RoadVitals

2001 Harley-Davidson Flhr

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Dec 17, 2008
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Jan 4, 2002
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 4 NHTSA owner-reported complaints for the 2001 Harley-Davidson Flhr, most frequently naming the engine, electrical and steering categories. 1 safety recall has been issued covering this model year; and 8 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Engine250.0%
  • Electrical125.0%
  • Steering125.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
02V002000

EXTERIOR LIGHTING

Jan 4, 2002
28,949 units potentially affected
The defect: ON CERTAIN MOTORCYCLES, THE CLIPS THAT RETAIN THE WIRING FOR THE FRONT FENDER TIP LIGHT CAN BECOME DETACHED FROM THE FENDER, CAUSING THE WIRES TO FRAY AND SHORT.
The risk: THIS COULD CAUSE THE LIGHTING SYSTEM FUSE TO BLOW, LEAVING THE VEHICLE WITHOUT AN OPERATIONAL FRONT FENDER TIP LIGHT, HEADLIGHT, TAILLIGHT, RUNNING LIGHTS, AND PASSING LAMPS (IF EQUIPPED).
The remedy: DEALERS WILL REPLACE THE FENDER TIP LIGHT WIRING HARNESS RETENTION CLIPS, AND INSPECT AND REPLACE, IF NECESSARY, ANY DAMAGED WIRING HARNESSES. OWNER NOTIFICATION BEGAN JANUARY 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680.
HARLEY-DAVIDSON MOTOR COMPANYView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Engine
Filed Dec 17, 2008

2001 HARLEY-DAVIDSON FLHR ROAD KING MOTORCYCLE WITH 15,500 MILES ON MOTOR HAD EXCESSIVE WEAR ON THE OIL PUMP AND NEEDED TO BE REPLACED AT AN EXPENSE OF OVER $500.00. THERE WAS EXCESSIVE SCORING ON THE PUMP CAMS WHICH MEANS METALS WITHIN THE ENGINE LOWER END HAVE CAUSED THE SCORING OF THE METAL PARTS OF THE OIL PUMP. *TR

NHTSA ID
10252155
Incident
Dec 17, 2008
Mileage
15,500 mi
Steering
Filed Oct 1, 2004

I OWN A 2001 HARLEY DAVIDSON FLHR, I HAD JUST TAKEN A TRIP FROM NORTH CAROLIN TO OHIO,WITH A FRIEND WHO WAS RIDING ALSO. HIS BIKE , A 2004 HALREY DAVIDSON FLHR. UPON OUR TRAVEL THROUGH THE WEST VIRGINIA TURNPIKE ON A COUPLE OF LONG SWEEPING CURVES, BOTH HE AN I EXPERIANCED A HIGH SPEED WOBBLE(TANK SLAPPER) NEEDLESS TO SAY THIS ALMOST CAUSED AN ACCIDENT. I ATTRIBUTE 35 YEARS OF RIDING, AS WELL AS MY FRIEND. FOR BEING ABLE TO RECOVER.UPON OUR RETURN WE FOUND OUT THAT THIS IS A KNOWN PROBLEM. WHAT IS HD GOING TO DO TO RESOLVE? AND WHEN? HOW MANY IN-EXPERIANCED RIDERS WILL HAVE TO ENDURE A CRASH OR DEATH? THERE IS A DEVICE ON THE MARKET THAT IS SUPPOSED TO CORRECT THIS.IT CAN BE FOUND ON WWW.TRUE-TRACK.COM.THIS IN ITSELF WOULD MEAN TO ME THERE IS AN ISSUE..AND SOMEONE HAS FOUND A FIX.HAVING SAID THAT..HOW DOES HD STIIL SAY THEY KNOW OF NO ISSUE?*AK

NHTSA ID
10093434
Incident
Sep 24, 2004
Electrical
Filed Apr 13, 2004

WHILE RIDING MY 2001 HARLEY ROAD KING (FLHR) ON TWO SEPARATE TIMES AS WE WERE RIDING DOWN THE MOTOR DIED. PRIOR TO THAT ON THE FIRST TIME BEFORE WE STARTED OFF THE BIKE WOULD NOT START, I ONLY HEARD THE SOUND OF A RELAY CLICKING SO I PUT IN A NEW BATTERY AND IT STARTED, THEN WE TOOK OFF AND IT QUIT IN TRAFFIC. IT DID START AND WE RODE HOME. THEN A WEEK LATER WE WENT FOR A RIDE AND IT DIED ON THE HIGHWAY AND WOULD NOT START AGAIN. IT WOULD ONLY CLICK A RELAY. THEY FOUND A BURNED OUT STATOR WHICH I PERSONALLY BELIEVE IS CAUSED BY SOMETHING ELSE AS A STATOR SHOULD NOT GO BAD WHEN THE BIKE HAS ONLY 14K MILES ON IT AND I AM ORIGINAL OWNER. ALSO THE STATOR WOULD HAVE BURNED OUT AND I BELIEVE THE FIRST TIME AND NOT STARTED AGAIN.

NHTSA ID
10066092
Incident
Mar 31, 2004
Mileage
14,000 mi
Engine
Filed Aug 7, 2002

DRIVE BELT SUDDENLY BROKE WHEN ACCELERATING IN 2ND GEAR. HAD RIDER PASSENGER IN MODERATE TRAFFIC.*AK

NHTSA ID
765316
Incident
Aug 4, 2002

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

M1684

ELECTRICAL SYSTEM

SERVICE BULLETIN M1684: MARKET SPECIFIC BATTERY INTRODUCTION. PURPOSE: Initial Release. This bulletin informs dealers of the availability of new batteries for new Original Equipment (OE) vehicle production and in the Parts and Accessories (P&A) catalog. Availability of the new Absorbed Glass Mat (AGM) batteries will vary by market and will be transitioning over the next few months. NOTE: The ring terminal screws are not compatible between Leoch and East Penn batteries. The new batteries will include new ring terminal screws, which must be used. The ring terminal screws from the old battery need to be discarded.

M1555

ELECTRICAL SYSTEM

SERVICE BULLETIN M1555 (REV E): BATTERY WARRANTY GUIDELINES. PURPOSE: Revision E. Added: Added procedures for the DCA-8000 E Battery Tester.* Updated: All sections. This bulletin informs the dealership network that Harley-Davidson has provided guidelines for battery warranty.

M1490

ELECTRICAL SYSTEM

SERVICE BULLETIN M1490 (V 24.8.8): DIGITAL TECHNICIAN II - UPDATES AND RELEASE NOTES. PURPOSE: This bulletin informs dealers that Harley-Davidson has made a software update to Digital Technician II (DT II). DIGITAL TECHNICIAN II (PART NUMBER: HD-48650). Version 24.8.8. Release Date: Week of August 5, 2024. New Features for Harley-Davidson vehicles: Advanced Module Replace for 2021 and later Revolution Max; 2023 and later CVO Touring; and 2024 Street Glide (FLHX), Road Glide (FLTRX). New Features for LiveWire vehicles: Updated calibrations for 2024 S2DM EV1/ EV6; 2024 S2MH EV1; and 2024 S2DM, S2MH. Changes: Added Hand Control Module (HCM) (Part No. 71500522A and 71500536A) for reflash support.

PAB1158

ENGINE; POWER TRAIN

GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1158: OIL FILTER PACKAGING AND CASE QUANTITY UPDATE. PURPOSE: To inform dealerships that Harley-Davidson has made updates to oil filters including new part numbers, packaging design, and bulk case quantity changes.

M1490

ELECTRICAL SYSTEM

SERVICE BULLETIN M1490 (V 24.6.4): DIGITAL TECHNICIAN II - UPDATES AND RELEASE NOTES. PURPOSE: Revision. This bulletin informs dealers that Harley-Davidson has made a software update to Digital Technician II (DT II). DIGITAL TECHNICIAN II (PART NUMBER: HD-48650). Version 24.6.4. Release Date: Week of May 1, 2024. New Features for LiveWire S2DM and S2MH, 2024 Revolution® Max, and 2024 Touring.

PAB1146

EXTERIOR LIGHTING

GENUINE MOTOR PARTS AND MOTOR ACCESSORIES BULLETIN PAB1146: 68193-95 BULB WEDGE, FENDER TIP LAMP. Purpose: To inform dealers of an issue with the bulb wire terminals not being to specification. The light bulbs were used in numerous front and rear fender tip light assemblies for domestic and international applications.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Harley-Davidson Flhr by model year
YearComplaintsRecallsInvestigationsIssue Index
2022010—
2021010—
2020110—
2019200—
2018510—
2017320—
2016000—
2015210—
2014320—
2013200—
2012210—
2011921—
2010331—
2009103151.8
2008142254.0
2007400—
2006000—
2005200—
2004100—
2003310—
2002210—
2001Viewing410—
2000000—
1999810—
1997100—
1995600—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.