2003 Honda Insight Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Honda Insight, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical233.3%
- Driver assistance116.7%
- Engine116.7%
- Fuel system116.7%
- Powertrain (other)116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
MY HYBRID BATTERY IS OVERHEATING WHICH MY HYBRID BATTERY IS 7 YEARS OLD WITH ONLY 31,680 MILES ON IT AND ITS AFFECTING THE INTEGRATED MOTOR ASSIST AND THE MONITOR SCREEN WITH THE CONTROL GAUGES AND MY VEHICLES ACCELERATION AND MAKING IT IMPOSSIBLE TO DRIVE WITHOUT IT SHUTTING OFF AND LOCKING UP, I TALKED TO HONDA AND THEY REFUSE TO FIX IT EVEN THO OTHER CUSTOMERS HAVE HAD THE SAME ISSUE WITH THE HYBRID BATTERY AND IT SHOULD STILL BE COVERED BECAUSE OF THE MILEAGE ITS BE USED FOR AND HAS BEEN STORED AND HIGHLY TAKEN CARE OF, THE EPA CLASSIFIES HYBRID BATTERIES UNDER EMISSIONS EQUIPMENT, REQUIRING MANUFACTURERS TO WARRANTY THEM FOR EIGHT YEARS AND 100,000 MILES. SOME STATES, LIKE CALIFORNIA, REQUIRE EMISSIONS EQUIPMENT TO BE COVERED FOR TEN YEARS AND 150,000 MILES. IF THE BATTERY FAILS WITHIN WARRANTY RANGE, YOUR TOTAL REPLACEMENT COST IS ZERO.
VEHICLE WAS STOPPED TO BE PARKED. AUTOMATIC TRANSMISSION WAS IN D(RIVE). KEY WAS TURNED OFF AND REMOVED. OWNER WALKED AWAY FOR APPOINTMENT. WHEN OWNER RETURNED, VEHICLE HAD MOVED. OWNER NOTICED VEHICLE WAS STILL IN D(RIVE). LATER TEST CONFIRMED KEY COULD BE REMOVED WITH VEHICLE IN D(RIVE). *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
MY HYBRID BATTERY IS OVERHEATING WHICH MY HYBRID BATTERY IS 7 YEARS OLD WITH ONLY 31,680 MILES ON IT AND ITS AFFECTING THE INTEGRATED MOTOR ASSIST AND THE MONITOR SCREEN WITH THE CONTROL GAUGES AND MY VEHICLES ACCELERATION AND MAKING IT IMPOSSIBLE TO DRIVE WITHOUT IT SHUTTING OFF AND LOCKING UP, I TALKED TO HONDA AND THEY REFUSE TO FIX IT EVEN THO OTHER CUSTOMERS HAVE HAD THE SAME ISSUE WITH THE HYBRID BATTERY AND IT SHOULD STILL BE COVERED BECAUSE OF THE MILEAGE ITS BE USED FOR AND HAS BEEN STORED AND HIGHLY TAKEN CARE OF, THE EPA CLASSIFIES HYBRID BATTERIES UNDER EMISSIONS EQUIPMENT, REQUIRING MANUFACTURERS TO WARRANTY THEM FOR EIGHT YEARS AND 100,000 MILES. SOME STATES, LIKE CALIFORNIA, REQUIRE EMISSIONS EQUIPMENT TO BE COVERED FOR TEN YEARS AND 150,000 MILES. IF THE BATTERY FAILS WITHIN WARRANTY RANGE, YOUR TOTAL REPLACEMENT COST IS ZERO.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
(1) AT 5000 MILES, WE HAD THE OIL CHANGED IN OUR 2003 HONDA INSIGHT AT RON NORRIS HONDA IN TITUSVILLE, FL. (2) AFTER 20 MILES, THE OIL PRESSURE LIGHT CAME ON AND WE HAD THE VEHICLE TOWED TO THE DEALER. THE DEALER CONCLUDED THAT THE OIL FILTER HAD NOT SEALED TO THE ENGINE PROPERLY AND ALL FO THE OIL HAD LEAKED OUT. THE ENGINE WAS DAMAGED. (3) THE DEALER REPLACED THE ENGINE AND PURCHASED AN EXTENDED WARRANTY FOR THE CAR. THE DEALER WOULD PROBABLY BE INTERESTED IN THE NHTSA'S INVESTIGATION ON SIMILAR EVENTS ON CRVS.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
MY HYBRID BATTERY IS OVERHEATING WHICH MY HYBRID BATTERY IS 7 YEARS OLD WITH ONLY 31,680 MILES ON IT AND ITS AFFECTING THE INTEGRATED MOTOR ASSIST AND THE MONITOR SCREEN WITH THE CONTROL GAUGES AND MY VEHICLES ACCELERATION AND MAKING IT IMPOSSIBLE TO DRIVE WITHOUT IT SHUTTING OFF AND LOCKING UP, I TALKED TO HONDA AND THEY REFUSE TO FIX IT EVEN THO OTHER CUSTOMERS HAVE HAD THE SAME ISSUE WITH THE HYBRID BATTERY AND IT SHOULD STILL BE COVERED BECAUSE OF THE MILEAGE ITS BE USED FOR AND HAS BEEN STORED AND HIGHLY TAKEN CARE OF, THE EPA CLASSIFIES HYBRID BATTERIES UNDER EMISSIONS EQUIPMENT, REQUIRING MANUFACTURERS TO WARRANTY THEM FOR EIGHT YEARS AND 100,000 MILES. SOME STATES, LIKE CALIFORNIA, REQUIRE EMISSIONS EQUIPMENT TO BE COVERED FOR TEN YEARS AND 150,000 MILES. IF THE BATTERY FAILS WITHIN WARRANTY RANGE, YOUR TOTAL REPLACEMENT COST IS ZERO.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
VEHICLE WAS STOPPED TO BE PARKED. AUTOMATIC TRANSMISSION WAS IN D(RIVE). KEY WAS TURNED OFF AND REMOVED. OWNER WALKED AWAY FOR APPOINTMENT. WHEN OWNER RETURNED, VEHICLE HAD MOVED. OWNER NOTICED VEHICLE WAS STILL IN D(RIVE). LATER TEST CONFIRMED KEY COULD BE REMOVED WITH VEHICLE IN D(RIVE). *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .