2024 GMC Yukon Engine Problems

After having the recall inspection completed and changing to the recommended higher grade of motor oil, 0W40, my engine failed while driving on a major highway. We were traveling at high speed on a busy highway when the engine failed and the Yukon shifted into neutral leaving me little time to pull off the road. When the failure occurred the Yukon shifted itself into neutral and a message appeared telling me to press start again. I was able to get to the side of the roadway and called the State Police for assistance. Six of us stood on the Side of this major highway for 90 minutes waiting for a tow truck. Since the incident the engine has been replaced by the dealer but I am concerned that this may happen again. After the recall inspection they tell you that you are ok but clearly you are not, you are still in danger.

NHTSA ID

11765869

Incident

Aug 4, 2026

Our Yukon was taken in for the recall. Dealer did the test and said it passed and used different oil. My wife and kids were driving to [XXX] from [XXX] yesterday. As they exited the highway, the car began acting weird. Then the car completely died. It was towed due to error code P0016. Dealer said they are going to put a new engine in. I saw online that cars with replacement engines were failing too? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11762331

Incident

Sep 4, 2026

Issues with the google voice, transmission issues, engine failure to start or restart. Reported same year vehicle was bought. Repeatedly. Dealership even with video evidence stated could not repeat issue and nothing wrong. My car then starts rattling in the engine and they do a full replacement had it for over three months. Now it’s leaking fluid and smoking. They try to send the consumer away and delay delay until the warranty is over. Unethical practices. They knew there was an issue with my engine as it was on the recall list but kept denying any issues until complete failure. Now less than 20 days after that repair the car is leaking and smoking.

NHTSA ID

11760762

Incident

Jun 11, 2026

Vehicle has 43k miles on it and a has a failed oil pump, already switched to the heavier oil and still have engine issue

NHTSA ID

11760663

Incident

Aug 14, 2026

My 2024 GMC Yukon Denali equipped with the 6.2L L87 V8 experienced an engine failure on July 4, 2026. Prior to the failure, there was no visible damage, warning, or other evidence that the engine was about to fail. I drove the vehicle to purchase fireworks and shut the vehicle off normally when I arrived. When I returned to the vehicle after shopping, the engine problem became apparent. There had been no noticeable indication of an engine failure before I turned the vehicle off. The vehicle was subsequently taken to a GM dealership, where the engine failure was confirmed and ultimately required replacement of the 6.2L L87 engine. The vehicle remained out of service from July 4, 2026, until it was returned to me on August 21, 2026. The original failed engine was in the possession of the servicing GM dealership I purchased the car from. Not even 8 months later of purchase the vehicle needed a 3rd engine (original, recalled engine, warranty engine). The lack of warning before the failure is a significant safety concern to me. The vehicle had been operating immediately before I parked it, and there were no apparent symptoms that would have alerted me that a major engine failure was imminent. Had the failure occurred while the vehicle was traveling at highway speed or in traffic, the sudden loss of engine operation could have created a dangerous situation. The failure was confirmed by the GM dealership and resulted in replacement of the L87 6.2L V8 engine. I am submitting this complaint to document the failure and because of continuing concerns regarding the L87 6.2L V8 and the effectiveness and long-term reliability of the recall remedy. I am still currently waiting for the repair work documentation for the new (assuming it was new) motor. I have attached attempts to talk to GM, app incidents, repair work being completed.

NHTSA ID

11760544

Incident

Jul 4, 2026

Complete engine failure, recall was performed before engine failed on highway with family inside.

NHTSA ID

11760484

Incident

May 15, 2026

Hello, I own a 2024 GMC Yukon Denali with the 6.2L V8. Car currently has 35,000 miles on it. At about 30,000 miles we started to feel a very aggressive vibration in the passanger seat, as well as the 2nd row seats, and driver seat. We took the vehicle in for the recall on the engine where we were instructed to put 0W-40 oil in. Much higher vescocity. After we did this recall the vehicle has not stopped shaking. We went for another service visit in July where we were told " this is the engine pistons trying to conserve fuel, and are firing causing the vibration." I have worked in the auto industry for 12 years, this is not a normal vibration. This should also not be caused by an engine. We then took it in again where they then proceeded to replace fuel manifold on August 18th. The vehicle shakes a bit less but still has a aggressive shake to it. I do not believe this is normal and if it is the engine pistons firing or the crank shafts misfiring, this could cause the engine to have catistrophic failure. This shake happens at speeds anywhere from 18 MPH to 50 MPH. My concern is with my wife and kids in this vehicle as the daily driver and this engine fails.

NHTSA ID

11760473

Incident

Mar 17, 2026

Driving about 75 mph car shuttered and motor quit running had to pull off of the highway and get towed to dealership. Motor had to be replaced due to 1,2,6,7 rod bearings spun on the crankshaft. 34367 miles

NHTSA ID

11760441

Incident

Jul 30, 2026

The contact owns a 2024 GMC Yukon. The contact stated that while her husband was driving at approximately 45–50 MPH, the vehicle stalled. No warning light was illuminated. The driver pulled over to the side of the road, and the vehicle was towed to the dealer, where it remained for five weeks before being diagnosed. The dealer determined that the engine was blown and needed to be replaced. The vehicle was repaired at the owner's expense. The contact associated the failure with NHTSA Action Number: EA25007 (Engine, Engine and Engine Cooling). The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 63,073.

NHTSA ID

11759639

Incident

May 18, 2026

Mileage

63,073 mi

Engine locked up and seized traveling 75mph on interstate with only 28,000 miles

NHTSA ID

11759549

Incident

Jun 25, 2026

This is a supplemental report to my original complaint (NHTSA ID XXX) regarding my 2024 GMC Yukon (VIN [XXX]). I am providing additional detail: prior to GM's recall being issued, I contacted Hatchett Buick GMC by phone and visited in person on multiple occasions reporting engine sputtering, stalling, hesitation, and total loss of power and electrical shutdown while driving. I was repeatedly told these were minor issues not affecting anyone and not to worry about them. As a result, the vehicle was not formally serviced for these issues until September 2025 — roughly three months after the recall was finally announced, more than a year after I purchased the vehicle. Since that recall repair and a subsequent "best guess" repair performed by GM technicians (their own description, not mine), the vehicle continues to sputter, hesitate, stall, and intermittently lose power. I have ongoing safety concerns driving this vehicle INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11759361

Incident

Jun 11, 2026

The 6.2 GMC engine has been replaced. I took my Yukon in for a oil change, on the second engine, the tech said that it now has a new oil synthetic 0-40, and I have to have the oil changed every 3 thousand miles. I checked with a couple of mechanics and they all said, synthetic is good for at least 5 thousand miles, and just thicker oil will not solve the engine problems that have plagued GM. I am bringing this to your attention as these vehicles are pretty much worthless in the marketplace, and as such GM should refund or exchange for the 2027, with the new motors.

NHTSA ID

11759183

Incident

Aug 21, 2026

The engine began knocking on startup and on acceleration. The vehicle would sometimes have difficulty accelerating. Upon taking it to the dealership, they were able to duplicate the issue. Upon inspection by the dealership, 2 rod bearings had spun and caused crankshaft damage. The manufacturer approved a full engine replacement under the warranty. There were no warnings lights, messages, or any other symptoms of the problem prior to the first incident.

NHTSA ID

11758834

Incident

Jun 22, 2026

I have a 2024 GMC Yukon Denali equipped with the 6.2L L87 V8 engine. The vehicle has approximately 23,000 miles. The vehicle previously underwent the remedy associated with the L87 engine recall. The engine now uses SAE 0W-40 dexos R oil and has the corresponding 0W-40 oil fill cap. After the recall remedy was performed, the check-engine warning light began intermittently FLASHING while I am driving. The light may flash for a period of time and then turn off again. I have also intermittently experienced the engine running rough or the vehicle shaking while idling. I have noticed the flashing warning light occurring while the engine is under load, including while driving uphill. I have video documenting the check-engine light flashing while the vehicle is being driven. Because the condition is intermittent, the warning light is not necessarily illuminated afterward. I am concerned because this vehicle is equipped with the L87 engine that was subject to GM recall N252494000/NHTSA Recall 25V-274 for potential engine damage/failure, and my vehicle appears to have already received the recall remedy. I understand NHTSA is currently investigating reports of L87 engine failures occurring after completion of that recall remedy. The cause of my vehicle's current symptoms is UNKNOWN and has not yet been diagnosed. The vehicle is available for inspection. I am filing this complaint because an intermittently flashing check-engine warning, rough/shaking operation, and the possibility of an engine malfunction or loss of propulsion present a safety concern, particularly if an engine failure occurs while the vehicle is being driven. I do have an appointment with a different GMC dealership for next week instead of the GMC dealership that sold it to me and preformed the original fix.

NHTSA ID

11758179

Incident

Aug 17, 2026

I am reporting a serious safety defect and unreasonable delay in addressing it under safety recall N252494000 (L87 Engine – Loss of Propulsion). My GMC Yukon has an illuminated check engine light and is now also overheating. According to GM’s own customer service r, this can lead to knocking, unusual engine noises, hesitation, high RPMs, abnormal shifting, reduced propulsion, and sudden loss of propulsion while driving, increasing the risk of a crash. I have contacted multiple dealerships for urgent repair: Cappllino GMC Keller Chevrolet Joe Basil All three have advised me that they do not have enough technicians to get my vehicle in for repair. Each has urged me to continue driving the vehicle despite the active check engine light and recall, and all have refused to provide a loaner vehicle. I have also contacted GMC Corporate directly for intervention. Instead of providing a loaner or expediting repairs, they have only offered post-repair rental reimbursement (up to $44/day after a repair order is opened). This leaves me with no safe transportation option. I have been told I can “drop off” the vehicle, but I have no alternative way to get home or to work. GMC and its dealerships are putting my safety (and the safety of other road users) at serious risk by directing me to continue operating a recalled, overheating vehicle with an active check engine light while refusing to provide any loaner or timely repair. My vehicle has 34,700 miles and is nearing the end of its warranty coverage, which raises additional concerns about potential delay tactics. Please review: The L87 engine defect and related check engine/overheating issues in GMC Yukons. GMC’s handling of this recall, including widespread failure to provide loaners and instructions to customers to keep driving defective vehicles. I authorize the release of my contact information to GMC to assist with the investigation. Attachments I can provide: Screenshots of communications with GMC

NHTSA ID

11751474

Incident

Jul 8, 2026

This truck has the 6.2 GM engine. While driving it late at night at approximately 28mph the engine blew, leaving the truck in the lane and unable to move. This was very dangerous since there was no warning and it just died. The truck receives regular maintenance by GMC and was tested to see if it was a “bad engine” and we were instructed that it wasn’t. GM said it will take 4-8 weeks to get an engine and the value of the truck to trade in is very low due to “marketing issues” which in my opinion is their issue not mine. I am battling stage 4 cancer and just had an operation and need a car to go to the doctors. They have officially said that they don’t have a truck to loan me. This has been going on for years apparently and the government is not doing anything to rectify it for the US tax payers per my research. I need a truck and GM said that they would get back to me within 24-48 hours, we are way past that. What is the government going to do, these trucks are not safe. What if I was traveling late at night to snowmobiling and it blew, it would be a different story. Need some help

NHTSA ID

11746964

Incident

Jun 18, 2026

At 35k miles our 2024 Yukon Denali with a 6.2L engine blew on a roadway with no known warning. Extremely dangerous situation with my pregnant wife and child in the car.

NHTSA ID

11745348

Incident

Jun 17, 2026

On our way home from vacation our engine failed and stranded us. This is the second engine that has failed and the vehicle only has 30220

NHTSA ID

11741129

Incident

May 31, 2026

I would like to document it took 7 trips to set the monitors after a failed smog check. That is 21 time going from 55 miles a hour to coasting to 20 miles a hour. on a freeway. Three times per trip at 2:00 - 3:00 in the morning. Also my Catalytic Converter went out at 26,000 miles. It should last 70,000 - 100,000 miles or 10 years. Catalytic Convertor was replaced by dealer. Will i have to replace it every 26,000 miles?

NHTSA ID

11740704

Incident

Apr 2, 2026

My engine ticks, and during the winter, I noticed white smoke coming from exhaust pipes in cold and warm weather. I believe there may be an issue with my engine. My vehicle is not on the list provided, and I’m concerned that the dealership responsible for my oil change package will not identify the problem, possibly because newly hired mechanics may lack the experience to make an accurate diagnosis. I’m afraid my vehicle will be overlooked intentionally.

NHTSA ID

11738051

Incident

Oct 8, 2025

For the third time, my vehicle died on me while I was driving; 2 of those times were on the highway going highway speeds. The last (3rd) time, I was towing my travel trailer/RV on the highway. In all incidents, the engine stopped propelling the vehicle. I could see and hear the engine revving but I failed to accelerate. After various warnings on the dash, I was able to pull safely off the road and then the engine just stopped, and nothing else worked. It failed to restart. This could have been a potentially dangerous situation because had I not been able to safely pull over, I would have been rear-ended. My vehicle was not part of the L87 recall for the 6.2L GM engines but the symptoms sound the same as those that were. The recall probably should have been expanded beyond the dates that GM originally included.

NHTSA ID

11737396

Incident

May 3, 2026

Engine suffered catastrophic failure without warning while traveling highway speeds after being cleared during recall check and suggested oil viscosity change. Most recent dealer performed service on 4/3/26 showed no mechanical issues and engine failed 2 weeks later on 4/17/26.

NHTSA ID

11735319

Incident

Apr 17, 2026

The contact owns a 2024 GMC Yukon. The contact stated that while the vehicle was stopped at a red traffic light, the accelerator pedal was depressed and the vehicle stalled. The message "Conditions not Available to Change Gear" was displayed. The vehicle was restarted and driven to the residence. The contact stated that several days later, while pulling into a parking lot, the vehicle unexpectedly stalled. The vehicle was restarted and was then towed to the dealer; however, the failure could not be duplicated. The manufacturer was notified of the failure. The failure mileage was approximately 24,000.

NHTSA ID

11729637

Incident

Apr 2, 2026

Mileage

24,000 mi

From the time i got my 2024 yukon denali i have had problems with the electrical systems not working, it was in the shop for 2 months upon delivery to me when it was brand new, and since then i have had issues with the engine racing, the start button not working, or cutting off and on , on its own, recently the motor cuts on but never turns over. It has been in the shop again for over a week now and they replaced the engine control module and it is still doing the same thing. The dealership is now telling me its a wiring issue causing it. It has been something the entire time I have owned it. I paid 90k for a vehicle that has major issues. I am looking into the Lemon law in my state of NC, and filing a complaint with GMC to see if I can get a replacement vehicle or traded.

NHTSA ID

11728869

Incident

Mar 15, 2026

Vehicle shut-off while driving on the expressway, around 70-75mph. Upon vehicle turning off, I had no option but to "coast" off to the left side, which thankfully, freed me from traffic for the most part. If anyone who have been a foot over, they would've hit me. I have had numerous electrical issues with this vehicle and have taken it to the dealership but they have been "unable" to duplicate the issue. Vehicle was immediately taken to the dealership (and they still have as of this incident report submission). They told me last night that they will keep it again today and test drive it again to see if they can get it to do anything but if it doesn't show anything new, they have nothing to diagnose and will give me my car back. After requesting a copy of repair orders and a list of the history codes in my car, I am beside myself that anyone thinks giving me this vehicle back to drive is ok. See the history code report in documents uploaded. These are MAJOR safety failures in a large vehicle.

NHTSA ID

11723837

Incident

Mar 8, 2026