RoadVitals

2003 Honda VFR800 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Aug 15, 2007
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

07V359000

ELECTRICAL SYSTEM:WIRING

Aug 15, 2007
6,952 units potentially affected
The defect: ON CERTAIN MOTORCYCLES, THE FRONT FAIRING SUB-HARNESS (SECTION OF THE WIRING HARNESS) TRANSFERS THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHTS, FRONT TURN SIGNALS, INSTRUMENT PANEL, AND VARIOUS RELAYS TO THE MAIN WIRING HARNESS VIA AN 18-PIN CONNECTOR. UNDER CERTAIN CONDITIONS, THE GROUND WIRE TERMINALS INSIDE THE CONNECTOR CAN OVERHEAT, RESULTING IN MELTING OF THE CONNECTOR AND A LOSS OF POWER TO VARIOUS CIRCUITS.
The risk: AS A RESULT, A LOSS OF CRITICAL LIGHTING OR ENGINE POWER COULD OCCUR WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
The remedy: DEALERS WILL INSTALL A RE-DESIGNED SUB-HARNESS. IF DAMAGE IS FOUND, THE MAIN WIRING HARNESS WILL ALSO BE REPLACED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON SEPTEMBER 26, 2007. OWNERS WERE RE-NOTIFIED ON NOVEMBER 10, 2007, TO TAKE THEIR MOTORCYCLES TO DEALERS TO HAVE THE PARTS INSTALLED. OWNERS MAY CONTACT HONDA AT 1-866-784-1870.
HONDA (AMERICAN HONDA MOTOR CO.)View on NHTSA.gov
05V010000

SERVICE BRAKES, HYDRAULIC

Jan 24, 2005
36,046 units potentially affected
The defect: CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
The risk: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
The remedy: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.
HONDA (AMERICAN HONDA MOTOR CO.)Manufacturer number P65View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

AQ12001ClosedAudit Query

Southern Honda Powersports

Opened May 14, 2012
Closed May 13, 2013

NHTSA opened Audit Query (AQ) 12-001 to determine whether Southern Honda Powersports (Southern Honda) of Chattanooga, Tennessee, had complied with the requirements of the National Traffic and Motor Vehicle Safety Act, as amended, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among other things, that a motor vehicle or equipment manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with federal motor vehicle safety standards.In turn, a dealer may not sell and deliver a new vehicle subject to a recall unless the recall remedy has been performed.(see 49 U.S.C. 30120(i); 49 C.F.R. 573.11)NHTSA issued an information request to Southern Honda on May 14, 2012 to which they responded on July 6, 2012.NHTSA?s inquiry led it to believe that Southern Honda had failed to complete the requirements of five recalls that required inspections and/or repairs of motorcycles prior to their sale or delivery.NHTSA believes that 329 motorcycles affected by recalls had not been inspected and/or repaired prior to their sale and delivery between 2007 and 2012.The agency is unaware of any deaths or injuries involving these vehicles.NHTSA concluded that it had a potential civil penalty claim against Southern Honda for violations of the Safety Act.Southern Honda denied any violations of the Safety Act.In order to settle this matter, Southern Honda agreed to pay a civil penalty in the amount of $125,000, to be paid in five annual installments.This AQ is closed.

UNKNOWN OR OTHER
PE05047ClosedPreliminary Evaluation

STALLING & SUDDEN HEADLIGHT OUTAGE

Opened Sep 2, 2005
Closed Dec 20, 2005

ODI OPENED THIS INVESTIGATION AFTER RECEIVING THREE COMPLAINTS CONCERNING ALLEGED ENGINE STALLING AND/OR SUDDEN HEADLIGHT OUTAGES WHILE UNDERWAY.ODI ALSO FOUND NUMEROUS POSTINGS ON A WEB-BASED CHAT BOARD RELATED TO THE SUBJECT VEHICLE AND THESE ALLEGATIONS.FREQUENTLY, THE POSTING REFERENCED THE BLUE CONNECTOR JOINING THE MAIN HARNESS AND THE HEADLIGHT SUB-HARNESS.ODI HAS INSPECTED SUBJECT MOTORCYCLES AND ITS PEERS AND MET WITH THEIR OWNERS, DISCUSSED THIS MATTER WITH SUBJECT MOTORCYCLE DEALERS AND INDEPENDENT SERVICE PERSONNEL, AND REVIEWED HONDA'S RESPONSE TO OUR INFORMATION REQUEST.BASED ON THE INFORMATION GATHERED TO DATE, THE EVIDENCE SUGGESTS THAT MOST FAILURES HAVE DEVELOPED SLOWLY OVER TIME WITH THE OPERATOR NOTINGDIFFICULTY STARTING THE MOTORCYCLE,AND A SMELL OF MELTING INSULATION, (NO FIRES ARE REPORTED).IN THE MAJORITY OF REPORTS, THE PROBLEM IS NOTED WHILE STARTING THE MOTORCYCLE.MANY REPORTS STATE THE ENGINE STALLED WHEN THE STARTER BUTTON WAS INITIALLY RELEASED. FOR THE HEADLIGHT PROBLEM, MANY OF THE CIRCUIT OVERLOAD REPORTS WERE DUE TO THE INSTALLATION OF AFTERMARKET ELECTRICAL EQUIPMENT.CURRENTLY, NO DEFECT TREND HAS BEEN IDENTIFIED WARRANTING FURTHER EXPENDITURE OF AGENCY RESOURCES AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY THE AGENCY THAT NO SAFETY RELATED DEFECT EXISTS.ODI WILL CONTINUE TO MONITOR THIS ISSUE CLOSELY AND SHOULD CIRCUMSTANCES CHANGE, ODI WILL TAKE APPROPRIATE ACTION.

ELECTRICAL SYSTEMLed to recall 07V359000

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .