2001 Hyundai Elantra Brakes Problems

ALL 4 BRAKES STARTED TO RANDOMLY LOCK UP. I WAS DRIVING AND HAD TO RUN IT ALMOST A 1/2 MILE FOR A SHOULDER TO PULL OVER AT. UPON STOPPING, THE BRAKES WERE SMOKING ALL AROUND THE CAR AND THE FRONT DRIVER SIDE ACTUALLY CAUGHT FLAME. I'M GUESSING BRAKE BOOSTER IS THE CAUSE. ALSO FRONT CONTROL ARMS ARE ALMOST RUSTED THROUGH. THE CARS BEEN WELL MAINTAINED AND HAS AROUND 185,000 MILES ON IT. HAS VALVE COVER LEAK INTO SPARK PLUG PORT ON CYLINDER 3 AND HAS A VERY WEAK CLUTCH THAT SOMETIMES SLIPS.

NHTSA ID

11113663

Incident

Jul 18, 2018

Mileage

185,000 mi

TL* THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. WHEN THE BRAKE PEDAL WAS APPLIED, THE BRAKES FAILED TO FUNCTION PROPERLY. THE CONTACT HAD TO APPLY FORCE TO THE BRAKE PEDAL SEVERAL TIMES TO ENSURE THAT THE VEHICLE COMPLETELY STOPPED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO SERVICE THE BRAKE SYSTEM. IN ADDITION, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT OF THE VEHICLE ASSOCIATED WITH THE UPPER OR LOWER CONTROL ARMS. THE CHECK ENGINE AND AIR BAG WARNING INDICATORS REMAINED ILLUMINATED. ALSO, THE VEHICLE FAILED TO REFUEL IN A REASONABLE TIME FRAME, WHICH CAUSED THE CONTACT TO HAVE TO WAIT AN EXTENDED PERIOD OF TIME DURING REFUELING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10939603

Incident

Oct 10, 2016

TOOK 2001 ELANTRA TO DEALER AS A RESULT OF LOW BRAKE FLUID. DEALER DISCOVERED VEHICLE UNSAFE TO DRIVE AND IRREPARABLE DUE TO CORROSION OF REAR CROSS MEMBER AND/OR "SPUD". IT IS OUR UNDERSTANDING THAT THIS CORROSION OCCURRED IN THE AREA WHERE BRAKE FLUID WAS LEAKING. IT HAS BEEN SUGGESTED THAT THE PROBLEM IS DUE TO ROAD SALT. HOWEVER, WE ALSO HAVE A (LOWER-MILEAGE) 2005 ELANTRA WHICH WE KEEP PARKED IN THE SAME GARAGE AS THE 2001 ELANTRA AND WHICH, TO THE BEST OF OUR KNOWLEDGE, SHOWS NO SIGN OF CORROSION. *TR

NHTSA ID

10662530

Incident

Dec 3, 2014

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE BRAKE LIGHTS REMAINED ILLUMINATED UNTIL THE VEHICLE WAS TURNED OFF WHICH DRAINED THE BATTERY INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE BRAKE LIGHT SWITCH NEEDED TO BE REPAIRED. THE CONTACT WAS NOT NOTIFIED OF NHTSA CAMPAIGN ID NUMBER: 03V496000 (SERVICE BRAKES, HYDRAULIC) AND 03V257000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TO BE REPAIRED BY AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 35,700.

NHTSA ID

10608153

Incident

Jul 2, 2014

Mileage

35,700 mi

CAR SHIMMIES REALLY BAD AT 35 MILES AN HOUR REPLACED FRONT BRAKES AND ROTORS FRONT STRUTS TIE ROD ENDS BOTH INNER AND OUTER TO NO AVAIL I AM SICK OF PUTTING MONEY IN THIS PIECE OF JUNK. *TR

NHTSA ID

10489129

Incident

Jun 4, 2002

Mileage

24,000 mi

THE BRAKE LIGHTS STAYED ON ALL NIGHT AFTER CAR WAS PUT IN PARK AND ENGINE WAS TURNED OFF, CAUSING BATTERY TO LOSE ALL POWER. THIS COULD BE CAUSED BY A FAULTY BRAKE/STOP LIGHT SWITCH. A RECALL WAS ISSUED FOR BRAKE/STOP LIGHT SWITCH ON DIFFERENT YEARS AND MODELS OF HYUNDAI VEHICLES. MY 2001 HYUNDAI ELANTRA GLS WAS NOT INCLUDED IN THE RECALL BUT PROBABLY SHOULD HAVE BEEN. *TR

NHTSA ID

10472506

Incident

Aug 25, 2012

Mileage

160,000 mi

SINCE NEW, OUR 2001 ELANTRA HAS HAD AN INTERMITTENT "THUMPING" SOUND IN THE REAR WHEELS WHILE BRAKES ARE APPLIED. IT WOULD GO AWAY FOR MONTHS, THEN RETURN, USUALLY AFTER SOME MAINTENANCE EVENT SUCH AS A TIRE ROTATION. INTERNET SEARCHES REVEAL THAT THIS IS A VERY COMMON COMPLAINT. PEOPLE HAVE REPLACED ALL SORTS OF PARTS; WHEEL BEARING, SUSPENSION PARTS ETC., USUALLY WITH NO FIX. I FOUND THE CAUSE, AND THERE NEEDS TO BE A RECALL !! ON OUR MODEL, THE WHEEL NUTS ARE "CLOSED", MEANING THAT THEY ARE NOT DRILLED AND TAPPED ALL THE WAY THOUGH. ON OUR CAR, SOME OF THE WHEEL NUTS BOTTOM OUT ON THE WHEEL STUDS BEFORE THE BRAKE DRUM IS SECURED. WHEN BRAKES ARE APPLIED, THE RESULTING LOOSE BRAKE DRUM CAN "WOBBLE" ON THE STUDS, MAKING THE SOUND,. ANOTHER ISSUE CONTRIBUTING TO THE PROBLEM: THERE IS ONE PHILLIPS SCREW WHICH SECURES THE BRAKE DRUM TO THE HUB. IN MY CASE THIS SCREW WAS MISSING, PROBABLY HAVING BEEN LEFT OFF DURING A SAFETY INSPECTION. HOWEVER, IF THE NUTS WERE NOT BOTTOMED OUT, THE DRUM WOULD BE SECURE EVEN IF THE SCREW IS MISSING. IT WOULD SEEM THAT THIS CONDITION COULD EVENTUALLY LEAD TO STUD FAILURE. AT THE VERY LEAST, IT IS A SERIOUS AGGRAVATION. PROBABLY THE LEAST EXPENSIVE WAY TO FIX THIS WOULD BE TO REPLACE THE WHEEL NUTS WITH ONES THAT ARE DEEPER, ALLOWING MORE CLEARANCE FOR THE END OF THE WHEEL STUD.

NHTSA ID

10444330

Incident

Dec 2, 2002

TL* THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. HIS VEHICLE WAS REPAIRED ACCORDING TO RECALL 03V257000 ( SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS). AFTER THE REPAIR, HE NOTICED THAT THE BRAKE LINES HAD HOLES IN THEM WHICH CAUSED BRAKE FLUID LEAKAGE. THERE WAS NO COMPRESSION IN THE BRAKE LINE , SO THE PEDAL FELL COMPLETELY TO THE FLOOR DURING APPLICATION. HE TOOK THE VEHICLE TO THE DEALERSHIP AND WAS ADVISED THAT THE ENTIRE BRAKE LINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. NO REPAIRS WERE MADE. THE CURRENT MILEAGE WAS APPROXIMATELY 58,000. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.

NHTSA ID

10297160

Incident

Feb 2, 2006

Mileage

58,000 mi

TL*THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. WHILE DRIVING 25 MPH, THE DRIVER WAS UNABLE TO STOP THE VEHICLE. THE DRIVER'S SIDE OF THE VEHICLE CRASHED INTO A CURB. THERE WERE NO INJURIES. THE CONTACT NOTICED THAT THE FRAME OF THE VEHICLE WAS ROTTED. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE LOWER FRONT CONTROL ARM WAS RUSTED. NO REPAIRS HAVE CURRENTLY BEEN MADE TO THE VEHICLE. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT THEY WOULD COVER THE REPAIR COSTS. THE FAILURE MILEAGE WAS 99,000.

NHTSA ID

10259763

Incident

Feb 13, 2009

Mileage

99,000 mi

TL*THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. THE BRAKES WERE PUMPED SEVERAL TIMES BEFORE THE VEHICLE CAME TO A COMPLETE STOP. A SMALL AMOUNT OF SMOKE APPEARED UNDERNEATH THE HOOD. THE AIR BAG AND ENGINE WARNING LIGHTS ILLUMINATED INTERMITTENTLY ON THE INSTRUMENT PANEL. IN ADDITION, THE CONTACT EXERTED MORE EFFORT TO TURN THE STEERING WHEEL AS IF THERE WERE NO POWER STEERING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY REPLACED THE POWER STEERING HOSE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 98,000.

NHTSA ID

10242443

Incident

May 8, 2006

Mileage

60,000 mi

TL*THE CONTACT OWNS A 2001 HYUNDAI ELANTRA. THE FRONT PASSENGER SIDE WINDOW AIR BAG WAS REPLACED IN 2004. THE DAY AFTER THE REPLACEMENT, THE AIR BAG LIGHT ILLUMINATED AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY STATED THAT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT DISCOVERED AN AIR BAG SAFETY RECALL ONLINE, BUT THE DEALER STATED THAT NO RECALL WAS AVAILABLE. IN 2004, THE CONTACT ALSO INFORMED THE DEALER THAT THE WEATHER STRIPPING ON THE BACK DOOR FRAME WAS TOO SMALL. THE VEHICLE WAS STILL UNDER WARRANTY. THE DEALER PUSHED THE WEATHER STRIPPING BACK ON THE DOOR. IN 2005, THE CONTACT HEARD A STRANGE NOISE COMING FROM THE ENGINE COMPARTMENT AND THE VEHICLE STALLED IN HOT WEATHER. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. WHILE AT THE DEALER, SHE WAS INFORMED OF A BRAKE LINE RECALL AND CLIPS WERE APPLIED. THE FOLLOWING DAY, THE VEHICLE BEGAN SQUEAKING WHEN SHE APPLIED AND RELEASED THE BRAKES. THE RECALL NUMBERS WERE UNKNOWN. THE CURRENT MILEAGE WAS 84,448 AND FAILURE MILEAGE WAS 1,000. ABL.PCO

NHTSA ID

10208489

Incident

Mar 1, 2001

Mileage

1,000 mi

ABS SYSTEM FAILED DURING BRAKING, CAUSING REAR END COLLISION AIR BAGS DID NOT DEPLOY. *JB

NHTSA ID

10185241

Incident

Mar 15, 2007

Mileage

84,000 mi

10/28/05 CAR DID NOT STOP IMMEDIATELY WHILE PARKING, WENT THROUGH FENCE AND HIT DECK. BRAKES DID NOT HOLD IN SAND. CAR TOWED TO DEALERSHIP WHO INFORMED, NOTHING WRONG WITH BRAKES. ADVISED BY DEALERSHIP THAT THE RECALL ON BRAKES FOR HYUNDAI ELANTRA 2001 WAS REMEDIED BY THEM. BRAKES STILL DO NOT HOLD WELL, ADVISED BY ANOTHER MECHANIC THAT BRAKE SHOES ARE FINE. STILL DO NOT HAVE A GOOD COMFORT LEVEL WITH BRAKES. AIR BAG LIGHT ON, RECALL ON FILE FOR MODEL AND YEAR, DEALER ADVISED NOT FOR MY CAR. WILL FIX AT COST OF APPROXIMATELY $700.00. *NM

NHTSA ID

10181786

Incident

Oct 28, 2005

BRAKES FAILED. UNABLE TO STOP. HAD TO INITIATE EMERGENCY MEASURES--EMERGENCY BRAKE, PUT CAR INTO PARK.

NHTSA ID

10124234

Incident

Apr 20, 2001

Mileage

59,900 mi

2001 ELANTRA REGARDING REAR BRAKE TUBES RECALL NOTICE.*MR IT TOOK SEVERAL TRIES TO GET THE RECALL PERFORMED ON THE CONSUMERS VEHICLE. THE CONSUMER MADE AN APPOINTMENT TO HAVE THE REPAIRS MADE, HOWEVER WHEN THE CONSUMER SHOWED UP, THE DEALER WAS CLOSED, THE CONSUMER WAS TOLD THE DEALERSHIP HAD CHANGED OWNERSHIP AND TO CALL BACK. THE CONSUMER CALLED BACK TWICE AND WAS TOLD THEY WERE STILL CLOSED. THE CONSUMER TOOK THE VEHICLE TO ANOTHER DEALERSHIP AND WAS TOLD THEY WERE BOOKED DESPITE HAVING AN APPOINTMENT. THE CONSUMER TOOK THE VEHICLE BACK TO THE DEALERSHIP THE FOLLOWING DAY AND WAS TOLD IT WOULD TAKE MOST OF THE DAY, BUT WHEN THE CONSUMER RECEIVED THE VEHICLE, THE INVOICE STATED THE PART HAD TO BE ORDERED. *JB

NHTSA ID

10082175

Incident

Jul 1, 2004

CONSUMER COMPLAINED ABOUT A BRAKE PROBLEM. WHEN APPLYING THE BRAKES THEY VIBRATED.*AK

NHTSA ID

10057856

Mileage

1,000 mi

IT IS BACK AT EARNHARDTS, FOR THE ELEC. SYSTEM AGAIN 4TH TIME. IT STARTED IN 3/02 AND WENT OUT AGAIN LAST FRI. 6/6/03 BUT THEY DON'T CONSIDER IT A PROBLEM. BECAUSE I FILED A LEMON LAW ON THE PREVIOUS ACCENT AND REPLACED IT WITH THE ELANTRA 2001 AND I FILLED OUT A SURVEY SAYING THEY HAD BAD CUSTOMER SERVICE, THE NORMAL USE OF A RENTAL WHILE THEY FIXED IT FOR DAYS WAS NOT GRANTED. I AM SO UPSET I SPENT A DAY OUT IN THE AZ SUN WAITING FOR A TOW OF 205 MILES TO THE NEXT DEALERSHIP AND THEY TELL ME I HAVE A BAD RECORD WITH THEM AND DON'T DESERVE THE COURTESY OF A RENTAL CAR. THIS IS MY SECOND HYNDAI AND I HAVE HAD NOTHING BUT TROUBLE WITH IT AND THE DEALERSHIP. I HAVE SENT LETTERS TO THE ATTORNEY GENERAL, THREE ON MY SIDE, HYNDAI AND EARNHARDTS DEALERSHIP. I WANT OUT OF THIS CAR AND DON'T FEEL SAFE IN IT ANY MORE. I WAS GOING DOWN THE SALT RIVER CANYON (IF YOU ARE NOT FROM AZ PICTURE GOING DOWN THE TWISTING ROAD TO THE GRAND CANYON) WITHOUT ANY POWER STEERING, BRAKES AND TRYING TO KEEP CONTROL OF THE CAR WITH KIDS IN IT. AND THEY TELL ME I SHOULDN'T BE EXCITED! 1 1/2 HRS IN THE SUN WAITING FOR THE TOW, THE NEXT DEALERSHIP 200 MI AWAY, NO RENTAL CARS AUTHORIZED, SO MY HUSBAND HAS TO DRIVE UP AND GET ME (198) MILES FROM MY HOUSE AND GO BACK SO HE COULD BE AT WORK IN 3 HRS. NO SLEEP FOR HIM. THE DATES ARE 3, 4, 6 OF 2002 AND NOW 6/6/03. THE MILEAGE IS 27,694. THE COST IS THEIRS BECAUSE IT HAS THE 100,000 WARRANTY. JUST THE MENTAL AND PHYSICAL ANGUISH AND INCONVIENCE OF ANOTHER CAR THAT WON'T WORK RIGHT NOW.

NHTSA ID

10070368

Incident

Jun 15, 2003

Mileage

27,694 mi

CONSUMER HAD TO CONSTANTLY PUT BRAKE FLUID IN VEHICLE. WHEN THE BRAKES WERE APPLIED THE BRAKE PEDAL WENT TO THE FLOOR, AND VEHICLE HIT ANOTHER VEHICLE. THERE WERE NO INJURIES. THE DEALER WAS CONTACTED. *AK

NHTSA ID

10050425

CONSUMER COMPLAINED ABOUT A BRAKE PROBLEM. WHEN DRIVER APPLIED BRAKES WHILE DRIVING 25-30 MPH VEHICLE DID NOT STOP. CONSUMER'S VEHICLE REAR ENDED VEHICLE IN FRONT. CURRENTLY, VEHICLE WAS BEING RECALLED FOR BRAKE MALFUNCTION.*AK

NHTSA ID

10048311

Mileage

21,800 mi

WHILE DRIVING AT VARIOUS SPEEDS DRIVER DEPRESSED THE BRAKE PEDAL THE VEHICLE TOOK LONGER TO OPERATE, SO EXTENDED STOPPING DISTANCE WAS NECESSARY. *AK

NHTSA ID

10046475

Incident

Nov 6, 2003

Mileage

13,000 mi

WHILE DRIVING AT 30 MPH DRIVER APPLIED THE BRAKES AND THEY FAILED. VEHICLE TOOK LONGER TO STOP,AND IT REAR ENDED ANOTHER VEHICLE. PRIOR TO THE ACCIDENT, CONSUMER CALLED THE DEALER TO VERIFY IF NHTSA RECALL 03V25700 CONCERNING ABS FAILURE APPLIED TO HER VEHICLE. DEALER DENIED IT. THREE WEEKS AFTER THE ACCIDENT CONSUMER RECEIVED A RECALL LETTER ON THE ABS SYSTEM.*AK

NHTSA ID

10046092

Incident

Oct 30, 2003

Mileage

41,500 mi

BRAKING FROM HIGHWAY SPEEDS 70 DOWN TO 50 RESULTS IN SERIOUS VIBRATION AND PULSATION DUE TO OUT OF ROUND DISC BRAKE ROTORS. FEELS LIKE POSSIBLE LOSS OF BRAKING CONTROL. PROBLEM HAS EXISTED SINCE VEHICLE WAS NEW AND CORRECTED ONLY BY MACHINING THE FRONT BRAKE ROTORS. ORIGINAL ROTORS MACHINED 3 TIMES IN 65000 MILES. ORIGINAL ROTORS RECENTLY REPLACED WITH NEW OEM PARTS AND PROBLEM OCCURED AGAIN WITHIN 5K MILES. COMPLAINED TO DEALER AND HYUNDAI REGIONAL MANAGER. EXPLANATION WAS THAT ROTORS ARE NOT DEFECTIVE IF OUT OF ROUND AND CONDITION CAN BE CORRECTED BY MACHINING. APPEARS ROTORS ARE UNABLE TO WITHSTAND BRAKING TEMPERATURES AND WARP AS RESULT. QUALITY OF STEEL MATERIAL USED IN MANUFACTURING THE ROTORS APPEARS POOR. HYUNDAI DOES NOT SEEM TO ACKNOWLEDGE PROBLEM WITH FLAW IN MANUFACTURING PROCESS.*AK

NHTSA ID

10037562

Incident

Aug 31, 2003

Mileage

75,890 mi

ABS WARNING LIGHT INTERMITTENTLY FLASHES ON AND STAYS ON WHILE DRIVING. THIS COULD RESULT IN EITHER NONE DEPLOYMENT OR PREMATURE DEPLOYMENT OF AIR BAGS. CAUSE OF THE PROBLEM UNDETERMINED. *AK ABL.PCO

NHTSA ID

10034369

Incident

Aug 22, 2003

Mileage

19,000 mi

AIR BAG LIGHT CONTINUED TO ILLUMINATE EVEN AFTER (4) ATTEMPTS BY THE DEALERSHIP. THE ACTUAL CAUSE HAD NOT BEEN IDENTIFIED. MR ALSO THE VEHICLE EXPERIENCED BRAKE PROBLEMS. PH *JB ABL.PCO

NHTSA ID

8020796

Incident

Jun 30, 2003

Mileage

15,000 mi

WHILE TRAVELING ON THE HIGHWAY HE APPLY HIS BRAKES TO STOP. BUT IN THE PROCESS HE A ATTACK AND LOST CONTROL OF THE VEHICLE. PLEASE PROVIDE ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. TS

NHTSA ID

10001696

Incident

Dec 2, 2002