RoadVitals

1996 Great Dane Trailer

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
4
Latest Aug 15, 2002
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 1996 Great Dane Trailer. 4 safety recalls have been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

4 campaigns cover this model year

View all 4

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
02V210004

SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE

Aug 15, 2002
The defect: ON CERTAIN TRAILERS EQUIPPED WITH SPRING BRAKE CONTROL VALVE ASSEMBLIES, THERE IS A RECESSED AREA ON TOP OF THE VALVE IN WHICH A BRASS GUIDE PIN FITS DOWN INSIDE THE BODY OF THE VALVE AND IS HELD IN PLACE BY A STEEL SNAP RING. THE RECESSED AREA ALLOWS ACCUMULATION OF WATER, DIRT, AND/OR CHEMICALS TO BUILD UP BEHIND THE SNAP RING TO THE POINT WHERE IT WILL NO LONGER CONTAIN THE GUIDE PIN RESULTING IN A FAILURE OF THE AIR VALVE.
The risk: FAILURE OF THE VALVE IN AN EMPTY OR LIGHTLY LOADED TRAILER WHILE THE VEHICLE IS IN MOTION COULD RESULT IN A HARD APPLICATION OF THE SPRING BRAKES, POSSIBLY LOCKING UP THE TRAILER WHEELS AND RESULTING IN A VEHICLE CRASH.
The remedy: SEALCO WILL PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS TO ITS CUSTOMERS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SEALCO AT 602-253-1007 OR GREAT DANE AT 912-644-2100.
GREAT DANE TRAILERS, INC.View on NHTSA.gov
97V238001

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Dec 30, 1997
4,331 units potentially affected
The defect: VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH ANTILOCK BRAKING SYSTEM (ABS) ELECTRONIC CONTROL UNITS (ECU) FOR OVER-THE-ROAD TRAILER APPLICATIONS. THE COVER SEAL (O-RING) MAY HAVE BEEN IMPROPERLY INSTALLED IN CERTAIN EASY-STOP TRAILER ABS ELECTRONIC CONTROL UNITS. AN INCORRECTLY INSTALLED SEAL COULD PERMIT WATER TO ENTER THE ECU CAUSING A FAULT TO DEVELOP. THIS WILL CAUSE THE VEHICLE'S TRAILER ABS WARNING LAMP TO ILLUMINATE IMMEDIATELY WHEN THE WATER CONTACTS THE BOARD, DEACTIVATING ALL OR PART OF THE ABS.
The risk: IF THE WARNING LAMP SIGNAL IS IGNORED FOR A PERIOD OF TIME, CORROSION CAN DEVELOP EVENTUALLY LEAKING TO A COMPLETE LOSS OF ECU FUNCTION. THE SERVICE BRAKES WOULD CONTINUE TO BE FULLY FUNCTIONAL.
The remedy: ROCKWELL IS CONDUCTING THE NOTIFICATION AND REMEDY FOR THIS RECALL DEALERS WILL REPLACE THE ECU ON THESE TRAILERS.
GREAT DANE TRAILERS, INC.View on NHTSA.gov
97V239001

SUSPENSION:FRONT:WHEEL BEARING

Dec 30, 1997
308 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCK TRAILERS EQUIPPED WITH AXLE ASSEMBLIES BUILT BY EATON. THE GREASE LUBRICATION VOLUME LEVEL SPECIFIED FOR THESE TRAILER AXLES IS INSUFFICIENT TO PROVIDE PROPER LUBRICATION TO THE OUTER WHEEL END BEARING ASSEMBLY.
The risk: THIS CONDITION CAN CAUSE FAILURE OF THE WHEEL BEARING SYSTEM RESULTING IN WHEEL END BURN UP OR LOSS OF WHEEL END EQUIPMENT.
The remedy: OWNER NOTIFICATION WILL BE CONDUCTED BY EATON. DEALERS WILL INSPECT THESE TRAILER AXLES AND ADD LUBRICANT IF NECESSARY.
GREAT DANE TRAILERS, INC.View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Compare model years

Complaint and recall counts across every year of this model

Great Dane Trailer by model year
YearComplaintsRecallsInvestigationsIssue Index
2012010—
2011020—
2010110—
2009130—
2008010—
2007120—
2006430—
2005130—
2004110—
2003010—
2002110—
2001130—
2000050—
1999430—
1998250—
1997120—
1996Viewing040—
1995020—
1994230—
1993010—
1992010—
1991010—
1989010—
1988010—
1987111—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.