RoadVitals

2006 Harley-Davidson Flstfi Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Oct 4, 2011
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Harley-Davidson Flstfi, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Interior & seats150.0%
  • Suspension150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Interior & seats

Reports naming seats, latches, locks, linkages and interior fittings.

1
report

From owner reports, verbatim

WHEN REMOVING SEAT, LEFT SIDE ANGLE BRACKET THAT HOLDS SCREW, (1/4-20 THUMB SCREW), FELL TO FLOOR. THIS BRACKET WAS RIVETED TO THE PLASTIC SEAT PAN, IN A TRIANGULAR PATTERN. THE BRACKET, RIVETS, AND PLASTIC, ABOUT THE SIZE / SHAPE OF A NICKEL, FELL OUT IN ONE PIECE. THERE ARE SPIDER CRACKS IN THE SEAT PAN AROUND THE HOLE ON THE LEFT SIDE AND ON THE RIGHT SIDE BRACKET ASSEMBLY AREA ALSO. IF THE SEAT FAILS, CAUSING A SEAT/RIDER SHIFT, AT ANY SPEED, WILL MAKE MOTORCYCLE UNCONTROLLABLE. THIS NEEDS TO BE A RECALL. LOOKING ONLINE FOR A REPLACEMENT, MANY USED SEATS HAVE THIS SAME CRACKING AROUND THE BRACKETS. I AM 6'3", 240LBS. AND VERY SELDOM RIDE TWO UP. THIS SHOULD NOT HAVE BROKEN, EVER. *TR

NHTSA ID 10428728 · filed Oct 4, 2011

Too few reports in this category for a page of its own — they appear in the full complaint list.

Suspension

Reports naming suspension components — springs, struts, shocks, control arms and related hardware.

1
report

From owner reports, verbatim

REAR WHEEL BEARINGS WORN BADLY AT ONLY 8,500 MILES CREATING UNSTABLE CONDITION. BEARINGS ARE SEALED AND CAN NOT BE LUBRICATED. THERE IS ALSO NO MENTION OF MAINTENANCE OR INSPECTION REQUIREMENTS IN OWNERS MANUAL/MAINTENANCE INTERVALS. THIS IS A COMMON PROBLEM SINCE HARLEY DAVIDSON SWITCHED FROM GREASY BEARINGS TO THOSE OF THE SEALED TYPE. *TR

NHTSA ID 10213256 · filed Dec 31, 2007

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .