2018 GMC Terrain Brakes Problems

While driving my 2018 GMC Terrain, the vehicle suddenly displayed an “Engine Power Reduced” warning and the brakes became extremely hard to press. The vehicle experienced a sudden loss of normal power-brake assist while it was in motion, creating a serious safety risk because significantly greater pedal force was required to stop the vehicle. I was able to pull over safely. After stopping, the vehicle would crank but would not start. The vehicle was towed to a GMC dealership for inspection. The dealership documented that the vehicle had a suspected failed/broken vacuum pump, a damaged exhaust camshaft, and a damaged exhaust camshaft actuator. The dealership subsequently documented that the engine was severely sludged and stated that the sludge caused the vacuum pump to fail, which then caused the exhaust camshaft to twist and damage the exhaust camshaft actuator. The dealership’s written diagnosis recommends replacement of the exhaust camshaft, exhaust camshaft actuator, vacuum pump, and associated one-time-use parts. The dealership has also documented diagnostic trouble codes P0014 and P0017. The failed vacuum pump and related components should be available for inspection upon request. The vehicle has been inspected by a GMC dealership, which has documented the suspected vacuum pump failure and resulting engine damage. The sudden loss of power-brake assist occurred while the vehicle was being driven and created a potentially dangerous loss of braking capability. I am reporting this because I believe the failure of the vacuum pump and resulting loss of brake assist may represent a safety-related defect requiring investigation, particularly because the vehicle experienced a hard brake pedal without prior warning.

NHTSA ID

11755920

Incident

Jul 29, 2026

The contact owns a 2018 GMC Terrain. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the brake pedal was abnormally firm. The brake pedal was depressed to the floor, and the vehicle came to a stop. The check engine warning light was illuminated. The vehicle was towed to the dealer. The vehicle was not diagnosed. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 95,300.

NHTSA ID

11754433

Incident

Aug 2, 2026

Mileage

95,300 mi

Vehicle would slowly roll even when break is applied. It was confirmed by the service center that the break booster vacuum pump was only reading 8 when it should be at 27. It was not making enough pressure. The vehicle would not stop when break was applied.

NHTSA ID

11752244

Incident

Jul 22, 2026

The vehicle has had regular maintenance, oil change, and inspection including the brakes. My boyfriend is visiting me in [XXX] from the [XXX]. OnXXX while driving the vehicle the engine started. Making a ticking noise especially during idle and when accelerating in idle. About 15 minutes after the ticking stopped and all of a sudden there's a complete loss of breaks they locked up and the driver was unable to efficiently stop while going down a hill Road. Driver had to use the emergency brake to make the other brakes release and then the brakes from there would not work even though you could stomp on them stand on top of them there was no breaking power anymore. Vehicle was brought into a GMC dealership on the following Monday where they confirmed the issue was a failed vacuum pump connected to the engine and camshaft which is a known safety issue to GMC as part of an ongoing open case they had specialty coverage and bulletins regarding the Tahoe and Sierra but neglected to include the terrain on this issue. Cold the GMC manufacturer in both [XXX] and [XXX] to try and get cost assistance and specialty coverage as the vehicle as well under the mileage requirements but have been giving the push around and zero assistance. The risk to the drivers and passengers lives was significant as we were on the highway for1.5 hrand thankfully the brake lost didn't happen in full during that time. The repairs were completed and paid for in full by the client which should have been covered by the dealership and we are looking for cost recuperation and are now being ignored. Receipts are here to substantiate the claim. The ABS light is no longer on there was no warnings on the vehicle showing any issues or any codes as OnStar was called and diagnostics were received and the diagnostics came back clear prior to this happening, and following the break failure. Lack of codes and warnings is life-threatening and serious. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11751119

Incident

Jul 11, 2026

Vacuum pump that supplies vacuum to brake booster failed without any warnings beforehand leaving us without the ability to stop. Luckily was able to avoid an accident.

NHTSA ID

11742410

Incident

Jun 3, 2026

While traveling on the highway in traffic, brakes became very stiff when depressed after attempting to slow down to exit. Was able to put full bodyweight into the brake pedal to slow enough to exit and navigate to the gas station right off the exit. Had to roll stop signs and unsafely navigate traffic because brakes were not working. Service Brake System warning light came on after the incident.

NHTSA ID

11739875

Incident

May 24, 2026

The contact owns a 2018 GMC Terrain Denali. The contact stated while the contact's daughter was driving, the brake pedal was depressed, however the vehicle failed to stop as intended. In addition, the contact stated that the brake pedal was unusually hard when depressed. The vehicle was taken to the dealer where the vehicle was purchased. The contact stated that the service brake vacuum pump failed while the vehicle was at the dealer. The vehicle was diagnosed with a failed service brake vacuum pump and a failed engine. The contact was informed that the service brake vacuum pump, the CAM Shaft and the engine needed to be replaced. The vehicle was repaired. The contact stated that the failure was a known failure of the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 260,000.

NHTSA ID

11737294

Incident

Mar 15, 2026

Mileage

260,000 mi

We just got off the bus thruway and my brakes pedal got hard to press and it was hard to stop car I had to push on brake dry hard to get the car to stop it was jarring and o had to get my some and o to a safe place. Garage said it’s brake assist and he researched there’s is an active law suit against GM bc lots of Moses and models have this issue although they claim to know nothing about it

NHTSA ID

11726554

Incident

Mar 18, 2026

Faulty Brake Vacuum Pump!!!! 2018 GMC Terrain @ 119254 miles--- NO warning! Brakes were hard to press, did not work and I rolled into ditch to prevent an accident. I see hundreds of people with same issue now that I Am having to research. This was very scary. I was told it was as a brake booster pressure sensor. But that was not the problem. It is the brake vacuum pump. This is so dangerous. Why is GMC not correcting this issue? This is insane. GM issued multiple technical service bulletins on vacuum and booster issues starting in 2017. Why hasn't anything been done?

NHTSA ID

11721477

Incident

Feb 27, 2026

The contact owns a 2018 GMC Terrain. The contact stated that while driving approximately 30 MPH, the brake pedal became extremely difficult to depress, with the message "Brake Assist" displayed. The vehicle was driven to the shoulder of the roadway and the parking brake was activated, and the vehicle was turned off. The contact stated that the transmission failed to shift into gear, and the vehicle was dragged onto a flatbed truck and towed to the residence. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 132,386.

NHTSA ID

11703650

Incident

Dec 7, 2025

Mileage

132,386 mi

The contact owns a 2018 GMC Terrain. The contact stated that while driving at an undisclosed speed, the vehicle shuddered and failed to come to a stop while the brake pedal was depressed. The check engine warning light was illuminated. The vehicle was taken to a local independent mechanic, where it was diagnosed with a locked brake vacuum pump. The contact was informed that parts of the brake vacuum pump had entered inside the camshaft and valve cover. Several unknown local dealers were contacted. The vehicle was not diagnosed or repaired because there was no recall associated with the VIN. The manufacturer was made aware of the failure. The failure mileage was approximately 183,000.

NHTSA ID

11700844

Incident

Nov 12, 2025

Mileage

183,000 mi

The contact owns a 2018 GMC Terrain. The contact stated while driving at an undisclosed speed, the air bag and ABS warning lights illuminated. The vehicle was taken to Auto Zone to be diagnosed. The vehicle was diagnosed with air bag failure. The contact was informed that the air bag needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure; however, the contact was informed that there were no open recalls on the VIN. In addition, the contact was informed that once a recall repair was completed, it would not be performed a second time free of charge. The manufacturer was not made aware of the failure. The failure mileage was approximately 95,100.

NHTSA ID

11694159

Incident

Oct 3, 2025

Mileage

95,100 mi

April 2025, Vacuum Pump went out meaning lost breaks going 60 miles per hour down the road after engine light came on. Left me and two children stranded 2 hours from home with no way to get back except a tow. Now September 2025 Cam Shafts are out as well as Vacuum Pump. Stranded boyfriend and I two hours away again. Now metal in oil and warranty is not willing to cover it due to the vacuum pump going out. Made a post on Facebook and got lots of feedback on how their newer terrains have done the same things. Work in insurance and have people car pertaining to their terrains wondering if we cover engine replacements. There is major issues with these vehicle. Mine only has 107,000 miles on it and I have 12,000 left to pay. The motor is shot and dealership wants to “flush” the metal out of the engine. Very frustrated, I put 12,000 out of my college fund to have a reliable vehicle for my two kids and now this is all I have. A car that doesn’t run. I called warranty and the man I talked to even said that they get a lot of calls for these cars needing to be fixed. I am at a loss on what to do now. The below information about the incident is for the most recent one happening in September. I know that this sounds like a warranty and dealership issue but I guaranty if you send something out to terrain owners they will report major issues that they have had. Leaving them stuck in loans and no where to go.

NHTSA ID

11691195

Incident

Sep 7, 2025

Difficulty with power assistive braking when traveling at low speeds

NHTSA ID

11676088

Incident

Jul 18, 2025

Component Affected: Service Brakes, Hydraulic – Brake Vacuum Pump Summary of the Problem: I am reporting a serious safety issue involving the brake vacuum pump on my 2018 GMC Terrain. The brake pump failed catastrophically ("blew up"), resulting in a sudden loss of braking power. This occurred without warning and posed a significant risk to my safety and others on the road. We were traveling to vacation in Florida and thankfully had just gotten off the interstate. Details: The failure caused the brake pedal to become extremely hard to press, and the vehicle required a much longer distance to stop. We experienced no brake at the brake booster and a blown vacuum pump is due to a faulty vacuum pump which is a known issue for this model. Fortunately, no accident occurred, but the situation could have easily led to a collision. A certified mechanic confirmed that the brake vacuum pump exploded and needs to be replaced. I have incurred significant out-of-pocket repair costs due to this issue. We had to uber to our vacation room, get Walmart Plus to have groceries delivered to our room. We had to have Uber Eats deliver other supplies. We have had to walk to various places for dinner and entertainment because Avis and Budget had no vehicles available to rent and Enterprise was closed as we arrived on Saturday afternoon. I have checked for recalls and service bulletins using my VIN, but none are currently listed for this specific issue, despite similar problems being reported in other GM vehicles. Request: I urge the NHTSA to investigate this issue further. The failure of a critical braking component without warning is a serious safety concern. I believe this may be part of a broader pattern of brake system failures in GM vehicles and should be addressed through a recall or safety campaign. Also, the estimate for the repair is $2,500 so any reimbursement would be greatly appreciated. We just received this estimate but I can provide it at a later date.

NHTSA ID

11673291

Incident

Jul 12, 2025

My car started experiencing a strange problem while braking on June 15. I released the parking brake leaving my parents driveway. I coasted backwards (as usual), and when I pressed the brake the car didn't stop as expected and the brake pedal was very hard to press. It eventually stopped. I put into park, then put the emergency brake on, then released all and tried again and encountered the same issue, that it was very very slow to stop and the brake pedal was hard to push in. I got home, parked the car - tested the reverse brake on flat surface and didn't notice the issue. The next day, the problem started happening with the front brake as well and an error code popped up that said 'check brake assist' which I've never seen before. I brought it to my local mechanic, who took a look and said that it's a vacuum pump failure, and the result is a lot of metal shards were released into the engine when the vacuum pump failed. My mechanic recommended I take to a GMC dealer for further evaluation. I looked up the recall on this issue, and see that it impacts a lot cars, including the 2017 GMC terrain, but not my 2018 GMC terrain. I am going to take it to the GMC dealer but I'm afraid I won't be able to afford the repair, and it doesn't seem like there was anything I could have done to prevent this from happening.

NHTSA ID

11667521

Incident

Jun 17, 2025

Brake booster went out and lost all braking ability on interstate doing 65 mph in spring of 2022 - had brake booster and exhaust cam replaced and April 20 2025 same break and same effect - no braking ability at interstate speed - extremely dangerous situation

NHTSA ID

11655816

Incident

Apr 20, 2025

Brake vacuum pump failed causing engine damage. Camshaft on national back order. Vehicle has been in repair shop for 1.5 months waiting on part. No ETA. There has been recall for similar vehicles with same issue, failure, damage. But not for this VIN. It’s the same failure with same damage. How is this not a recall for this VIN?

NHTSA ID

11643291

Incident

Jan 1, 2025

The contact owns a 2018 GMC Terrain. The contact stated while driving at various speeds, the vehicle would not decelerate as intended while depressing the brake pedal. No warning light was illuminated. The vehicle was previously repaired at a local independent mechanic and the vacuum pump was replaced; however, approximately 32 days later the failure reoccurred. The local dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 58,000.

NHTSA ID

11640299

Incident

Dec 23, 2024

Mileage

58,000 mi

I was slowing down to turn and I couldn't push my brake pedal down it completely locked up. If I wasn't already slowing down I would've hit a power pole and potentially lost my life. My ABS light never came on and it's still not on. After I got parked and shut my car off the check engine light came on.

NHTSA ID

11638157

Incident

Jan 22, 2025

Faulty Brake Vacuum Pump triggered my brake to get stuck while I was driving ended on the side of the express way to avoid traffic and prevent a crash.

NHTSA ID

11633346

Incident

Dec 26, 2024

The contact owns a 2018 GMC Terrain. The contact stated while driving 40-45 MPH, the vehicle started coasting and stopped unintendedly. The contact stated that the vehicle drove for a while and then coasted and stopped. The message that the “Engine Power Reduced” was displayed. The contact stated that the brake system warning light was also illuminated. The vehicle was towed to an independent mechanic who determined that the camshaft had disintegrated into the engine. The mechanic informed the contact the vehicle was unrepairable. The vehicle was not repaired. The local dealer was not contacted. The manufacturer was not made aware of the issue. The failure mileage was approximately 60,000.

NHTSA ID

11633081

Incident

Dec 22, 2024

Mileage

60,000 mi

I got my car out of the shop a week ago for my brakes the car was in the shop for a month and this past weekend my car is doing the same exact thing a week later I was on I 75 also hit a semi truck

NHTSA ID

11633068

Incident

Dec 28, 2024

I have a 2018 Terrain SLT. On 11/20/24, I was headed home from my commute to work driving my terrain with all the confidence in the world because I hadn't had any major issue with it. In 5pm stop and go traffic I decided on another route to my son's school to pick him up from practice. As the light at the end of the bridge turned red, I proceeded to stop, and my brake pedal was as stiff as stone. Going across that bridge I was literally standing up on the brake pedal with my back and shoulder against the roof of the truck for support trying to stop. As I came close to the cars that had already stopped I contemplated jumping out of the car but I decided to keep at it. It was God and God alone that cleared a shoulder for me to be able to pull over. I was petrified!! No signs, no brake noises, no hesitations, nothing! No warning lights on the dash, no alerts, NOTHING! Brakes were just gone! The mechanic said the vacuum pump had exploded and it was a known issue with terrains and that there was a bulletin regarding this. Pieces of the metal from the exploded vacuum pump were found inside of the engine. The mechanic was upset about the event and said to notify GM, something needed to be done about it. He gave me the vacuum pump to show the GM service center and he said one of the mechanics took pics of the metal in the engine. I called GM and was told to bring it in to a GM service shop so that they could check it out, but at my expense because the manufacturer warranty had expired. I AM SO UPSET WITH GM!! I have anxiety every time I go to press the brake! Panic attacks thinking about the possibility of this happening with my kids/elderly parents in tow. Thank God for covering me and all the drivers and their families that could have been hurt. Thank God my son/elderly parents weren't in the car! The fact that this is a known issue and it hasn't been addressed is heartbreaking. GM should do the right thing and recall these trucks, asap.

NHTSA ID

11630230

Incident

Nov 20, 2024

The vacuum pump exploded and I lost power braking ability while going approx. 40mph. If I hadn't pressed down hard on the brakes to slow down, in less than 2 minutes I would have ended up in Lake Michigan, as I was heading east toward the on ramp for [XXX]. The problem has been confirmed by European US Auto here in Chicago, and I have photos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11628389

Incident

Nov 25, 2024