2001 GMC Sierra Owner Complaints

05068A PRODUCT SAFETY RECALL FRONT WHEEL SPEED SENSOR CORROSION. MY VEHICLE WAS SERVICED FOR THIS RECALL IN 2006 WHICH INVOLVED REMOVING AND CLEANING THE ABS SENSOR AND REINSTALLING IT. NO REDESIGN WAS CREATED TO IMPROVE THIS FLAWED DESIGN. I'M HAVING THE SAME FAILURES DESCRIBED AND COVERED IN THIS RECALL. WHILE MOVING AT SLOW SPEEDS IN DRY CONDITIONS ABS KICKS IN AND INCREASES MY STOPPING DISTANCE. I HIT A PARKED CAR IN A PARKING LOT DUE TO THIS DEFECT. MY VEHICLE WAS IN MOTION AT <5MPH ON DRY PAVEMENT WHEN THE BREAKS WENT INTO 'ABS MODE' AND HIT A STATIONARY PARKED CAR. LUCKILY NO ONE WAS HURT. WHEN I CONTACTED GMC I WAS TOLD THAT THIS WOULD NOT BE COVERED UNDER THE RECALL BECAUSE IT WAS ALREADY SERVICED FOR THIS RECALL IN 2006 AND THAT THE ISSUE WAS THEREFORE CLOSED. IN MY CASE THE ORIGINAL RECALL WAS NOT ADEQUATE AND MY CAR BREAKS STILL FAILED EVEN THOUGH SERVICED IN 2006. I HOPE THIS DOESN'T START TO OCCUR WITH ALL OF THE VEHICLES THAT WERE SERVICED ~10 YEARS AGO WHICH IS WHY I'M FILING THIS COMPLAINT. LINK TO RECALL: HTTP://WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/JAXRS/DOWNLOAD/DOC/ACM5671334/RCRIT-05V379-9258.PDF

NHTSA ID

10811477

Incident

Dec 20, 2015

Mileage

250,000 mi

WENT TO STOP AT TRAFFIC LIGHT AND EXPERIENCED BRAKE LINE RUPTURE DUE TO EXCESSIVE RUST. HAD TO USE EMERGENCY BRAKE TO COAST TO A STOP. FORTUNATE NO CARS WERE IN LANE.$1200.00 FOR REPAIR OF LINES.

NHTSA ID

10764366

Incident

Sep 9, 2015

Mileage

134,000 mi

BRAKE PEDAL MOVED ALL THE WAY TO FLOOR WITH NO APPARENT HYDRAULIC PRESSURE WHICH FAILED TO ENGAGE BRAKES WHEN SHIFTING INTO DRIVE. INSPECTION OF BRAKE LINES BENEATH DRIVERS SIDE DOOR REVEALED EXCESSIVE RUST AND A HOLE IN STEEL BRAKE LINE LEAKING FLUID.

NHTSA ID

10723781

Incident

May 1, 2015

Mileage

145,050 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA. WHILE SELF-SERVICING THE VEHICLE, THE CONTACT DISCOVERED THAT THE SUBFRAME WAS CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10713981

Incident

Dec 31, 2014

Mileage

124,000 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT STATED THAT WHILE ATTEMPTING TO STOP, THE ABS FAILED AND THE VEHICLE STARTED TO PULL TO THE RIGHT. THE CONTACT DETERMINED THAT THE CAUSE OF THE FAILURE WAS A DEFECTIVE WHEEL SPEED SENSOR. THE VIN WAS NOT AFFECTED BY NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 105,000. ...UPDATED 06-11-15 *BF UPDATED 11/23/2015*JS

NHTSA ID

10700640

Incident

Jan 1, 2015

Mileage

105,000 mi

BRAKE LINE FAILED AND BROKE, UPON INSPECTION ALL BRAKE LINES WERE CORRODED AND BRITTLE, HAD TO REPLACE ALL BRAKE LINES. *TR

NHTSA ID

10692429

Incident

Feb 26, 2015

Mileage

118,000 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA. WHILE DRIVING 15 MPH, THE BRAKE PEDAL FAILED TO DEPRESS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE SENSORS ON THE FRONT OF THE VEHICLE FAILED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 70,000.

NHTSA ID

10671006

Incident

Oct 15, 2012

Mileage

70,000 mi

HEADING INTO PARKING SPOT AT WALMART , APPLIED BRAKES WOULD NOT STOP , HEADING HEAD ON INTO PARKED CAR , SLAMMED EMERGENCY BRAKE , PUT INTO NEUTRAL , FINALLY STOPPED . HAD TO HAVE TOWED TO MECHANIC BRAKE LINES ALL BURST DUE TO RUST , MECHANIC SAID COST TO FIX , APPROX. $1000 OR MORE ? WHICH I DON'T HAVE . THANK GOD I WAS GOING SLOW AND DIDN'T CAUSE ANY INJURY , POUR DESIGN AND POUR QUALITY PARTS PER MECHANIC ON GM'S PART , NOTICE A LOT OF COMPLAINTS ON THESE ERA OF TRUCKS. *TR

NHTSA ID

10667811

Incident

Dec 22, 2014

Mileage

219,844 mi

I PULLED INTO MY DRIVEWAY AND APPROACHED THE GARAGE, APPLIED BRAKES AND ALL THEY DID WAS VIBRATE AND MAKE THAT PULSE NOISE. NO MATER HOW HARD I PUSHED THE PEDAL, THE TRUCK WOULD NOT STOP AND I WENT THROUGH THE GARAGE DOOR AND ALSO KNOCKED OVER MY HARLEY THAT WAS IN THE GARAGE. I CANT BELIEVE THE AMOUNT OF COMMON STORY'S ABOUT THIS BRAKE ISSUE. THERE SHOULD BE A CLASS ACTION LAWSUIT. *TR

NHTSA ID

10667607

Incident

Dec 21, 2014

Mileage

223,000 mi

I WAS TRAVELING ON I-95 SOUTH IN VIRGINIA ON THE HOV LANES AT ABOUT 1:30 PM APPROACHING THE ROUTE 1 EXIT. TRAFFIC WAS DEAD STOPPED IN FRONT OF A MODERATE FLOW OF TRAFFIC AND EVERYONE QUICKLY SLAMMED THE BRAKES (INCLUDING ME) TO SLOW AND STOP TO PREVENT REAR ENDING THE STOPPED CARS. TRAFFIC WAS FLOWING AT APPROXIMATELY 75 MPH WHEN I SLAMMED MY BRAKES. THE BRAKES GRABBED MOMENTARILY AND THEN I HEARD A LOUD POP AND THE BRAKE PEDAL WENT TO THE FLOOR; THE VEHICLE BRAKES WERE GONE. NO PRESSURE WAS AT THE PEDAL EVEN AS I PUMPED IT. THE ONLY WAY OUT WAS TO HIT THE SHOULD AND BERM AND TAKE THE ROUTE 1 EXIT TO COAST TO A STOP; WHICH I DID. NO FLUID LOSS WAS EVIDENT AT THE MASTER CYLINDER RESERVOIR AND I COULDN'T SEE EVIDENCE OF A BLOWN LINE OR BRAKE CALIPER UNTIL I GOT THE VEHICLE HOME AND NOTICED THE METAL (STEEL) BRAKE LINE BETWEEN THE MASTER CYLINDER AND THE ANTI-LOCK BRAKE CONTROL VALVE/MODULE WAS LEAKING AT A PIT IN THE LINE CAUSED BY RUST. THE POINT WAS UNDER THE DRIVER SIDE FLOOR PAN ON THE OUTSIDE OF THE FRAME AND PARALLEL WITH THE FRAME. IT BLEW A RUSTED PITTED SPOT ON THE LINE UNDER PRESSURE.. *JS

NHTSA ID

10661777

Incident

Nov 24, 2014

Mileage

154,976 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THE BRAKE PEDAL WAS ENTIRELY DEPRESSED AND THE VEHICLE ROLLED INTO AN INTERSECTION. THE CONTACT STATED THAT THE EMERGENCY BRAKE WAS APPLIED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 227,570.

NHTSA ID

10639374

Incident

Sep 24, 2014

Mileage

227,570 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE BRAKES FAILED TO RESPOND. THE CONTACT HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE INDEPENDENT MECHANIC DIAGNOSED THAT THE BRAKE LINES HAD RUST BUILD UP. THE INDEPENDENT MECHANIC REPAIRED ONE BRAKE LINE. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

NHTSA ID

10628713

Incident

Jul 1, 2014

Mileage

170,000 mi

I WAS ON MY WAY HOME FROM AN EVENT THIS PAST SATURDAY HEADING TO DROP OFF MY SON. AFTER DROPPING HIM OFF I CONTINUED HOME. I WAS TRAVELING ABOUT 35 MPH WHEN THE LIGHT TURNED RED AND I DEPRESSED THE BRAKE AND WAS TERRIFIED WHEN IT WENT DOWN TO THE FLOOR. ALTHOUGH I HAVE AS ABLE TO COME TO A STOP WITHOUT INCIDENT I HAVE AS STILL TERRIFIED. I AM A DISABLED VETERAN WITH A HEART CONDITION AND COULD HAVE HAD A HEART ATTACK. I HAD MY TRUCK LOOKED AT BY MY CERTIFIED MECHANIC AND HE TOLD ME THAT MY BRAKE LINE RUPTURED DUE TO RUST AND IT WILL COST ME AROUND $1000.00 FOR REPAIRS. I HAVE HAD MANY MANY CARS AND TRUCKS IN MY LIFETIME AND NEVER EVER EXPERIENCED ANY PROBLEMS OF THIS NATURE. IT SEEMS TO ME THE MANUFACTURE WOULD ALLOW FOR THESE NORTHERN CONDITIONS WITH THE PARTS THEY USE IN PRODUCTION. *TR

NHTSA ID

10628182

Incident

Aug 23, 2014

Mileage

94,000 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT WAS DRIVING APPROXIMATELY 2 MPH WHEN THE BRAKES FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

NHTSA ID

10619248

Incident

Aug 6, 2014

Mileage

120,000 mi

EXPERIENCED COMPLETE FAILURE OF THE BRAKING SYSTEM. FORTUNATELY THE VEHICLE WAS ONLY TRAVELING 15MPH AND IN AN AREA THAT WASN'T CONGESTED WITH TRAFFIC. I WAS ABLE TO STOP BY USING THE ROADSIDE BERM BANKING AND AVOIDED ANY FURTHER DAMAGE. VEHICLE WAS TOWED TO A NEARBY GM DEALERSHIP WHERE IT WAS DETERMINED THAT BOTH BRAKE LINES HAD CORRODED SO BADLY IT CAUSED THE LINES TO RUPTURE RESULTING IN AN IMMEDIATE LOSS OF PRESSURE AND COMPLETE BRAKE FAILURE. JUST DAYS EARLIER I HAD THE BRAKES SERVICED AT A DIFFERENT GM DEALERSHIP NEAR MY HOME AND THERE WAS NO MENTION OF THIS CONDITION NOR THE PREVIOUS REPORTS OF THIS PROBLEM FROM OTHER OWNERS AS NOTED ON THIS WEB SITE. EVEN IF GM OR THE NHTSA DOES NOT DEEM THIS ISSUE FREQUENT ENOUGH TO ISSUE A TSB, AT MINIMUM A SERVICE WARNING/RECOMMENDATION SHOULD BE ISSUED TO GM DEALERSHIPS AND OTHER REGISTERED SERVICE PROVIDERS ALERTING THEM TO INSPECT FOR THIS CONDITION WHILE SERVICING THE BRAKING SYSTEMS FOR THESE MODEL YEARS. DEATH OR SERIOUS INJURY CAN AND MOST LIKELY WILL OCCUR AS THERE ARE MANY VEHICLES FROM THESE MODEL YEARS STILL ON THE ROAD. *TR

NHTSA ID

10610057

Incident

May 10, 2014

Mileage

72,495 mi

BRAKE PEDAL WENT TO FLOOD, HAD DIFFICULTY STOPPING TRUCK, LEAKING BRAKE FLUID. *TR

NHTSA ID

10585834

Incident

Apr 30, 2014

Mileage

149,000 mi

WHEN MY ISSUES STARTED, I WOULD FILL MY GAS TANK AND THE GAS GAUGE WOULD PLUMMET TO EMPTY. WHILE DRIVING, IT WOULD GO TO FULL, BACK TO EMPTY OR BE ANYWHERE IN BETWEEN. AT THAT TIME, THERE NO NO MECHANICAL ISSUES, JUST THE ANNOYING FACT THAT YOU HAD NO IDEA HOW MUCH FUEL YOU ACTUALLY HAD. THIS WENT ON UNTIL THIS SPRING, WHEN I HAD THE FIRST POTENTIALLY DANGEROUS INCIDENT. I WAS DRIVING DOWN A COUNTY HIGHWAY AT APPROXIMATELY THE SPEED LIMIT AND THE TRUCK'S ENGINE JUST SHUT OFF. NO POWER STEERING, NOTHING. IT HAPPENED JUST AS I WAS COMING TO A STOP SIGN THANKFULLY. I WAS ABOUT 50 MILES FROM HOME AND WAS ABLE TO CALL A FRIEND THAT MANAGES THE COLLISION CENTER OF A LOCAL CAR DEALERSHIP TO SEE ABOUT GETTING A TOW OR HIS OPINION AS TO WHAT WAS WRONG. AFTER ABOUT TEN MINUTES AND AFTER NUMEROUS ATTEMPTS, IT RESTARTED. I TALKED TO SEVERAL MECHANICS AND GOT THE SAME ANSWER FROM ALL OF THEM: THE FUEL PUMP AND SENDING UNIT FAIL IN GMC TRUCKS AROUND THE MILEAGE, 95,000 MILES, THAT I CURRENTLY HAVE ON THE TRUCK. THE GAS GAUGE IS STILL ERRATIC, I HAVE HAD TWO EPISODES OF THE VEHICLE STALLING AND NOW THE SERVICE ENGINE SOON LIGHT IS COMING ON AND WHEN IT IS PUT ON AN ANALYZER IT SAYS EMISSIONS, BUT THERE IS NOTHING WRONG WITH THE EMISSIONS SYSTEM. I HAVE ALSO TALKED TO OWNERS WHO HAVE HAD THEIRS REPLACED AND EVERYONE SAYS TO GET A FACTORY MADE PUMP BECAUSE THE CHEAP AFTERMARKETS BREAK DOWN EVEN QUICKER. I GOOGLED THE INFORMATION AND THE PROBLEM APPEARS TO BE WIDESPREAD. *TR

NHTSA ID

10576461

Incident

Jun 9, 2012

Mileage

86,000 mi

I HAVE A 2001 GMC SIERRA THAT HAS BEEN LOSING COOLANT FOR ABOUT 2 YEARS NOW. I WAS TOLD IT WAS A COMMON PROBLEM WITH THESE TRUCKS JUST WANDERING WHY NOTHING HAS BEEN DONE. *TR

NHTSA ID

10575996

Incident

Mar 29, 2012

Mileage

175,000 mi

IT WAS SNOWING AND ICY OUTSIDE. I ATTEMPTED TO BRAKE FOR AN UPCOMING RED LIGHT. THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR. I HAD VERY LITTLE BRAKING POWER. I STEERED TO THE CURB TO AVOID TRAFFIC IN THE INTERSECTION. I JUMPED THE CURB AND CAME TO A STOP AGAINST A POWER POLE. DAMAGE TO THE POWER POLE AND TO THE FRONT OF MY TRUCK. ONE OF THE STEEL BRAKE LINES RUPTURED. UPON CLOSER INSPECTION, ALL THE BRAKE AND FUEL LINES WERE SEVERELY CORRODED. *TR

NHTSA ID

10568693

Incident

Feb 24, 2014

Mileage

135,052 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA. THE CONTACT STATED THAT THE BRAKE PEDAL BECAME STUCK TO THE FLOOR BOARD WHILE ATTEMPTING TO DEPRESS THE BRAKES. THE CONTACT WAS ABLE TO STOP THE VEHICLE WITH AN ABNORMAL INCREASE IN STOPPING DISTANCE. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE REAR BRAKE LINE WAS LEAKING FLUID DUE TO CORROSION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 115,000.

NHTSA ID

10550519

Incident

Oct 31, 2013

Mileage

115,000 mi

STEPPED ON BRAKES APPROACHING YELLOW LIGHT ,SAILED RIGHT THOUGH LIGHT. *TR

NHTSA ID

10548012

Incident

Oct 14, 2013

Mileage

80,000 mi

THE WHEELS MALFUNCTION ENDING UP HITTING A COVERT THE AIR BAGS DID NOT DEPLOY

NHTSA ID

10525847

Incident

Jul 18, 2007

Mileage

1,700 mi

METAL BRAKE LINES RUSTED CAUSING BRAKES TO FAIL AND REPLACEMENT OF MASTER CYLINDER AND BRAKE LINES. *TR

NHTSA ID

10521500

Incident

Nov 9, 2012

Mileage

130,000 mi

THE FIRST DAY I NOTICED THAT THE BRAKE PEDAL WENT CLOSER TO THE FLOOR BEFORE THE BRAKES ACTIVATED. THE SECOND DAY THE PEDAL NEARLY TOUCHED THE FLOOR AND THEN THE BRAKE WARNING LIGHT CAME ON. I TOOK THE VEHICLE TO MY NEIGHBORHOOD INDY TIRE CENTER WHERE THEY QUICKLY DETERMINED BRAKE LINE FAILURE NEAR THE LEFT REAR WHEEL. THE BRAKE LINE HAD RUSTED COMPLETELY CAUSING A HOLE AND RAPID LOSS OF BRAKE FLUID. A NEW TEFLON COATED MAIN BRAKE LINE AND FITTINGS WAS INSTALLED ALONG WITH NEW BRAKE FLUID. OTHER BRAKE LINES WERE EXAMINE AND FOUND TO BE RUSTED BUT NOT COMPROMISED. THE TOTAL COST OF REPAIR WAS $461.38. *TR

NHTSA ID

10515788

Incident

Jun 7, 2013

Mileage

86,740 mi

BRAKES HYDRAULICS FAILED WHEN TRYING TO STOP. TRUCK IS IN THE SHOP NOW. THE CONSUMER STATED THE VEHICLE LOST HYDRAULIC PRESSURE WITHOUT WARNING. HE WAS TRAVELING 10 MPH TOWARDS A BUSY INTERSECTION. FORTUNATELY, HE WAS ABLE TO TURN INTO A PARKING LOT AND USE THE PARKING BRAKE TO STOP. THE REAR BRAKE LINES ON THE VEHICLE RUSTED AND LEAKED BRAKE FLUID, WHICH RESULTED IN THE LOSS OF PRESSURE. *TR

NHTSA ID

10513827

Incident

May 28, 2013

Mileage

90,000 mi