1993 GMC Sierra Owner Complaints

RECALL SUBJECT: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY REPORT RECEIPT DATE: 04-05-1994 NHTSA CAMPAIGN: 94V044001 MANUFACTURE: GENERAL MOTORS CORP. SUMMARY: VEHICLES ALTERED BY PAS, INC. HAVE COMPRESSED NATURAL GAS FUEL TANKS THAT CAN DEVELOP STRESS CORROSION, WHICH CRACK THE E-GLASS WRAPPING. THIS STRESS CORROSION CRACKING CAN LEAD TO TANK RUPTURES. CONSEQUENCE: IF THE TANK RUPTURES, PERSONAL INJURY TO INDIVIDUALS IN OR NEAR THE VEHICLE MAY OCCUR. REMEDY: GM IS OFFERING TO EXCHANGE THESE VEHICLES WITH A COMPARABLY EQUIPPED 1994 GASOLINE 1/2 OR 3/4 TON GM PICKUP. IF THE OWNER CHOOSES NOT TO EXCHANGE THE NATURAL GAS VEHICLE, GM WILL REPURCHASE THE VEHICLE.

NHTSA ID

11044458

Incident

Nov 1, 2017

I WENT OUT ONE MORNING AND STARTED MY TRUCK AND HEARD A RATTLE NOISE COMING FROM THE ENGINE. I GOT OUT AND OPENED THE HOOD. ALMOST INSTANTANEOUSLY THE ENGINE BACKFIRED AND THE COOLING FAN BLEW APART AND FRAGMENTS OF METAL CAME THROUGH THE PLASTIC SHROUD AND INTO MY FACE AND HEAD CAUSING SERIOUS AND WOULD HAVE BEEN FATAL INJURY TO MYSELF. IF IT WERE NOT FOR THE FAST RESPONSE OF THE PARAMEDICS WHO FLEW ME TO THE HOSPITAL BY CHOPPER. I AM NOW BLIND MISSING AN EYE AND MY FACE AND HEAD ARE SCARED ALONG WITH POSSIBLE BRAIN DAMAGE. PLEASE DO WHATEVER IT TAKES TO KEEP THIS TRAGIC ACCIDENT FROM HAPPENING TO ANYONE ELSE. *TR

NHTSA ID

10531539

Incident

May 25, 2013

Mileage

210,000 mi

I PURCHASED A 1993 GMC SIERRA PICKUP FOR MY SON FROM MY FATHER WHO WAS THE ORIGINAL OWNER. MY FATHER TOOK VERY GOOD CARE OF IT MAKING ALL SCHEDULED MAINTENANCES AS WE HAVE DONE AS WELL AFTER PURCHASING IT. MY SON WAS ON HIS WAY TO SCHOOL WHEN ALL OF A SUDDEN THE STEERING COLUMN BROKE. HE WAS UNABLE TO STEER THE TRUCK AND HAD TO COME TO A COMPLETE STOP AFTER GOING APPROXIMATELY 50 MPH. LUCKILY HE DID NOT LOOSE CONTROL NOR DID HE CRASH HEAD ON INTO THE ON COMING LANE OF TRAFFIC. ONCE STOPPED HE COULDN'T GET THE IGNITION TO TURN OFF WITH THE KEY. HAD TO JIGGLE THE STEERING COLUMN AROUND TO SHUT OFF THE ENGINE. HE DID THIS WITHOUT THE KEY IN THE IGNITION. WE HAD THE TRUCK TOWED BACK TO OUR HOME AND ARE IN THE PROCESS OF FIXING IT. *TR

NHTSA ID

10263108

Incident

Mar 24, 2009

Mileage

220,000 mi

WHILE DRIVING IN RAIN WITH MY WIPERS ON LOW SPEED, THEY SUDDENLY STOPPED, JUST AS A TRUCK WAS PASSING ME, WITH THE ROAD WATER THROWN ON THE WINDSHIELD BY THE SEMI, I COULD NOT SEE THE ROAD AHEAD. I COULD SEE IN MY SIDE MIRROR THAT I WAS CLEAR ON MY RIGHT SIDE, SO I PULLED OVER ON THE SHOULDER AND STOPPED. I ALSO OWN A 1991 3/4 TON SILVERADO WHICH I HAVE HAD TROUBLE WITH THE WIPER DELAY FUNCTION, ALTHOUGH THEY HAVE NOT TOTALLY STOPPED AS THE SIERRA'S DID. I SPOKE WITH SOME OTHER GM TRUCK OWNERS WHO SAY THEY HAVE EXPERIENCED SIMILAR ISSUES WITH THE WIPER SYSTEMS OF THEIR TRUCKS, SOME AS FAR BACK AS 1988 MODELS. *JB

NHTSA ID

10152489

Incident

Mar 11, 2006

NHTSA RECALL CAMPAIGN 03V159000; GENERAL MOTORS ISSUED A WINDSHIELD WIPER MOTOR RECALL. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. HOWEVER, THE WINDSHIELD WIPERS WERE WORKING INTERMITTENTLY. *AK *SC *JB

NHTSA ID

10117811

Incident

Apr 11, 2005

WHILE DRIVING 45 MPH WINDSHIELD WIPERS CAME ON AND OFF OWN THEIR OWN. *AK WINDSHIELD WIPERS FAILED ON THREE SEPARATE OCCASIONS. GENERAL MOTOR CORPORATION (GM) ISSUED A SAFETY RECALL ON 1994-1996 GMC LIGHT TRUCKS, AND TRUCK'S WINDSHIELD WIPER CONTROL MODULE WAS REPLACED. *LA

NHTSA ID

10066997

Mileage

75,000 mi

DEFECTIVE WIRING HARNESS TO WINDSHIELD WIPER MOTOR, CAUSING WIPERS TO STOP RUNNING RANDOMLY.*AK

NHTSA ID

10068257

Incident

May 1, 2001

Mileage

74,000 mi

REPLACED THE TRANSMISSION 4 TIMES, RECALL ON SEATS WERE FIXED BUT BOLTS KEEP BREAKING SO I BOUGHT NEW SEATS OF A DIFFERNT STYLE AND REPLACED THEM AFTER A 5 YEAR PROBLEM. PAINT HAS BEEN FLAKING OFF THE TRUCK FOR APPOXIMATELY 4 YRS AND I CANT GET THE DEALER OR GM TO DO ANYTHING WITH THIS PAINT PROBLEM. THEY SAY IT IS BECAUSE I AM THE SECOND OWNER. THE TRUCK WAS IN AN ACCIDENT BUT THE TOP OF THE CAB AND THE BED IS ALL THAT NEEDS PAINTED, AND THEY WERE NOT DAMAGED IN ANYWAY BECAUSE OF THE ACCIDENT.

NHTSA ID

10071252

Incident

Oct 15, 2003

Mileage

150,000 mi

#1 TRANSMISSION. SLIPS OUT OF GEAR INTO NUETRAL WHILE DRIVING AT HIGHWAY SPEEDS. MUST COAST OVER TO SIDE OF ROAD, TURN OFF ENGINE, WAIT, RESTART AND CONTINUE ON. NARROWLY CAUSED A COLLISION WITH A SEMI TRUCK WHILE COASTING TO SIDE OF ROAD. COMPLAINED TO DEALER NUMEROUS TIMES, SAID THEY COULD NOT FIND ANYTHING WRONG. NOW TRANS IS LOCKED IN 2ND GEAR AND WON'T SHIFT TO A HIGHER GEAR. #2 PAINT. STARTED CHIPPING WITHIN 6 MONTHS OLD AND LESS THAN 2500 MILES. DEALERS SAID NOTHING COULD BE DONE. ROOF IS NOW RUSTED THROUGH AND HEADLINER IS HANGING DOWN. DEALER AND ZONE REP SAY GMC IS NOT RESPONSIBLE AND REFUSE TO REPAIR AND REPAINT. #3 SEAT BELT RETRACTOR. DRIVER'S SEAT BELT WILL NOT RETRACT AND IS VERY LOOSE. IT WOULD NOT PREVENT INJURY OR DEATH IF INVOLVED IN A CRASH. DEALER AND ZONE REP DENY RESPONSIBILITY AND REFUSE TO REPAIR EXCEPT AT MY EXPENSE. #4 RADIO. RADIO HAS BEEN REPLACED 3 TIMES BY THE DEALER SINCE NEW AND THEY REFUSE TO REPLACE OR REPAIR IT AGAIN. VOLUME MUST BE TURNED UP ALL THE WAY TO BE HEARD. THIS IS THE EXACT SAME PROBLEM WITH EVERY RADIO THEY SAY THEY HAVE REPLACED.

NHTSA ID

10071216

Incident

Nov 15, 2003

Mileage

1,500 mi

No narrative was included with this report.

NHTSA ID

10069489

Incident

Jun 15, 1999

Mileage

116,438 mi

WINDSHIELD WIPERS QUIT WORKING WHILE DRIVING IN A SNOW STORM. THIS RESULTED IN POOR VISIBILITY, WHICH ALMOST CAUSED AN ACCIDENT. CONSUMER HAD TO PULL OVER, AND HIT THE WINDSHIELD WIPER MOTOR FOR THE WINDSHIELD WIPERS TO START WORKING. RECALL 03V15900 WAS ISSUED, BUT THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK

NHTSA ID

10052267

Incident

Dec 29, 2003

Mileage

72,000 mi

WHILE DRIVING IN INCLEMENT WEATHER WINDSHIELD WIPERS CAME ON AND OFF ON THEIR OWN. *AK

NHTSA ID

10050576

Incident

Dec 15, 2003

PROBLEMS WITH VEHICLE SLIPPING OUT OF GEAR WHILE DRIVING.*MR THE VEHICLE WENT FROM DRIVE TO NEUTRAL WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO TOLD THE CONSUMER THAT A NEW TRANSMISSION WOULD COST HIM $4000.00 AND TO REBUILD AN OLD ONE WOULD BE $3000.00. THE CONSUMER HAS MADE ONGOING COMPLAINTS ABOUT THE VEHICLE AND FEELS THE COST OF THE TRANSMISSION SHOULD BE LOWERED. NOT ONLY HAS THE VEHICLE EXPERIENCED PROBLEMS WITH THE TRANSMISSION ,BUT THE ROOF OF THE TRUCK INCLUDING THE REPLACEMENT OF THE HEAD LINER THAT NOW HANGS DOWN WHICH WAS DUE TO THE ROOF LEAKING, THE CONSUMER HAD TO REPLACE THE DRIVERS SIDE SEAT BELT RETRACTOR AS WELL AS THE RADIO SYSTEM. *CB THE VEHICLE ALSO HAD A BROKEN SEAT BACK RECLINER, THE IGNITION SWITCH WOULD NOT TURN OFF, THE 4 WHEEL DRIVE WOULD NOT ENGAGE, THE SHOCKS WERE BAD AND THE VEHICLE WAS IN NEED OF AN ALIGNMENT. *JB

NHTSA ID

10051807

Mileage

1,500 mi

DRIVER'S SEAT BELT RETRACTOR WILL NOT RETRACT. SEAT BELT IS VERY LOOSE AND WOULD NOT PREVENT INJURY OR DEATH IN THE EVENT OF A CRASH. DEALER AND GMC ZONE OFFICE REFUSE TO ACCEPT RESPONSIBILITY AND/OR REPAIR THE RETRACTOR EXCEPT AT MY OWN EXPENSE. *LA

NHTSA ID

10046833

Incident

Oct 31, 2003

Mileage

37,000 mi

TRANSMISSION. COMES OUT OF DRIVE WHILE MOVING AND TRANSMISSION GOES INTO NEUTRAL. DRIVER MUST COAST OVER TO THE SHOULDER OF ROADWAY, STOP, TURN OFF ENGINE, WAIT SEVERAL MINUTES THEN RESTART ENGINE. CAN CAUSE A COLLISION WITH OTHER VEHICLES WHILE COASTING TO THE EDGE OF ROADWAY. HAVE BEEN COMPLAINING TO GMC FOR 10 YEARS WITH NO CORRECTION OF PROBLEM. I NARROWLY AVOIDED A COLLISION WHILE COASTING TO THE SIDE OF THE ROAD. *LA

NHTSA ID

10046763

Incident

Oct 17, 2003

Mileage

39,350 mi

FAILURES IN ELECTRICAL SYSTEM. RADIO,DASHBOARD LIGHT (SPEEDOMETER, ETC.),WINDSHIELD WIPERS. *LA

NHTSA ID

10045281

Incident

Aug 8, 2003

Mileage

87,510 mi

WHILE DRIVING THE WINDSHIELD WIPERS WORK INTERMITTENTLY CAUSING PROBLEMS ON THE HIGHWAY. THERE IS A RECALL ON SIMILAR VEHICLES BUT THE CONSUMER'S VIN NUMBER WAS NOT INCLUDED. *PH

NHTSA ID

10039923

Incident

Aug 19, 2003

Mileage

115,000 mi

THE WINDSHIELD WIPERS WERE INOPERATIVE. A RECALL HAD BEEN ISSUED, HOWEVER, IT DID NOT APPLY TO CONSUMER'S VEHICLE IDENTIFICATION NUMBER. *JB

NHTSA ID

10022453

Incident

Jun 5, 2003

WINDSHIELD WIPERS WERE EXPERIENCING THE SAME DEFECT AS STATED IN RECALL 02 V 280 000, BUT THIS VEHICLE WA SNOT INCLUDED IN RECALL DUE TO VIN. *AK

NHTSA ID

10022356

THE CONSUMER'S DAUGHTER WAS UNSECURING THE BELT BUCKLE ATTACH TO THE SEAT. WHEN SHE LIFT UP THE BUCKLE UP THE BELT RETRACTED FAST AND HIT HER INSIDE OF THE MOUTH STRIKING HER FRONT TOOTH. THE DEALERSHIP IS AWARE OF THE PROBLEM. MR

NHTSA ID

8020892

Incident

Feb 6, 2002

TIRE DEVELOPED A LARGE EGG SHAPED BUBBLE ON RIGHT, OUTSIDE HALF OF TREAD AREA. NOT ON SIDEWALL BUT DIRECTLY ON THE THREAD. THE VEHICLE STARTED TO ROCK VIOLENTLY FROM SIDE TO SIDE CAUSING THE RIGHT FRONT END TO DIP AND RISE RAPIDLY. I STOPPED IMMEDIATELY AND OBSERVED THIS BUBBLE. I DROVE THE REST OF THE WAY HOME, APPROXIMATELY 2 MILES. AT 10 MPH. WHEN I ARIVED HOME THE TIRE THEN DEFLATED BUT IT DID NOT BURST. THE TIRE IS FLAT BUT INTACT. IS THIS A TIRE YOU WOULD BE INTERESTED IN TESTING OR CHECKING OUT? PLEASE ADVISE. I CAN SEE FROM MY EXPERIENCE HOW THE CAR COULD OVER TURN DUE TO THIS INCREASING VIOLENT RISING AND DIPPING OF THE FRONT END. IF THIS OCCURRED ON A DIP AND THE BRAKES WERE APPLIED I BELIEVE IT WOULD CAUSE THE VEHICLE TO ROLL OVER VERY QUICKLY. THANKS JOHN. *AK

NHTSA ID

761584

Incident

May 5, 2000

TREAD CAME OFF OF THE TIRE. *AK (DOT NUMBER: MD11 T5H1 TIRESIZE: LT245/75R1)

NHTSA ID

750820

Incident

Jul 17, 2001

THIS WAS A RECALL ITEM-94-C-62(B). SINCE THE RECALL I'VE HAD THE TRUCK IN THE DEALERS SHOP 3 TIMES. THEY'VE REPLACED THE SAME SEAT BOLTS EACH TIME. THEY EVEN REPLACED THE SEAT THE SECOND TIME IN THE SHOP. THE LAST TIME IT TOOK OVER A MONTH AND DEALING WITH 3 GM CUSTOMER SERVICE PEOPLE TO GET GM TO PAY FOR IT. WHICH AT THAT TIME GM STATED THAT THEY WOULD NO LONGER PAY FOR ANY FURTHER SEAT REPAIRS. THIS SEAT FEELS LIKE IT MIGHT BE GETTING LOOSE AGAIN. AS THIS WAS A RECALL ITEM ARE THEY ONLY OBLIGATED TO REPAIR IT AS LONG AS THEY WANT? ONE OF MY CONCERNS IS WHAT HAPPENS WHEN IT BREAKS AGAIN? EACH TIME IT BREAKS, IT DOES SO WHILE DRIVING. IS THIS JUST AN ISOLATED EVENT OR ARE OTHERS EXPERIENCING THE SAME PROBLEM? GM CUSTOMER SERVICE TOLD ME MY REOCCURING PROBLEM IS THE ONLY ONE THEY HAVE HEARD OF RELATED TO THIS RECALL. THE DEALER THAT DID THE RECALL WORK IS ROYAL MOORE BUICK/GMC IN HILLSBORO OR.*AK

NHTSA ID

749956

Incident

May 17, 2001

1) DASH BRAKE LIGHT CONSTANTLY ON OR FLASHING, CODE = SHORTED ABS DEFECTIVE? 2) 4WD TRANSAXLE- SHIFTER FORK AND THRUST BEARINGS BROKEN. NO FORWARD OR REVERSE ON HIGHWAY-VERY DANGEROUS BREAKDOWN 3) ECM ELECTRONIC CONTROL MODULE FAILURE, PREVENTING THE 3-4 OVERDRIVE SHIFT IN THE TRANSMISSION-VERY HIGH RPM UNDER LOAD. 4) AUTOMATIC TRANSMISSION, NO REVERSE DUE TO LOSS OF PLANETARY GEAR SET (2) DUE TO DEFECTIVE WORKMANSHIP (DRIFT PIN SETTING GEAR IN HUB HAD WORKED OUT THEREBY GALLING AND MILLING OUT THE HUB AREA=LOSS OF PRESSURE AND BEARING STABILITY. 5) NYLON ROCKER ARM RETAINERS HAD FRACTURED AND BROKEN DUE TO DEFECTIVE MATERIALS, ALLOWS ROCKER TO FALL OFF ROCKER ARM SHAFT AND PUSH RODS TO FALL INTO CRANKSHAFT...ABRUBT ENGINE HALT AT HIGH SPEED...VERY DANGEROUS. 6) GLOW PLUG CONTROLLER DOES NOT ACTIVATE THE GLOW PLUGS AFTER HOT ENGINE SITS FOR ABOUT 15 MINUTES...ENGINE WILL NOT START. *AK

NHTSA ID

746508

Incident

Sep 30, 1998

WHEN 4 WHEEL DRIVE KICKED INTO NEUTRAL TRUCK ROLLED DOWNHILL TRUCK WAS IN PARK AND OFF. *AK

NHTSA ID

744998

Incident

May 5, 2001