2004 Harley-Davidson Touring Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Harley-Davidson Touring, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical337.5%
- Driver assistance225.0%
- Suspension225.0%
- Other / unspecified112.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WHEN USING THE CB ON A RIDE, THE LOCATION OF THE PTT BUTTON WAS CHANGED FROM THE RIGHT HAND SIDE TO THE LEFT. WHEN PUSHING THE PUSH TO TALK CB BUTTON YOU HAVE AN ISSUE WITH SHUTTING THE ENGINE OFF DO THE LOCATION OF THE BUTTON. I SHUT THE ENGINE OFF 5 TIMES ON MY LAST RIDE. THIS IS A DANGEROUS SITUATION THAT MAY CAUSE AN ACCIDENT. *TR
2004 FLHTCUI HARLEY-DAVIDSON HORN ISSUE. DOES NOT OPERATE CORRECTLY. IT APPEARS THAT NOT ENOUGH POWER IS GETTING TO THE HORN AND IT BECOMES A 50-50 CHANCE THAT THE HORN MIGHT WORK. TOOK IT TO THE HD SHOP 3 TIMES AND ALL 3 TIMES THEY SAID THEY COULD NOT DUPLICATE THE ISSUE. THE SECOND TIME I EVEN PAID FOR A NEW HORN AS TO ELIMINATE ONE POSSIBLE ITEM. SAME ISSUE WITH NEW HORN. THE 3RD TIME THE HD SHOP SAID THAT HARLEY-DAVIDSON SAID THAT THE BIKE NEEDS TO BE RUNNING FOR THE HORN TO WORK CORRECTLY. AGAIN THE SHOP COULD NOT DUPLICATE THE ISSUE. EACH TIME I TOOK THE BIKE HOME FROM THE SHOP, THE HORN ONLY WORKED 50% OF THE TIME. HOT, COLD,DRY, WET, LOW SPEED, HIGH SPEED...IT DOESN'T MATTER. THIS STARTED AROUND JUNE, 2005. BIKE IS STILL IN WARRANTY. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WHEN USING THE CB ON A RIDE, THE LOCATION OF THE PTT BUTTON WAS CHANGED FROM THE RIGHT HAND SIDE TO THE LEFT. WHEN PUSHING THE PUSH TO TALK CB BUTTON YOU HAVE AN ISSUE WITH SHUTTING THE ENGINE OFF DO THE LOCATION OF THE BUTTON. I SHUT THE ENGINE OFF 5 TIMES ON MY LAST RIDE. THIS IS A DANGEROUS SITUATION THAT MAY CAUSE AN ACCIDENT. *TR
CRUISE CONTROL ON HARLEY DAVIDSON FLHTCUI (2004) WORKED INTERMITTENTLY. AT TIMES, THE CRUISE WOULD OPERATE NORMALLY, BUT THEN WOULD CUT OUT SUDDENLY AND WITHOUT WARNING. OR, THE CONTROL PANEL INDICATED THE CRUISE WAS ON, WHEN IN FACT IT WASN'T. 4-9-05 WAS NOT FIRST INCIDENT; THERE WERE NUMEROUS PRIOR EVENTS.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
2004 HARLEY-DAVIDSON ROAD KING. I WAS GOING INTO A SWEEPING RIGHT HAND TURN, THEN THE REAR END STARTED TO WOBBLE AND I COULDN'T CONTROL THE BIKE RAN OFF THE ROAD, WAS TRASHED AND I BROKE TWO RIBS AND A COLLAR BONE. I HAVE OWNED MANY OF THE SAME BIKE OVER 30 YEARS AND HAD WOBBLE PROBLEMS BEFORE BUT NEVER CRASHED. *JB
DT: THE VEHICLE PULLED TO THE LEFT WHEN DRIVING. HAD BEEN TO THE DEALER 4 TIMES, AND WILL TAKE IT BACK ON AUGUST 15, 2005. FILED A COMPLAINT UNDER THE LEMON LAW . THEY SAID IT WAS NOT A PROBLEM . THE FIRST TIME CONSUMER TOOK VEHICLE TO THE DEALER IT HAD 479 MILES ON IT. HAD IT 8 DAYS AND FOUND JUST A COUPLE OF LOOSE BOLTS.*AK THE VEHICLE HAS BEEN SERVICED FIVE TIMES BUT IT CONTINUES TO PULL TO THE LEFT. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
2004 FLHTCUI HARLEY-DAVIDSON HORN ISSUE. DOES NOT OPERATE CORRECTLY. IT APPEARS THAT NOT ENOUGH POWER IS GETTING TO THE HORN AND IT BECOMES A 50-50 CHANCE THAT THE HORN MIGHT WORK. TOOK IT TO THE HD SHOP 3 TIMES AND ALL 3 TIMES THEY SAID THEY COULD NOT DUPLICATE THE ISSUE. THE SECOND TIME I EVEN PAID FOR A NEW HORN AS TO ELIMINATE ONE POSSIBLE ITEM. SAME ISSUE WITH NEW HORN. THE 3RD TIME THE HD SHOP SAID THAT HARLEY-DAVIDSON SAID THAT THE BIKE NEEDS TO BE RUNNING FOR THE HORN TO WORK CORRECTLY. AGAIN THE SHOP COULD NOT DUPLICATE THE ISSUE. EACH TIME I TOOK THE BIKE HOME FROM THE SHOP, THE HORN ONLY WORKED 50% OF THE TIME. HOT, COLD,DRY, WET, LOW SPEED, HIGH SPEED...IT DOESN'T MATTER. THIS STARTED AROUND JUNE, 2005. BIKE IS STILL IN WARRANTY. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .