2003 Gulf Stream Sun Voyager Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Gulf Stream Sun Voyager, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes466.7%
- Body & structure116.7%
- Other / unspecified116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2003 GULFSTREAM SUNVOYAGER. DURING BRAKE APPLICATION WHILE DRIVING DOWNHILL AT 40 MPH THE BRAKE PEDAL WENT TO THE FLOOR. AFTER REPEATED BRAKE APPLICATION HE WAS ABLE TO STOP. AFTER AN HOUR OF WAITING HE NOTICED HEAT BUILD-UP IN THE BRAKE SYSTEM. A MECHANIC INSPECTED THE VEHICLE, AND MADE A TEMPORARY REPAIRS. HE WAS ADVISED THAT HIS VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL 09V245000 (SERVICE BRAKES, HYDRAULIC). HE WAS INELIGIBLE FOR A FREE REMEDY, SO NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 30000 . THE CURRENT MILEAGE WAS 34000.
TL*THE CONTACT OWNS A 2003 GULF STREAM SUN VOYAGER. WHILE DRIVING 40 MPH, THE VEHICLE WOULD NOT ACCELERATE. WHEN THE VEHICLE WOULD COAST, IT BEGAN TO STOP AUTOMATICALLY AND MORE QUICKLY THAN USUAL. WHEN THE CONTACT EXAMINED THE VEHICLE, HE NOTICED THAT THE REAR DRIVER SIDE TIRES WERE EXTREMELY HOT AND THE ABS WARNING LIGHT ILLUMINATED. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE PRIOR TO THE FAILURE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT MILEAGE WAS 17,447 AND FAILURE MILEAGE WAS 13,700.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
2003 GULF STREAM MH SUNVOYAGER 36FT. 5000LB RECEIVER RIPPED LOOSE FROM EXTENSION OF WORKHORSE W22 CHASSIS 125 MI SO OF FORT NELSON,BC ON 7/1/05. TOWING A 2004 HONDA CRV(3400LBS). EXTENSION FRAMING RIPPED ON LEFT SIDE LIKE A PIECE OF PAPER AND PARTIALLY RIPPED ON RIGHT SIDE. CRV WAS NEARLY COMPLETELY SEPARATED FROM TOW VEHICLE. BREAKAWAY SYSTEM WOULD BE USELESS BECAUSE IT WAS TIED TO RECEIVER. ONLY PURE LUCK KEPT US FROM A MAJOR ACCIDENT. ACCORDING TO WELD SHOP OWNER,THIS WAS HIS 4TH SUCH REPAIR IN PAST WEEK. MH MANUFACTURES SHOULD BE HELD RESPONSIBLE FOR PROVIDING FRAMING MATERIAL THAT WOULD SUPPORT THE HITCH THAT THEY PROVIDE ON THESE VEHICLES. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
CUSTOMER STATES THAT THEY HAD TO PAY OUT OF POCKET FOR RECALL REPAIR AND IS ASKING FOR ADVICE TO GET REIMBURSEMENT FROM DOMETIC**CC THE CONSUMER STATED IN HIS OPINION, THE KIT FOR THE RECALL WAS NOT A CORRECTION FOR THE DEFECT, IT WAS MERELY PUTTING A METAL BOX AROUND THE DANGER AREA WITH A THERMO-COUPLER TO TURN OFF THE GAS IF IT STARTS A FIRE. THE CONSUMER WAS INFORMED THAT HE WOULD BE RESPONSIBLE FOR SOME OF THE LABOR BECAUSE THE MANUFACTURER WOULD ONLY PAY $40.00 AND THE SHOP CHARGED $95 PER HOUR FOR LABOR, SO THERFORE IF IT TOOK MORE THAN 20 MINUTES THE CONSUMER WOULD HAVE TO PAY THE DIFFERENCE. THE CONSUMER WOULD LIKE HIS $95 DOLLARS RETURNED TO HIM. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .