RoadVitals

1992 GMC Typhoon

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Aug 18, 2005
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest May 19, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 3 NHTSA owner-reported complaints for the 1992 GMC Typhoon, most frequently naming the brakes, other / unspecified and seat belts categories. 3 safety recalls have been issued covering this model year; and 1 NHTSA investigation names it.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Brakes233.3%
  • Other / unspecified116.7%
  • Seat belts116.7%
  • Transmission116.7%
  • Visibility116.7%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06E043000

FUEL SYSTEM, GASOLINE

May 19, 2006
88,303 units potentially affected
The defect: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
The risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
The remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
HONEYWELL INTERNATIONAL, INC.View on NHTSA.gov
06E041000

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

May 18, 2006
7,800 units potentially affected
The defect: CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED VALVE WHICH WAS NOT INSTALLED AT THE PROPER TORQUE.
The risk: A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE.
The remedy: R&B, INC. WILL NOTIFY OWNERS AND AT THE CUSTOMERS REQUEST, EITHER REPLACE THE FUEL LINE OR OFFER A FULL REFUND. THE RECALL BEGAN ON MAY 4, 2006. OWNERS MAY CONTACT R&B, INC. AT 215-712-5330.
R&B, INC.View on NHTSA.gov
91V207000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Nov 25, 1991
401 units potentially affected
The defect: THE LINK CONNECTING THE ELECTRONIC REAR HEIGHT SENSOR TO THE REAR AXLE CAN DISCONNECT UNDER SEVERAL CONDITIONS, ALLOWING THE ARM ATTACHED TO THE SENSOR TO LODGE BETWEEN THE REAR AXLE ASSEMBLY AND THE RIGHT REAR BRAKE PIPE. THIS ABRADES THE BRAKE PIPE AND COULD LEAD TO REAR BRAKE FAILURE.
The risk: ABRASION OF THE BRAKE LINE COULD RESULT IN LOSS OF REARBRAKES. THE FRONT BRAKES WOULD FUNCTION, BUT THE VEHICLE WOULD NEED INCREASEDSTOPPING DISTANCES WHICH COULD RESULT IN AN ACCIDENT.
The remedy: INSTALL RETENTION CLIPS TO INSURE THE LOWER AND UPPER BALL SOCKET CANNOT BE REMOVED FROM THE BALL; ADD A DOWN STOP ON THE SENSOR ARM; AND ADD A SHIELD ON THE REAR AXLE.
PAS, INC.View on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

EA94038ClosedEngineering Analysis

ABS BRAKING SYSTEM

Opened Oct 31, 1994
Closed Feb 28, 2000

THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.

SERVICE BRAKES, HYDRAULICLed to recall 99I006000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Other / unspecified
Filed Aug 18, 2005

DT: THECONTACT OWNS A 1992 GMC TYPHOON. ABOUT TWO YEARS AGO, THE LEFT REAR TIRE CAME OFF WHILE THE CONSUMER WAS DRIVING THE VEHICLE. INSURANCE COMPANY COVERED THE REPAIRS. THE CONSUMER STATED THAT ABOUT A MONTH AGO THE LEFT FRONT TIRE CAME OFF OF THE VEHICLE WHILE HIS WIFE WAS DRIVING THE VEHICLE. THE INSURANCE COMPANY COVERED THE REPAIR OF THIS WHEEL. THE CONSUMER STATED HE WAS DRIVING THE VEHICLE AFTER HAVING THE VEHICLE FOR ABOUT 3 HOURS THE WHEEL CAME OFF AGAIN. THE SERVICE DEALER HAS NOT SAID WHY THE WHEELS KEEP COMING OFF.*AK

NHTSA ID
10133291
Incident
Aug 12, 2005
Mileage
135,000 mi
BrakesSeat beltsTransmission
Filed Sep 1, 2000

AT SLOW SPEEDS, BRAKES UNDER SOME CIRCUMSTANCES PROVIDE NO STOPPING POWER. AT HIGHER SPEEDS, ANTI-LOCK ALLOWS BRAKE PEDAL TO TRAVEL TO FLOOR. COMPLAINED TO DEALER SEVERAL TIMES. EVENTUALLY TOLD OF RECALL IN NOV. 1999. NOTHING DONE YET. REAR SEAT BELTS UNWIND BUT FAIL TO REWIND SLACK. TOLD DEALER AND THEY WANTED $100 EACH TO REPLACE. TORQUE CONVERTER HAS BEEN REPLACED TWICE AND IS SHAKING AND SHUDDERING A THIRD TIME. OVER $1000 TO FIX.

NHTSA ID
729930
BrakesVisibility
Filed Feb 4, 1996

WINDSHIELD WIPER FAIL INTERMITTENTLY.

NHTSA ID
529845
Incident
Apr 3, 1992

Compare model years

Complaint and recall counts across every year of this model

GMC Typhoon by model year
YearComplaintsRecallsInvestigationsIssue Index
1993831—
1992Viewing331—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.