Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 679 NHTSA owner-reported complaints for the 2005 Honda Pilot. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 679 · page 1 of 28
A stuck ignition lock cylinder on a 2005 Honda Pilot. Hello I purchased this car from the second owner and they had the ignition lock replaced less than 2 years ago. This device has now failed again. Its a poor design by honda and was never fixed or recalled. This has lead countless people to be stranded. With repairs upwords of $500.
Power steering high pressure line leaking on exhaust and almost caused fire Dangerous. Lines need to be recall or replace
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. A Police Report was taken at the scene, and the vehicle was towed away. The cause of the failures was not determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 150,000.
The contact owns a 2005 Honda Pilot. The contact stated that while driving 25-35 MPH, the vehicle slowed down unexpectedly, and the brake pedal was hard and slow to respond when depressed. The contact stated that the steering wheel was pulling to the left, and it was difficult to correct the steering wheel. The vehicle was difficult to control. The VSA light was illuminated. There was a triangle with an exclamation mark symbol displayed on the instrument cluster. The vehicle was taken to the local dealer, where it was diagnosed and determined that the VSA module had failed and needed to be replaced. The vehicle was not repaired because the parts were on backorder. The manufacturer was not notified of the failure. The approximate failure mileage was 173,273.
The rear trailing arm, normally attached to the rear suspension is clearly corroded and came detached when driving under 25 mph up a road. The SAME issue Honda had to do a recall on their 2005 CRV model. Researched Honda Pilots, in our (Midwest) area, EVERY SINGLE 2005 Pilot had the corrosion. Also cause the muffler pipe to detach from the catalytic converter (included in the photos attached).
I was leaning back looking backwards while reversing and the front left seat bracket on the driver’s seat cracked and separated resulting in my seat turning into a rocking chair and my feet coming off of the pedals. It could have ended in an accident.
Airbag is deactivated due to failure of both crash sensors on the vehicle. Replacement parts are on national backorder.
The rear suspension got detached from a collapsed/rusted Frame. Item # 11 Sub-Frame, Rear Suspension Part # 50300-S9V-A01 The suspension is rubbing against the rear tires since the Bolt Flange (14x125 item# 14 part # 90160-S0X-A00) can’t be supported by the rusted/ collapsed Frame affecting the rest of suspension parts item # 12 washer E subframe part# 50354-S3V-A00 and item#13 part# 50456-S3V-A00 Washer F subframe Mounting.
The contact owns a 2005 Honda Pilot. The contact stated that while waiting in line at a gas station, she smelled a burning odor, and there was smoke coming from the steering wheel. The contact was turned off and restarted the vehicle. The contact stated that upon activating the low-beam headlights, the failure reoccurred. The contact stated that upon restarting the vehicle without activating the low-beam headlights, the steering wheel stopped smoking. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 12V136000 (Exterior Lighting). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was approximately 220,000.
The rear subframe attaches to the unibody has rotted and almost fell off the car
The drivers side seat bracket has a broken weld causing the seat to wobble & rock while driving the vehicle. From the Pilot Driver’s online forum it’s been known as a common complaint that Honda is not willing to confess to or interested in resolving as a safety design flaw as it seems to be related to multiple yrs 2004 & up of the Pilot vehicle & happens over time.
Ignition switch locked will not turn.
The contact owns a 2005 Honda Pilot. The contact stated while driving at various speeds on several occasions, there was a cranking sound coming from underneath the vehicle. No warning lights were illuminated. The contact stated that the vehicle was taken to an independent mechanic, where it was diagnosed that several unknown components needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the vehicle was towed to another independent mechanic, where it was diagnosed that the shocks, control arms, drive train and other unknown components needed to be replaced. The contact referenced the failure to NHTSA Campaign Number: 23V228000 (Structure); however, neither the VIN nor the year, make, or model was included. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 149,000.
My Honda pilot has rust on one of the subframe mounts causing it to come loose from body. Honda issued a technical service bulletin about it for an investigation from nhtsa. But, the dealer is acting like there is no such thing with the known issue and repair kit they made to fix the issue. I will attach the service bulletin below to about the issue of what Honda put out supposedly to fix the problem. They keep saying this bulletin does not exist for my vehicle but the bulletin states all years not VIN specific.
Was traveling down the road, had an electrical burning smell coming from my dash and around steering wheel. Low beams then shut off going down road pulled over but still had high beams but no low beams.
I parked my car in front of my house at 10pm the following morning my neighbor came to tell me my car was on fire. It had been raining the previous night. My driver window was not completely closed so rain got in my car. There was black smoke coming out of the window. When I opened my door, the driver seat & driver door was on fire. I grabbed the hose & put out the fire.
My vsa light came on when I was on the freeway and made my vehicle jerk almost pushing me into the next lane. It has been coming on and turns off when I restart the car and other cars of my same modal and year have recalls for this same issue but my vin yields no results for a recall.
On dry asphalt the vehicle stability control (VSC) periodically activates forcing the car either off the road or into the opposing lane. This has occurred 3 times in the past year, always on dry asphalt going in a straight line. Thankfully I live in a rural area, were there other cars on the road one instant could have caused a head-on collision. The VSC light comes on when this happens but no permanent CEL lights and the VSC light turns off after a restart. The recall work was done with the capacitor added to the circuit to smooth the signal and the ground connection under the driver side kick panel was cleaned according to the TSB, however, based on my experience and what has been reported by numerous other Honda Pilot owners this cheaper fix to replacing or repairing the yaw sensing circuit is concerning, particularly since Honda charges nearly $1000 for an OEM yaw sensor.
Travelling on interstate w/ cruise speed set @ 70 mph. VSA (vehicle stability assist) engaged with a brief grinding noise & pulled to the right. Very startling event. VSA activation indicator triangle light came on, as well as, the VSA system indicator light. Have experienced the event a dozen or so times on both the interstate and roads with a speed limit of 35/40 mph, without use of the cruise control. We are original owners of the vehicle and it has been diligently worked on throughout & currently has 230,000 miles on it. Awaiting delivery of a new vehicle, but intend for my newly licensed son to drive the vehicle. Took it to my repair shop, but they couldn't replicate the issue. Replaced both front speed sensors, but the issue occurred on the interstate drive home immediately after. Hope to be able to drop the vehicle off for an extended period once I take delivery on my new vehicle. Worried the issue will occur in rain or snow & be even more dangerous. Repair shop ran diagnostic showing the yaw issue, but said the Honda generated code report only went up to 25 mph. Has always pulled to the right during activation and the grinding noise is very evident & startling. Kinda feels like maybe the ABS anti-braking system engages on 1 tire for a brief few seconds in my non auto mechanic analysis.
The contact owns a 2005 Honda Pilot. The contact stated while driving at 20 MPH, the low beams of the vehicle went out inadvertently, almost causing the contact to crash into another vehicle that was coming from the opposite direction. There were no warning lights illuminated. The contact stated she turned on her high beams and was able to continue to drive the vehicle. The vehicle was taken to the independent mechanic who diagnosed that the terminal ends had melted within the wiring harness connector and the wiring harness connector or the lighting switch needed to be replaced. An unknown dealer was notified of the failure and informed the contact that her vehicle could not be repaired under the recall for NHTSA Campaign Number: 12V136000 (EXTERIOR LIGHTING) as her VIN was not included in the recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 290,000.
The contact owns a 2005 Honda Pilot. The contact stated that after starting the vehicle, the passenger’s side airbag light illuminated continuously. The vehicle was taken to an independent mechanic where it was diagnosed that the front passenger’s impact sensor needed to be replaced. The dealer was not contacted. The vehicle was repaired. The contact mentioned that a year later the failure recurred. The manufacturer was not notified of the failure. The approximate failure mileage was 100,000.
The Honda Pilots Engine Mounts are constantly having to be replaced prematurely than any other vehicle I have ever owned. This is an extremely dangerous part failure and an expensive cost to have. This dealership explained this is a known issue with these Hondas, yet no help or solutions from the manufacturer. There has to be some form of help or accountability for this type of negligence.
Takata recall. The contact owns a 2005 Honda Pilot. The contact received notification of NHTSA campaign number: 16V344000 (Air Bags) however, the part to do the recall was unavailable. The contact called the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Airbag tensioner seatbelt light is on (red one); AKA, SRS (supplemental restraint system) Dealership pulled codes 41-11 and 42-11, which are the front left and right impact sensors. They said the impact sensors "appear to be okay". but the main SRS computer unit control modular is "not working properly". The car has 137,000 miles on it and has not been in an accident and the light came on immediately when I started my car after it sat for a day without driving it. I live in rural area where no one could have tampered with my car. The dealership was perplexed and said they have seen this happen a lot recently and believe it is a defect in the SRS unit. The impact sensors are fine but the codes are being thrown for impact sensors, not the SRS unit; which they said if I paid 1,000 dollars (might) resolve the impact sensors error... if not, then I would have to pay another 900 for parts/labor to do the sensors as well. THIS IS A MANUFACTOR DEFECT THEY KNOW ABOUT THIS I CALLED MANY DEALERSHIPS AND THEY THINK THAT IT SHOULD BE WARRANTIED AS A SAFETY HAZARD... Honda will not yet acknowledge that me or my family could be killed because their computer SRS unit malfunctions. I will continue to support and buy only HONDA but I NEED this to be warrantied and replaced no cost out of my pocket. Please issue a recall or honor the repair cost IMMEDIATELY.
IN THE HIGHWAY THE CAR BRAKES FOR NO REASON FOR A MOMENT THAN IT RELEASE
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .