RoadVitals

2004 Honda CBR600RR Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
7
Latest Aug 23, 2005
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
4

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Honda CBR600RR, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes685.7%
  • Electrical114.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

6
reports

From owner reports, verbatim

DRIVER APPLIED THE BRAKES ON THE MOTORCYCLE AND IT FAILED TO STOP. DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE MOTORCYCLE, AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC DETERMINED THAT THE ROTORS NEEDED TO BE REPLACED DUE TO CORROSION. *AK

NHTSA ID 10109513 · filed Feb 1, 2005

RECALL 04V387000 CONCERNING MOTORCYCLES BRAKE SYSTEM LINKAGE. DEALER REFUSED TO HONOR RECALL BECAUSE THE CONSUMER DID NOT PURCHASE THE MOTORCYCLE THERE. *AK

NHTSA ID 10099658 · filed Nov 9, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

DT:WHEN TURNING ON BRIGHT LIGHT SWITCH WHILE DRIVING THE ENGINE DIES AND THE LIGHTS GO OUT, THIS INTERMITTENT IN NATURE. DID CONTACT MANUFACTURER, WHO NOT CONCERNED, TOLD CONSUMER TO TAKE TO DEALER. CONSUMER TOOK VEHICLE TO THE DEALER, WHO SAID THEY DID NOT HAVE TO REPLACE PART BECAUSE THIS WAS A GROUND WIRE PROBLEM AFTER BEING ORIGINALLY DIAGNOSED AS A BATTERY ISSUE WHICH WAS REPLACED AND DID NOT REMEDY PROBLEM. DEALER AGREED TO FIX PROBLEM WHICH CONSUMER HAD TO PAY FOR, BUT HAS NOT HAD ANY PROBLEMS SINCE REPAIR.*AK *TT

NHTSA ID 10128902 · filed Aug 23, 2005

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .