1998 GMC Sierra 3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1998 GMC Sierra 3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes433.3%
- Fuel system216.7%
- Tires & wheels216.7%
- Visibility18.3%
- Electrical18.3%
- Driver assistance18.3%
- Body & structure18.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
TL* THE CONTACT OWNS A 1998 GMC SIERRA 3500. THE CONTACT STATED THAT WHEN HE APPLIED HIS BRAKES TO RELEASE THE GEAR SHIFTER, THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR. THE BRAKE WARNING LIGHT ILLUMINATED IMMEDIATELY AFTER. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE BRAKE LINES HAD BURST AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 136,000. THE VIN WAS UNAVAILABLE.
ABOUT 4 YEARS AGO I HAD PROBLEMS WITH MY BRAKE BOOSTER SYSTEM ON MY TRUCK WHEN THE BRAKES FAILED AND IT WAS HARD TO STOP THE TRUCK. I HAD THE BRAKE BOOSTER REPLACED TWO TIMES THEN HAD TO HAVE THE POWER STEERING PUMP REPLACED AS THIS IS CONNECTED TO MY BRAKE SYSTEM. ABOUT A YEAR AFTER I HAD THIS WORK DONE GMC RECALLED THE POWER STEERING PUMP ON MY TRUCK. NOW I AM HAVE PROBLEMS WITH THIS SYSTEM AGAIN. IF I TURN MY TRUCK RIGHT OR LEFT THE BRAKE ACTIVATE JUST LIKE YOU ARE PUSHING ON THE BRAKE TO STOP. THIS HAS ALMOST CAUSED ME TO HAVE AN ACCIDENT MORE THEM ONCE. I UNDERSTAND FROM OTHER OWNERS THAT THIS SYSTEM HAS A LOT OF PROBLEMS WITH IT AND THE ONLY WAY TO FIX IT IS TO REMOVE THIS SYSTEM AND REPLACE WITH A DIFFERENT TYPE OF SYSTEM. I HOPE YOU CAN HELP ME AND OTHER OWNERS TO GET GMC TO REPAIR OUR BRAKES. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FUEL INJECTION SYSTEM IS CONTINUALLY FAILING. CONSUMER STATES THAT IT IS AN ELECTRICAL FUEL INJECTION SYSTEM, AND THE SENSOR HAS BEEN CHANGED. HAS BEEN TAKEN TO THE DEALER 3 TIMES. *AK
SMELL OF FUEL WHEN DRIVING VEHICLE, WHEN VEHICLE LEFT RUNNING PARKED, VEHICLE ENGINE COMPARTMENT CAUGHT ON FIRE AND DESTROYED THE VEHICLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
AT 65MPH VEHICLE STARTED MAKING A THUMPING SOUND. WHEN CONSUMER PULLED OVER AND STARTED FEELING AROUND TIRE TREAD WAS SEPARATING. RIGHT REAR TIRE HAD AT LEAST 1,000 MORE MILES TO GO. CONSUMER USED THE SPARE TIRE TO GO FIND A FIRESTONE DEALER WHICH THEY REPLACED AND BALANCED TIRE FOR FREE. CONSUMER OWNS A 1999 MOTOR HOME WITH A 98 CHEVROLET 3500 CHASSIS WITH ORIGINAL TIRES SIZE LT245/75R16 HAVING 34,000 MILES ON THEM.*AK *SLC
PE-00020 ORIGINAL EQUIPMENT ON A 1998, GMC, VAN 3500, TIRE SIZE LT24575R16. WHILE DRIVING 55 MPH ON THE HIGHWAY TREAD ON THE RIGHT REAR TIRE SEPARATED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
WINDSHIELD WIPERS CAME ON AND OFF INTERMITTENTLY WHILE DRIVING IN INCLEMENT WEATHER. THIS CAUSED POOR VISIBILITY. DEALERSHIP WAS CONTACTED AND STATED THAT VEHICLE WAS NOT UNDER RECALL.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
MAIN BATTERY CABLE FAILED CAUSING VEHICLE TO CATCH FIRE WHILE IDLING. NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
TL* THE CONTACT OWNS A 1998 GMC SIERRA 3500. THE CONTACT STATED WHILE THE VEHICLE WAS STOPPED WITH THE BRAKE PRESSED, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER FOR INSPECTION. THE CONTACT HAD NOT INFORMED THE DEALER, AND THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 120,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
SEVERE VEHICLE FRAME CORROSION/RUSTING OF FRONT FRAME EXTENSIONS, PARTICULARLY IN AREA OF STEERING BOX MOUNTING OF SEVERAL AGENCY OWNED 98-2000 YEAR MODEL CHEVROLET & GMC PICKUP TRUCKS. DISPOSITION IS SCRAPPING VEHICLES AS BEYOND ECONOMICAL REPAIR AND UNSAFE TO OPERATE. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .