2022 Heartland Trail Runner Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2022 Heartland Trail Runner, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical266.7%
- Exterior lighting133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
In January 2023 the 26th breaker panel sparked and started smoking no breakers flipped and at 3am my roommate who works nights started pulling anything that could produce power or consume it. After almost two weeks of fighting manufacturer we were sent a converter and a licensed technician installed it and power was restored. May 21st 2023 there was a loud pop and the entire system started flickering off and on and an electrical smell of burning wires started producing and i immediately went to evacuate the children and disconnected anything that could be consuming power. Flickering and clicking went on for a couple hours before it ceased and no power was returned to the unit.
Converter overheated or failed to work as intended resulting in smoke leading up to an electrical fire. Component was in a small space with no adequate air flow and breaker’s remained in place not flipping as they should have to stop power from flowing. There were no warning signs as we were all asleep and husband happened to get up to go check on the kids when he found the breaker panel smoking. This could have killed us and has resulted in no power and losing food, shelter and warmth during a major freeze.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
In January 2023 the 26th breaker panel sparked and started smoking no breakers flipped and at 3am my roommate who works nights started pulling anything that could produce power or consume it. After almost two weeks of fighting manufacturer we were sent a converter and a licensed technician installed it and power was restored. May 21st 2023 there was a loud pop and the entire system started flickering off and on and an electrical smell of burning wires started producing and i immediately went to evacuate the children and disconnected anything that could be consuming power. Flickering and clicking went on for a couple hours before it ceased and no power was returned to the unit.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .