RoadVitals

2001 Harley-Davidson Flhr Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Dec 17, 2008
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
3
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2001 Harley-Davidson Flhr, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Engine250.0%
  • Electrical125.0%
  • Steering125.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

2
reports

From owner reports, verbatim

2001 HARLEY-DAVIDSON FLHR ROAD KING MOTORCYCLE WITH 15,500 MILES ON MOTOR HAD EXCESSIVE WEAR ON THE OIL PUMP AND NEEDED TO BE REPLACED AT AN EXPENSE OF OVER $500.00. THERE WAS EXCESSIVE SCORING ON THE PUMP CAMS WHICH MEANS METALS WITHIN THE ENGINE LOWER END HAVE CAUSED THE SCORING OF THE METAL PARTS OF THE OIL PUMP. *TR

NHTSA ID 10252155 · filed Dec 17, 2008

DRIVE BELT SUDDENLY BROKE WHEN ACCELERATING IN 2ND GEAR. HAD RIDER PASSENGER IN MODERATE TRAFFIC.*AK

NHTSA ID 765316 · filed Aug 7, 2002

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

WHILE RIDING MY 2001 HARLEY ROAD KING (FLHR) ON TWO SEPARATE TIMES AS WE WERE RIDING DOWN THE MOTOR DIED. PRIOR TO THAT ON THE FIRST TIME BEFORE WE STARTED OFF THE BIKE WOULD NOT START, I ONLY HEARD THE SOUND OF A RELAY CLICKING SO I PUT IN A NEW BATTERY AND IT STARTED, THEN WE TOOK OFF AND IT QUIT IN TRAFFIC. IT DID START AND WE RODE HOME. THEN A WEEK LATER WE WENT FOR A RIDE AND IT DIED ON THE HIGHWAY AND WOULD NOT START AGAIN. IT WOULD ONLY CLICK A RELAY. THEY FOUND A BURNED OUT STATOR WHICH I PERSONALLY BELIEVE IS CAUSED BY SOMETHING ELSE AS A STATOR SHOULD NOT GO BAD WHEN THE BIKE HAS ONLY 14K MILES ON IT AND I AM ORIGINAL OWNER. ALSO THE STATOR WOULD HAVE BURNED OUT AND I BELIEVE THE FIRST TIME AND NOT STARTED AGAIN.

NHTSA ID 10066092 · filed Apr 13, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Steering

Reports naming the steering system — racks, columns, power-steering assist and steering linkage.

1
report

From owner reports, verbatim

I OWN A 2001 HARLEY DAVIDSON FLHR, I HAD JUST TAKEN A TRIP FROM NORTH CAROLIN TO OHIO,WITH A FRIEND WHO WAS RIDING ALSO. HIS BIKE , A 2004 HALREY DAVIDSON FLHR. UPON OUR TRAVEL THROUGH THE WEST VIRGINIA TURNPIKE ON A COUPLE OF LONG SWEEPING CURVES, BOTH HE AN I EXPERIANCED A HIGH SPEED WOBBLE(TANK SLAPPER) NEEDLESS TO SAY THIS ALMOST CAUSED AN ACCIDENT. I ATTRIBUTE 35 YEARS OF RIDING, AS WELL AS MY FRIEND. FOR BEING ABLE TO RECOVER.UPON OUR RETURN WE FOUND OUT THAT THIS IS A KNOWN PROBLEM. WHAT IS HD GOING TO DO TO RESOLVE? AND WHEN? HOW MANY IN-EXPERIANCED RIDERS WILL HAVE TO ENDURE A CRASH OR DEATH? THERE IS A DEVICE ON THE MARKET THAT IS SUPPOSED TO CORRECT THIS.IT CAN BE FOUND ON WWW.TRUE-TRACK.COM.THIS IN ITSELF WOULD MEAN TO ME THERE IS AN ISSUE..AND SOMEONE HAS FOUND A FIX.HAVING SAID THAT..HOW DOES HD STIIL SAY THEY KNOW OF NO ISSUE?*AK

NHTSA ID 10093434 · filed Oct 1, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .