2019 Honda Fit Fuel system Problems

Purchased great condition used 2019 Fit EX on XXX from local non-Honda dealership. Nearly 10 months later, on XXX the following errors appeared on the dash: tire pressure monitor system, emissions, hill start assist, lane deviation warning, power steering, and vehicle stability assist errors on the screen, and the check engine, tire pressure monitoring system, vehicle stability assist system, and electric power steering lights were also on. I took it to a local Honda service shop (Performance Kings Honda at [XXX]), and it was diagnosed as needing fuel injectors replaced (running too rich). I approved the repair for a total cost of $1,629.32, including the diagnostic fee, parts, labor, and taxes, on XXX. This was an identical issue to a used 2018 Honda Fit EX that I had purchased on XXX which had the same symptoms and was diagnosed as the same problem (fuel injectors) in XXX, and for which I submitted a separate NHTSA complaint. This is an issue for the NHTSA because it is a known issue on this make and model of car by owners and Honda. See the following: Honda Service Bulletins 21-007, 22-002, 23-042. Additionally, it's an issue I have had to deal with twice, on two separate vehicles, both of the same make and model, meaning it is likely an extremely prevalent issue for owners. Fuel injectors are an expensive repair, and they're known to be faulty on these vehicles by the manufacturer. Without correction, other major systems in the vehicle will fail, with issues such as engine misfire, overheating, catalytic converter failure, and catastrophic damage to the engine. Honda already knows this is an issue on the 2016 and 2017 models. The warranty extension they already issued for these years must be expanded or replicated to cover this issue, which has persisted in the 2018-2020 models. This should be expanded to cover additional years as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11749596

Incident

Jun 13, 2026

Multiple warning lights lit up after starting car and driving for a short distance (less than 5 feet). Honda mechanic diagnosed it as a misfire in cylinder likely due to carbon buildup or other unknown reason. Similar incidents have happened with other 2019 Honda Fit and an extension of warranty was issued for some vehicles but not all (SB 23-042). Unfortunately, mine was apparently not covered despite the same exact issue as other reported incidents.

NHTSA ID

11737815

Incident

May 13, 2026

The fuel gauge, Odometer went blank. Im afraid of be stranded o have in accident . Was taken to Burne Honda Scranton. The problem wasn’t resolved

NHTSA ID

11722347

Incident

Sep 11, 2024

Car only has 91,000 miles and code P219A is popping up but Honda wont cover it because its the "wrong" code even though they cover fuel injectors under misfire codes.

NHTSA ID

11713325

Incident

Dec 22, 2025

Purchased new 2019 Honda FIT. Had to have injectors replaced at dealership due to issues at 18,000 miles. At 19,743 miles started having driving issues with unusual jumping during driving/idling. Honda dealership diagnosed as misfire with excessive carbon buildup. Completed carbon cleaning procedure though only temporary repair. American Honda reviewing matter reference #4411584. Issues returned at 40,308 miles with same issues ( all lights going off on dash, carbon buildup in injectors). completed carbon cleaning at dealership. At 44,831 same lights went off again, carbon buildup seen, faulty injectors replaced at dealership. Issues continued at 56,649 where carbon cleaning took place again for issue at dealership. at 86,606 check engine lights returned with jumping, faulty injectors replaced again and a cleaning was performed at dealership. at 113,791 miles, issues came up again. Dealership cleaned again with carbon cleaner. American Honda contacted again after last dealership visit #15755510 with American Honda rep stating there is no solution at this point per Honda engineers.

NHTSA ID

11686571

Incident

Aug 14, 2025

Vehicle has less than 16k miles over 6 years of ownership. One day, upon starting the car, multiple warning lights, including check engine light, appeared. Dealer stated after diagnostic that issue is due to misfire in one cylinder due to carbon buildup. This is a known issue with this model, and several repair bulletins have been made about this specific issue. Certain VINs were given an extended warranty to fix this problem, but despite having this exact issue and my VIN being mentioned in the repair bulletin, my car is not covered, forcing me to pay out of pocket for this known issue. Car is deemed not safe to drive by dealer until issue is remedied.

NHTSA ID

11683373

Incident

Aug 20, 2025

The fuel pump is malfunctioning. The car struggles to start and when it does start the engine is erratic and the check engine light and steering wheel light come one. I’ve taken the car to AutoZone for a diagnostic test and the computer showed it was a fuel pump issue. I got a second opinion with a mechanic who confirmed the same thing. The car has left me stranded multiple times when it doesn’t start and I fear that the car my stall while driving putting me and other drivers at risk. I researched my issue and there is indeed a recall out for faulty fuel pumps for the Honda Fit 2019. However, my specific VIN number does not qualify for the recall. Honda needs to investigate and expand the number of vehicles that were impacted. Clearly my vehicle is suffering from the same issue and I can’t get it fixed at the dealership due to my VIN not qualifying.

NHTSA ID

11667288

Incident

May 5, 2025

My vehicle has difficulty starting and sometimes won't even start at all, the motor is irregular/jumpy, and the check engine light and steering wheel light have come on. After getting a diagnostics run at AutoZone the computer indicates it's a fuel pump issue. A second opinion with a mechanic also confirmed it was the fuel pump. After further research I see that the 2019 Honda Fit had a recall for Fuel Pumps. However, my specific VIN does not qualify for a recall. Honda needs to further investigate and expand the number of vehicles that were affected by this faulty fuel pump. I've been left stranded numerous times and fear that the vehicle may stall while driving, putting myself and other drivers on the road at risk.

NHTSA ID

11667287

Incident

May 5, 2025

The contact owns a 2019 Honda Fit. The contact received notification of NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11660390

Incident

Dec 28, 2023

Four dashboard warning signs (Check Engine Light, Tire Pressure Monitoring System, Vehicle Stability Assist System, Electric Power Steering) appeared all at once suddenly. I had the vehicle towed to my local Honda dealership for service. They gave me a diagnostic code of P0304 and insisted that the repair did not fall under my car's active powertrain warranty. I searched the web and found it is a common problem in Honda Fits. Some 2019 Honda Fits have an extended warranty for fuel injection replacement, but it is not applicable to my car for an unknown reason. Relevant service bulletins: 23-042 and 21-007

NHTSA ID

11649491

Incident

Nov 1, 2024

The check engine light came on. The vehicle was shaking/sputtering when idling. We took it into the dealership and they said we needed to replace the fuel injectors, despite the vehicle not even having 60,000 miles on it.

NHTSA ID

11647807

Incident

Feb 9, 2025

All warning lights cycle through on vehicle dashboard after turning on vehicle. Vehicle was taken to Honda Auto Service Center, where issue is diagnosed as Carbon Buildup, causing misfires. Error Diagnostic Code is one of P0300 - P0304. After maintenance, error clears out. However, there is a Honda Service Bulletin 23-042 which provides a warranty extension for Honda Fits of the same year, make, and model with the same issue, which my vehicle's VIN was not included as eligible. Issue of carbon buildup causing misfires may apply to other VIN ranges than in that bulletin, as accounted by NHTSA ID #11462041, #11490506, #11549767, and #11593466

NHTSA ID

11643451

Incident

Feb 14, 2025

Recall 23V-858 issued nearly 1 year ago. Honda notified that parts were available to those not currently experiencing direct fuel pump issues in September of 2024. Dealership was contacted in early October, late October, and mid-November but repeatedly claims that parts are not available. Although I was added to a waitlist, no indication of parts availability to remedy the recall has been provided.

NHTSA ID

11628975

Incident

Dec 4, 2024

The contact owns a 2019 Honda Fit. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11626772

Incident

Nov 22, 2024

The contact owns a 2019 Honda Fit. The contact stated that while driving at approximately 10 MPH, the vehicle lost motive power and failed to accelerate above 5 MPH before the vehicle stalled. The vehicle failed to restart and was later towed to the local dealer to be diagnosed. The contact was informed that the battery had failed and needed to be replaced. The battery was replaced along with the fuel pump which was included in the NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 40,000.

NHTSA ID

11626619

Incident

Oct 2, 2024

Mileage

40,000 mi

Four dashboard warning signs (Check Engine Light, Tire Pressure Monitoring System, Vehicle Stability Assist System, Electric Power Steering) appeared all at once suddenly. I had the vehicle towed to my local Honda dealership. They gave me a diagnostic code of P0304 and insisted that the repair did not fall under my car's active warranty. I searched the web and found it is a common problem in Honda Fits. Some 2019 Honda Fits have an extended warranty for fuel injection replacement, but it is not applicable to my car for an unknown reason. Relevant service bulletins: 23-042 and 21-007.

NHTSA ID

11624511

Incident

Nov 7, 2024

The contact owns a 2019 Honda Fit. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer and another dealer, Weir Canyon Honda (714-777-4100), were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11621734

Incident

Oct 24, 2024

See Attached Letter

NHTSA ID

11618941

Incident

Oct 10, 2023

The contact owns a 2019 Honda Fit. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11616453

Incident

Dec 18, 2023

We just had the fuel injectors fail for the 2nd time on this car, which has about 85,000 miles on it. The fuel injectors were originally replaced in 2021 by the dealer and have once again failed according to the dealer’s diagnosis. Honda America’s extended warranty for some Fits for this same issue needs to be extended to other model years. It is unreasonable to have to replace fuel injectors twice within this short of a time span.

NHTSA ID

11615964

Incident

Sep 20, 2024

The contact owns a 2019 Honda Fit. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11614002

Incident

Aug 15, 2024

Mileage

55,000 mi

All four fuel injectors have failed. Car only has 42,500 miles. Known issue and recall already in effect for previous years of same make and model

NHTSA ID

11611817

Incident

Aug 30, 2024

The contact owns a 2019 Honda Fit. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The contact stated that the failure occurred intermittently. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure; however, the manufacturer was unable to confirm when the part would be available. The failure mileage was 44,000. Parts distribution disconnect.

NHTSA ID

11605350

Incident

Apr 17, 2024

Mileage

44,000 mi

The contact owns a 2019 Honda Fit. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11593966

Incident

Jun 12, 2024

Fuel injector is going bad on my car at 80,000 miles causing catalytic converter to go bad based on two check engine codes. Recall done on 2015-2016 models so hoping this could be extended to 2019 as it seems they haven’t fixed the issue

NHTSA ID

11593578

Incident

Jun 10, 2024