2025 Hyundai Ioniq 5 N

vehicle battery failure

NHTSA ID

11742827

Incident

Mar 18, 2026

Integrated Charging Control Unit (ICCU) failed while driving. Heard a pop from below the rear seats. "Check vehicle electrical system" message popped up initially, then changed to "Stop vehicle and check power supply" Vehicle could not exceed 20mph directly after failure, then lost all driving power just as I pulled the vehicle off the road. If I hadn't found a place to pull over in time, the car would have stopped in the middle of the road putting my safety and the safety of others at risk. Dealer inspected and took over a month to replace ICCU and 12v battery.

NHTSA ID

11720305

Incident

Aug 15, 2025

Car's ICCU blew as I was pulling out of my driveway. Was able to limp to the dealer. They replaced the ICCU in a week.

NHTSA ID

11719918

Incident

Jan 31, 2026

Driving under normal conditions, heard a “pop” near the rear of the car and within seconds had an immediate loss of power. The dashboard had lit up with “Check electric vehicle system” and was limited to 20 MPH on a 45 MPH road with no safe place to stop. Was able to limp car home, dealer confirmed ICCU was faulty and had to be replaced. My family was very very lucky to not be on a highway when this occurred. Hyundai has continuously failed to not only fix the ICCU issues with this vehicle, but also hasn’t extended the warranty on the faulty component here in the US like they’ve done in Asian markets. As a consumer, I’m begging the NHTSA to hold Hyundai accountable for these ongoing EV issues.

NHTSA ID

11716901

Incident

Feb 1, 2026

I have experienced two high voltage battery failures both requiring hv battery replacement. The first occurred around 6000 miles and the second occurred around 13,000 miles. I also had several dead 12v battery episodes where the card would be dead; even when plugged into the home charger overnight. I had to replace the 12v battery at 12000 miles.

NHTSA ID

11716115

Incident

Feb 10, 2025

ICCU failure and fuse, the car became unoperational and needed to stop. The car would no longer charge the 12V battery, and the EV battery would not charge. Hybrid Control Problem Detected at 3,160 miles. DTC P056216

NHTSA ID

11713949

Incident

Jan 27, 2026

What happened to me is a common problem with these models. I had an issue with the 12 V battery not being charged by the main battery as it should be. This led to a blowing of the main fuse which took out the ICCU unit. This seems to be fairly prevalent from what I can tell from online forums, and there needs to be a recall from Hyundai.

NHTSA ID

11707241

Incident

Dec 25, 2025

The contact owns a 2025 Hyundai Ioniq 5 N. The contact stated that while driving at 40 MPH, the service battery immediate warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer because the ICCU unit needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 8,000.

NHTSA ID

11700539

Incident

Nov 11, 2025

Mileage

8,000 mi

This bulletin provides information related to the navigation and head unit software changes introduced in the 2026 1st Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system. Refer to the 2026 1st Navigation Map and Software Update Key Improvements and Additional Improvements tables in this TSB for a list of specific changes. The software can be downloaded via Navigation Updater (NAU) and updated by USB.

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink functions. This may be due to an occasional disconnection on Verizon’s communication network. Follow the procedures in this bulletin to verify Bluelink Data Communication Unit (DCU) network connection and if needed, reset the DCU in Dealer Mode to resolve the connection.

Some 2019MY and newer vehicles equipped with a front view camera may illuminate certain warning lights and trigger DTC C272246 fault code for the front camera. In the following cases, the front camera auto-calibration range may be exceeded while driving: • If the front camera is not properly installed and is completely or partially detached. • In case of excessive changes affecting the vehicle's balance (e.g., loading excessively heavy cargo in a specific location of the vehicle, or significant under-inflation of the tires). • Specific road conditions affecting the vehicle's balance (e.g., excessive road crown) This TSB provides instructions on how to service the vehicle when the front camera related warning light(s) are triggered due to system out of calibration (DTC_C272246).

Certain IONIQ 5 N vehicles are equipped with a Left-Foot Braking (LFB) function designed for use on performance roadways, such as racetracks. Affected customers will be offered two options — either to remove or to retain the LFB feature.