2024 Honda CR-V Hybrid Fuel system Problems

The contact owns a 2024 Honda CR-V. The contact stated that after driving during rainy weather at various speeds, the check engine and TPMS warning lights illuminated. The vehicle was taken to a local dealer, where it was diagnosed with water intrusion in the canister valve. The water was flushed, and the system was restarted; however, the parts were not available to replace the canister valve. The vehicle was taken back to the same local dealer due to the failure recurring; however, the parts for the repairs were not replaced. The check engine warning light illuminated. The vehicle was taken back to the same local dealer where it was diagnosed as needing further diagnostic tests and repairs. The vehicle was not diagnosed or repaired due to the cost. The contact related the failure to NHTSA Campaign Number: 24V763000 (Fuel System, Gasoline); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 752.

NHTSA ID

11668977

Incident

Jun 6, 2024

Mileage

752 mi

My 2024 Honda CR-V Hybrid began experiencing a noticeable loss of engine power and severe shaking while idling. The problem first appeared when I was parked with the engine running, and the car suddenly started vibrating strongly. Shortly after, the “Emissions System Problem” warning message appeared on the dashboard. A local Honda dealer suspected a malfunction in the fuel injector system, which may have led to improper fuel combustion, reduced acceleration, and overall unstable engine behavior. This issue could increase the risk of an accident, particularly when merging or accelerating in traffic, due to delayed throttle response. Many other CR-V Hybrid owners have reported similar symptoms online, pointing to a potential widespread defect in the fuel delivery system. Despite this, there is currently no official recall for the fuel injectors in this model. I am concerned that this issue, if left unresolved, could lead to engine damage or even pose a fire risk due to unregulated or incomplete fuel combustion. Given the number of reports and the potential danger, I respectfully urge the NHTSA to investigate this issue and consider initiating a recall to protect driver safety.

NHTSA ID

11665691

Incident

May 31, 2025

Car went from regular driving to very rough running engine, multiple warning lights activated and limp mode activated. Drove 25mph to get home. Car was towed to Dealership and after inspection, Fuel injectors and spark plug # 3 had to be replaced. Many many CRV owners seen to be having this problem and this could cause an accident should it happen on a freeway.

NHTSA ID

11664127

Incident

May 24, 2025

The contact owns a 2024 Honda CR-V. The contact received notifications of NHTSA Campaign Number: 24V763000 (Fuel System, Gasoline) and 24V744000 (STEERING); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was contacted and confirmed that parts were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue and informed the contact that parts were available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11650123

Incident

Nov 24, 2024

The contact owned a 2024 Honda CR-V. The contact stated that while driving on a state road at 35 MPH, the contact reported seeing and smelling smoke inside the cabin of their vehicle, the smoke began to increasingly become heavy, and from the rearview mirror, flames could be seen emitted from the rear end of the vehicle. No warning lights were illuminated. The contact immediately pulled over into a parking lot and exited the vehicle within minutes the vehicle was engulfed in flames. The origin of the fire was unknown. The fire was extinguished by the local fire department. A police report was filed. The vehicle was destroyed. No injuries were reported. The vehicle was towed to a local dealer where the vehicle was inspected and declared a total loss. The contact referenced NHTSA Campaign Number 24V763000 (FUEL SYSTEM, GASOLINE) as probable cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 25,000.

NHTSA ID

11649454

Incident

Mar 6, 2025

Mileage

25,000 mi

My car has two recalls, including EPS recall #24V-744, which I’ve been informed won’t be completed until February 2026. However, my recall letter from Honda states that repairs should be completed within **60 days** of contacting the dealership (February 25, 2025). This delay is far beyond a reasonable timeframe, especially since the recall involves a potential safety issue. I’m concerned about the risk of driving my vehicle for an extended period without the necessary repairs and need clarification on how this situation will be addressed.

NHTSA ID

11644853

Incident

Feb 25, 2025

The contact owns a 2024 Honda CR-V. The contact received notification of NHTSA Campaign Number: 24V763000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The vehicle was taken to a dealer to be diagnosed; however, the dealer informed the contact that the fuel pump was not leaking. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall.

NHTSA ID

11642612

Incident

Feb 13, 2025

The contact owns a 2024 Honda CR-V Hybrid. The contact received notifications of NHTSA Campaign Numbers: 24V763000 (Fuel System, Gasoline) and 24V744000 (Steering); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available for NHTSA Campaign Number: 24V763000 (Fuel System, Gasoline). Parts distribution disconnect for NHTSA Campaign Number: 24V744000 (Steering).

NHTSA ID

11642470

Incident

Feb 13, 2025

The contact owns a 2024 Honda CR-V. The contact received notification of NHTSA Campaign Number: 24V763000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11641974

Incident

Feb 11, 2025

On [XXX], my 2024 Honda CR-V Hybrid experienced a sudden loss of acceleration while driving on the highway, creating a dangerous situation where I was unable to merge or maintain speed. This put me at immediate risk of an accident as other vehicles were traveling at normal highway speeds. This issue arose less than 136 miles after my vehicle underwent recall repairs on [XXX] at Superstition Springs Honda in Mesa, Arizona. The recall repairs included: •Fuel Pump Safety Recall (NHTSA Recall 24-049) •CVT Greasing Recall (NHTSA Recall 24-123) After the recall repair, my vehicle displayed a dashboard warning on [XXX] stating: ⚠ “Emission System Problem. Power may be reduced. See your dealer.” Following this warning, the vehicle failed to accelerate properly despite pressing the gas pedal, making highway driving unsafe. I took my vehicle back to the dealership immediately. The dealership categorized this as an emissions system failure but has not confirmed if it is related to the recall repairs. The dealership also stated that I would need to drive 500 miles after any repair to “confirm” the issue is resolved, which is unreasonable and unsafe given the circumstances. This is a serious safety defect. A sudden loss of acceleration on the highway creates a high risk of collisions, injuries, or fatalities. Other 2024 Honda CR-V Hybrid owners have reported similar emission system failures after recall repairs, suggesting this may be a widespread issue. This issue is now under review by Honda Corporate (Case #[XXX]), but I have not received a clear resolution or assurance that my vehicle will be permanently fixed. I request that NHTSA investigate whether Honda’s recall repairs are causing secondary defects leading to acceleration failures. This defect poses a significant safety risk and requires immediate attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11641649

Incident

Feb 8, 2025

I contacted Gaudy Honda Dealership in Alhambra CA if they have parts on recall but they always said that its out of stock. and cannot renew my car registration

NHTSA ID

11639502

Incident

Jan 29, 2025

On 1/21/25 I had multiple warning lights appear while driving along the highway @ 60 mph. The error messaging included “transmission failure, loss of power, emissions control…”. I had not seen alerts prior to this incident, and was not aware of changes in performance other than a recent, minor, decrease in fuel efficiency. Fortunately, I was able to safely exit the freeway & park in a nearby shopping center. My vehicle was towed to the local dealer, Marin Honda. After a week of evaluation, and consulting with Honda America tech support, the dealer reports difficulty isolating the problem and determining appropriate repair. At this time a cracked piston has been identified, and the plan is for a technician to use a barescope to evaluate the cylinder for damage, and the potential need to replace the engine. I am concerned that multiple owners of this model & year have reported the same problem, including loss of power while traveling at high speed (see CRV Owners Club) Their vehicles were also determined to have cracked pistons, with and without cylinder damage. It has also been noted that when the fuel injector remains open it may be a contributing factor to a cracked piston. Could this be relevant to the current recall issued for the fuel pump on the 2024 CRV? Whatever the cause, the potential for catastrophic engine failure places drivers and their passengers, as well as other drivers, at great risk of a serious accident.

NHTSA ID

11638988

Incident

Jan 21, 2025

The contact owns a 2024 Honda CR-V Hybrid. The contact received notification of NHTSA Campaign Number: 24V763000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11635693

Incident

Oct 14, 2024

The contact owns a 2024 Honda CR-V. The contact stated that while driving 40-70 MPH, the steering wheel was jerking abnormally. The contact had to hold the steering wheel tightly. The steering wheel was moving unintendedly. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V763000 (FUEL SYSTEM, GASOLINE) and NHTSA Campaign Number 24V744000 (Steering); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. VIN tool confirms parts not available for NHTSA Campaign Number 24V763000 (FUEL SYSTEM, GASOLINE). Parts distribution disconnect for NHTSA Campaign Number 24V744000 (Steering). The failure mileage was approximately 15,272.

NHTSA ID

11634515

Incident

Nov 1, 2024

Mileage

15,272 mi

Driving on an [XXX] near St Pauls NC at 70mph the engine shut off. Annunciator came on stop now engine is quitting. Check engine light came on. We were in a construction zone so there were barriers blocking the shoulders. We were in a high risk of someone behind ramming into us. We coasted to the exit which was 1/2 mile away. We exited at 2mph. We were very fortunate that no one from the rear, hit us. There was a tractor trailer behind us who put his flashers on, realizing the issue stayed behind us to keep cars from hitting us. All warning lights came on, first engine then all of the safety warnings. Car would not run. It was towed to a Honda dealer in Fayetteville. Honda analyzed the issue as a misfire resulting in engine damage. They performed a boroscope and found 3 piston cracked. Honda after 3 weeks installed a new short block and fuel injectors. Car was one year old with 6280 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11633272

Incident

Nov 22, 2024

Mileage

6,280 mi

The contact owns a 2024 Honda CR-V Hybrid. The contact received notifications of NHTSA Campaign Numbers: 24V744000 (Steering) and 24V763000 (Fuel System, Gasoline); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available for NHTSA Campaign Number: 24V763000 (Fuel System, Gasoline). Parts distribution disconnect for NHTSA Campaign Number: 24V744000 (Steering).

NHTSA ID

11631554

Incident

Dec 19, 2024

The contact owns a 2024 Honda CR-V. The contact received notification of NHTSA Campaign Number: 24V763000 (Fuel System Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11628594

Incident

Dec 3, 2024

The fuel injector in my 2024 Honda CR-V malfunctioned, causing severe shaking upon startup, with the "Check Engine" and "Emission System Problem" lights appearing. This incident posed a safety risk, as the engine seemed unstable and power was reduced, potentially affecting vehicle control. The problem has been confirmed by a dealer, who recommended replacing the fuel injector. No other parties (such as insurance or police) have inspected it. These warning indicators first appeared a few days before I took it to the dealer.

NHTSA ID

11624302

Incident

Nov 6, 2024

car shake when switch from EV to gas. Found out the fuel injectors is bad. I replace fuel injectors, now the car is fine. Car has 50,000 miles.

NHTSA ID

11618879

Incident

Sep 2, 2024

When starting the vehicle engine shakes and rattles, when motor is idling and charging the EV battery and also when going from EV to Gas and Gas to EV engine shakes and rattles. When accelerating the engine shakes and rattles. Engine feels sluggish and a loud ticking noise can be heard. Seems the engine is struggling and accelerating it feels the engine rocks back and forth. When transmission is changing gears I also feel the engine rock back and forth.

NHTSA ID

11616753

Incident

Mar 4, 2024

Fuel Injectors failed on all 4 cylinders. They replaced them, still having issue. Blown head gasket was what they diagnosed next and repaired. Picked up vehicle, when driving it down the interstate (70 mph speed limit) the check engine light started flashing. An error came up indicating a Critical Failure. Vehicle stopped accelerating and would not move, luckily I was able to coast to the emergency lane. American Honda states they want to replace the cylinder head now.

NHTSA ID

11614882

Incident

Sep 14, 2024

have a ‘24 hybrid. my car started experiencing a vibration when idling (when the engine is running!), it would last for about 15 seconds. My POWER SYSTEM PROBLEM light and my EMISSIONS SYSTEM PROBLEM lights came on. Took it in to honda and they just said they need to reset the car, which they did. Now today my car was vibrating but, no system lights came on.

NHTSA ID

11613361

Incident

Sep 6, 2024

The Honda of Downtown Chicago dealership has informed us that there is a fuel injector problem with this vehicle. On 8/11/24 it caused the vehicle to cycle through a series of errors before it stopped accelerating on the highway with our young son inside, and eventually stopped moving altogether after we were able to get off on an exit. When the car failed, we were given a final Power System warning. It should be noted that we took the vehicle to the Honda of Downtown Chicago dealership months prior for a the same kind of warning lights (Emissions warning, Lane Departure warning, etc) and a very loud rumbling noise. At that time, the servicing team at the dealership DID NOT disclose that it was or could be a fuel injector issue. Instead, they said that the computer just needed to be “reset” and that the rumbling could be attributed to the vehicle being a hybrid. At this time, the vehicle is with the Honda dealership for repair. They have not provided a timeline for repair or provided a loaner car.

NHTSA ID

11609534

Incident

Aug 11, 2024

See attached document for complaint

NHTSA ID

11609301

Incident

May 11, 2024

2400 miles, emissions light came on and dealership says I need a new fuel injector. Looks like this is a very common issue with these vehicles.

NHTSA ID

11609152

Incident

Aug 17, 2024