INCLUDING THE GAS LINES( ALSO REPLACED JUST LAST YEAR) TRUCK RUNS AND DRIVES EXCELLENT EXCEPT FOR THIS CORROSION PROBLEM. *TR
WENT UP TO STORE AND FOUND OUT BRAKES WERE NOT WORKING, PEDAL GOING TO FLOOR. HAD TO AVOID WRECKING. HAULED IT HOME. PURCHASED AND PUT IN NEW MASTER CYLINDER. WENT TO BLEED THE FIRST BRAKE AND FOUND A RUSTED BREAK LINE OVER DRIVER SIDE REAR. COULD HEAR IT SUCKING AIR WHEN I WAS USING THE PUMP TO BLEED OUT OLD FLUID. GLAD THE TRAFFIC WASN'T BUSY. *TR
I WAS MAKING A RIGHT TURN OUT OF A PARKING LOT AND HEARD A LOAD CLUNK. WHEN I GOT HOME I WAS LOOKING FOR THE CAUSE OF THE BANGING AND FOUND THAT THE REAR LEAF SPRING SHACKLE HAD RUSTED SO BAD IT BROKE IN HALF. *TR
TL* THE CONTACT OWNS A 1999 GMC C2500 PICKUP. THE CONTACT STATED THAT WHILE TRAVELING DOWNHILL, THE BRAKES WERE APPLIED BUT THE VEHICLE DID NOT RESPOND. THE CONTACT HAD TO USE THE EMERGENCY BREAK IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS INSPECTED AND IT WAS DETERMINED THAT THE BRAKES LINES WERE COMPLETELY RUSTED. THE CONTACT SPOKE TO THE MANUFACTURER REGARDING NHTSA CAMPAIGN ID NUMBER: 00V345000 (SERVICE BRAKES: HYDRAULIC), BUT WAS TOLD THAT THERE WAS NO RECALL FOR THE VEHICLE. THE FAILURE AND THE CURRENT MILEAGES WERE 170,000. *TR
I WAS PULLING MY HORSE TRAILER AND WENT TO STOP AT A STOP SIGN AND MY TRUCK BRAKES WENT OUT AND I COULD NOT STOP. I ENDED UP BEING PUSHED INTO TRAFFIC AND ALMOST WENT OFF A CLIFF. MY STEP DAD CAME AND GOT MY TRAILER AND WE HAULED MY TRUCK BACK TO HIS PLACE. MY DAD AND STEP DAD STARTED LOOKING AT IT AND MY ENTIRE BRAKE LINE IS RUSTED OUT? I HAVE NOTICED SEVERAL WEBSITES STATING NUMEROUS INCIDENTS AND RECALLS? I NEED HELP! *TR
WHILE ATTEMPTING TO SLOW THE VEHICLE TO EXIT THE HIGHWAY, THE BRAKE PEDAL WENT TO THE FLOOR AND THERE WAS LIMITED BRAKING. THE VEHICLE HAD TO BE SLOWED BY DOWN SHIFTING. AFTER THE VEHICLE WAS OFF OF THE HIGHWAY, THE BRAKE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE MECHANICS FOUND THAT ONE OF THE STEEL BRAKE LINES HAD RUSTED AND RUPTURED CAUSING THE BRAKE FLUID TO LEAK AND THE REDUCTION IN BRAKING ABILITY. ALL OF THE STEEL BRAKE LINES ARE SEVERELY RUSTED AND NEED TO BE REPLACED DUE TO CONCERNS OF ADDITIONAL FAILURES. *TR
DRIVING AROUND TOWN AND WENT TO SLOW DOWN TO STOP AND THE BRAKE LINE TO THE RIGHT ( PASSENGER ) FRONT CALIPER STEEL LINE BLEW FLUID ALL OVER TRUCK AND PUMPED BRAKES UNTIL THE MASTER CYLINDER WAS ALMOST EMPTY . TRUCK STOPPED AFTER THIS AND TURNING INTO A GRASSY FIELD. THIS TRUCK NEEDS ALL THE LINE REPLACED!!! I BOUGHT THE TRUCK NEW 32,00.00 AND IT HAS DOLLAR STORE BRAKE LINES!! SAFE!!! *TR
WHEN I TILT THE STEERING WHEEL IN THE UPWARD POSITION ALL HEADLIGHTS GOES OUT/OFF,AND WHEN I TILTED IT TO THE LOWER POSITION ALL HEADLIGHTS COME ON.THIS IS VERY UNSAFE AND OTHER OWNERS OF THIS SAME VEHICLE NEEDS TO KNOW THE SAFETY RISK INVOLVE.THIS VEHICLE IS AVAILABLE FOR INSPECTION ANYTIME. *TR
GAS TANK STRAPS RUSTED THROUGH AND TANK IS FALLING OUT. *TR
BRAKE LINE BURST. THIS IS THE SECOND TIME, BUT A DIFFERENT BRAKE LINE. *TT
1999 GMC SIERRA K2500 4X4. AT JUST OVER 100K MILES THE ADVANCED RUST AND CORROSION ON MY STEEL BRAKE LINES IS VERY BAD. THESE ARE THE HARD GALVANIZED LINES THAT ARE IN THE ENGINE COMPARTMENT BENEATH THE BRAKE FLUID RESERVOIR NEAR THE FRAME, AND THE HARD GALVANIZED LINES THAT RUN ALONG THE INSIDE OF THE FRAME RAIL ON THE DRIVER SIDE (LEFT HAND SIDE OF THE TRUCK) FROM FRONT TO REAR. THIS STARTED A FEW YEARS AGO AND HAS GOTTEN PROGRESSIVELY WORSE. THE CORROSION IS IN THE FORM OF RUST THAT IS FLAKING OFF IN CHUNKS. WITH THE STEEL RUSTING AND FLAKING AWAY LIKE THIS, IT WILL COMPROMISE THE INTEGRITY OF THE BRAKE LINE, SIGNIFICANTLY REDUCING THE ABILITY FOR THE BRAKE LINES TO HOLD PRESSURE, AND AT SOME POINT MAY ULTIMATELY RESULT IN BRAKE FAILURE. I HAVE OTHER GM VEHICLES WITH MORE MILES THAT ARE OLDER I'VE HAD SINCE NEW AND THE BRAKE LINES HAVE VERY LITTLE SIGNS OF RUST AND CORROSION. I AM NOT HAPPY ABOUT THIS AS I TAKE VERY GOOD CARE OF MY VEHICLES AND THIS IS THE FIRST GM VEHICLE THAT I'VE SEEN THIS HAPPEN. I WILL HAVE TO STOP DRIVING THIS VEHICLE TO AVOID THE HIGH ACCIDENT RISK POTENTIAL THE RUSTED BRAKE LINES HAVE CREATED. *TR
DEALER REPLACED RUSTED OUT BRAKE LINES IN 2008. DEALER NOW SAYS BRAKE LINES NEED TO BE REPLACED AGAIN. BRAKE LINES FOR THIS VEHICLE ARE APPARENTLY MADE OF A MATERIAL THAT IS EXTREMELY PRONE TO CORROSION LEADING TO BRAKE FAILURE-WHICH OCCURRED TO THIS VEHICLE.
I WAS DRIVING MY DAUGHTER TO A FRIENDS HOUSE. WHEN THE PEDAL STARTED GETTING SOFT ,IT WAS JUST A 3 MILE RIDE ON 35 MPH ROADS. BY THE TIME I GOT HOME I HAD NO BRAKES AT ALL. HAD TO HAVE 5 BRAKE LINES AND 2 BRAKE CALIPERS REPLACED THEY WERE TOTALLY COVERED WITH RUST. *TR
I OWN A 99 GMC SIERRA 2500. WHILE PULLING A 9000 LB TRAILER MY BRAKES WENT OUT HAD ENOUGH TIME TO DOWN SHIFT AND USE EMERGENCY BRAKE TO BRING TRUCK TOO A STOP. UPON INVESTIGATION I NOTICED THE BLOWN BRAKE LINE AND LOTS OF CORROSION ON THE UNDER CARRIAGE OF THE VEHICLE THIS IS SOMETHING THAT NEEDS TO BE ADDRESSED. I HAVE OWNED OLDER VEHICLES AND HAVE NEVER SEEN SUCH RUST ON THE UNDER CARRIAGE LIKE THIS TRUCK HAS. ESPECIALLY THE BRAKE AND FUEL LINES. *TR
I HAVE A 1999 GM PICKUP WHILE 3 HRS FROM HOME I WAS COMING ONTO A TRAFFIC SIGNAL WHEN I APPLIED THE BRAKES I WAS NOT SLOWING DOWN I HAD TO USE THE EMERGENCY BRAKE AND LOWER GEARS TO PREVENT RUNNING INTO THE CARS AHEAD OF ME, WHEN I FINALLY STOPPED AND CHECKED FLUID I WAS EMPTY THE CLOSEST STATION WAS STILL MILES AWAY, LUCKY FOR ME I WAS ON FL ST RD 710 20 MILES FROM INDIANTOWN I STAYED IN THE SLOW LANE DRIVING AT 5- 25 MPH UNTIL I COULD GET FLUID. I HAD THIS PROBLEM ALL THE WAY HOME WITHOUT CRASHING. UPON INVESTIGATING I FOUND THAT MY BRAKE LINES HAVE RUSTED OUT, I AM NOW IN THE MIDDLE OF CHANGING THEM OUT AS I CAN'T AFFORD A MECHANIC AND NOW AM HAVING PROBLEMS TRYING TO FIX SO NOW I AM OUT OF WORK BECAUSE OF THIS. LAST NIGHT I HAPPENED TO BE WATCHING THE NEWS AND SEEN THIS. IF YOU WOULD LIKE TO SEE THE LINES I HAVE ONE OFF OUT OF 4 LINES MY HOPE IS A RECALL TO HAVE THESE FIXED BY SOMEONE THAT KNOWS HOW IF NOT I WILL DO MY BEST SO I CAN MAKE IT TO WORK. *TR
THE VEHICLE WAS COLD AND DRIVEN APPROX 1/2 MILE TO STOP LIGHT FROM HOME. I WAS LIGHTLY STEPPING ON THE BRAKE WAITING FOR A LIGHT TO TURN GREEN AND ALL OF A SUDDEN A BRIEF SURGE WHICH CAUSED ME TO HIT THE BRAKE HARDER AND THEN THE SURGE STOPPED. I COULD SEE THE TACH GO UP AS IF I HAD HIT THE ACCELERATOR. IN MY OPINION THIS SUDDEN ACCELERATION IS A COMPUTER ISSUE AND NOT A TOYOTA, FORD OR GMC ISSUE. WHO MANUFACTURES THE COMPUTER EQUIPMENT FOR THESE VEHICLES? IN MY CASE I JUST IGNORED IT BECAUSE NOTHING BAD HAPPENED BUT I THOUGHT THE NHTSA SHOULD KNOW. I HAVE NOT HAD THE PROBLEM SINCE. *TR
EMPLOYEE DRIVING 1999 GMC 2500 PICKUP TOWING A 2008 TOWMASTER TRAILER LOADED WITH A BOBCAT 325 MINI EXCAVATOR NORTHBOUND ON I-25 AT SAN FELIPE EXIT HEARD A POP, THINKING IT WAS A BLOWN TIRE, TRIED TO PULL OFF TO THE RIGHT SIDE OF THE ROAD. LOST CONTROL OF THE VEHICLE, HIT A PASSING CAR, HIT A GUARDRAIL, CROSSED OVER THE HIGHWAY THROUGH ANOTHER GUARDRAIL, DOWN THE CONCRETE EMBANKMENT TO THE ROAD BELOW. ON THE PICKUP BOTH FRONT TIRES WERE BLOWN OUT AS A RESULT OF LANDING AT THE BOTTOM OF THE EMBANKMENT (DOT #K2W8YD4A, DOM ???? COUNTRY OF ORIGIN: VIETNAM). RIGHT REAR TIRE HELD AIR, BUT TREAD WAS PEELED OFF(DOT# 4TW8YD4A, DOM 0806 COUNTRY OF ORIGIN: CHINA). LEFT REAR TIRE (DOT# H2W8YD4A, DOM 2906, COUNTRY OF ORIGIN: KOREA) REMAINED INTACT. ALL TIRES ON THE PICKUP WERE KUHMO ROAD VENTURE AT - LT265/75R16. THE RIGHT FRONT TIRE OF THE TRAILER WAS ALSO BLOWN OUT. AS A RESULT OF THE ACCIDENT THE TRUCK, TRAILER, AND EQUIPMENT WERE ALL TOTALED OUT, ALTHOUGH THANKFULLY THE DRIVER WALKED AWAY WITH NECK AND BACK INJURIES. DRIVER AND PASSENGER OF OTHER CAR ALSO RECEIVED NECK AND BACK INJURIES. ALL TIRES WERE CHECKED FOR PROPER TIRE PRESSURE BEFORE THE TRIP FROM LAS VEGAS, NM TO ALBUQUERQUE, NM AND AGAIN REINSPECTED BEFORE LEAVING ALBUQUERQUE WITH LOAD BACK TO LAS VEGAS, NM. *TR
A MAN CLIMBED INTO A COMMUNITY CENTER VAN (USED TO HAUL FOOD, ALL METAL AND NO SEATS IN THE BACK), ON A COLD NIGHT AND HE APPARENTLY SET A SMALL FIRE IN THE BACK, PRESUMED TO KEEP WARM. CHILD SAFETY DOOR LOCKS ON ALL DOORS PREVENTED HIM FROM GETTING OUT. EVIDENCE IN VAN SHOWED THAT HE TRIED TO KICK DOOR AND WINDOWS OUT BUT HE WAS UNABLE TO GET OUT. HE WAS FOUND DEAD IN THE VAN, WITH THE FIRE OUT. THE COMMUNITY CENTER REPORTED THAT AN EMPLOYEE HAD PREVIOUSLY BEEN TRAPPED IN THE VAN DUE TO THE CHILD SAFETY LOCKS. *TR
1999 GMC K2500 FUEL GAUGE GOES DOWN TO SHOW HALF A TANK AND STOPS THERE. SHOWS ERRATIC READINGS. VEHICLE CAN RUN OUT OF GAS AND APPEAR TO HAVE APROX. HALF A TANK. *TR
TL*THE CONTACT OWNS A 1999 GMC SIERRA 2500. THE CONTACT STATED THAT EVERY TIME HE APPROACHES A STOP AT APPROXIMATELY 10 MPH, THE ABS ENGAGES AND THE VEHICLE JERKS FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT IT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V379000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK). THE DEALER STATED THAT THE HUB BEARING NEEDED TO BE REPLACED AT THE COST OF $1,700. THE CURRENT MILEAGE WAS 120,000 AND FAILURE MILEAGE WAS 96,000. UPDATED 12/12/07
TL*THE CONTACT OWNS A 1999 GMC SIERRA WITH FTS WESTLAKE TIRES. WHILE DRIVING 40 MPH THE VEHICLE WOULD SHAKE AND VIBRATE. THE SERVICE MGR STATED THAT THE TIRES WERE OUT OF SPECIFICATION AND THEY WOULD BE UNABLE RESOLVE THE TIRE ISSUES. THE CURRENT AND FAILURE MILEAGES WERE 102,000.
DT: A HUMMING NOISE CAME FROM UNDER THE HOOD AFTER REMOVING THE KEY FROM THE IGNITION AND SHUTTING OFF THE ENGINE. THE VEHICLE WAS DRIVEN TO A GM DEALER, WHO NOTED THAT THE ANTI LOCK BRAKE PUMP WAS CONTINUOUSLY RUNNING. THE ANTI LOCK BRAKES WERE REPAIRED UNDER A RECALL, BUT THE PUMP WAS NOT COVERED BY THE RECALL. THE COST FOR A REPLACEMENT OF A BRAKE PUMP WAS $2,000 OR THE DEALER COULD PERFORM A CHEAPER PROCESS BY SIMPLY REMOVING ANTI LOCK BRAKE FUSE WHICH BYPASSED THE BRAKE PUMP. THE CONTACT OPTED FOR REMOVING THE FUSE DUE TO COST. THIS REMEDY WARRANTED THE ANTI LOCK BRAKES AS NON WORKING. SINCE THIS REPAIR THERE HAVE BEEN NO FURTHER PROBLEMS. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .