2023 Hyundai Ioniq 5 Electrical Problems

The ICCU malfunctioned. Safety impaired because it likely impacted the ADAS, which concurrently failed. Yes, the problem has been inspected and confirmed by a dealer.

NHTSA ID

11752509

Incident

Jul 18, 2026

The contact owns a 2023 Hyundai Ioniq 5. The contact stated that while driving at higher speeds occasionally, the vehicle suddenly lost motive power. The "Smart Smooth Cruise Control Conditions Not Met" warning message was displayed on the instrument panel. The contact restarted the vehicle as a temporary fix; however, the failure recurred. The vehicle was taken to a local dealer where it was diagnosed with an unknown electrical failure. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the same local dealer; however, the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000.

NHTSA ID

11749330

Incident

Apr 21, 2026

Mileage

47,000 mi

I have a 2023 Hyundai Ioniq 5 Limited and had the ICCU "popped" (failed) which took about two weeks to replace. This time we were lucky that in happened at our home but had we been driving the car would it would have completed died. We regularly drive from from [XXX] to [XXX] were there are large section of [XXX] with no cell service. Meaning potentially walking for miles in extreme heat or cold. Hyundai right now seems only interested in continuously replacing the part rather than actually fixing the route cause, making it so the car is not trustworthy or safe to drive long distances. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11747025

Incident

Jun 14, 2026

1. What component failed, and is it available for inspection? The Integrated Charging Control Unit (ICCU) failed. The vehicle is currently at the dealer's service center, so the failed component is available for inspection upon request. 2. How was your safety or others' safety put at risk? After parking and re-entering the vehicle following a grocery stop, the vehicle displayed "Check Vehicle Electrical System" followed by "Check Vehicle Power Supply" warnings. This occurred without warning while the vehicle was in normal use, and the vehicle had to be towed since it was no longer driveable. The sudden, unannounced failure of the electrical/power system created a risk of being stranded in traffic or in an unsafe location had the failure occurred while driving rather than while parked. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The vehicle was towed to the dealer's service center, where the Hyundai-certified service technician confirmed the ICCU failed and informed us it needs replacement. 4. Has the vehicle been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by the dealer's Hyundai-certified service technician, who confirmed the ICCU failure. No additional inspection by Hyundai corporate, police, or insurance representatives has occurred at this time. 5. Were there any warning lamps, messages, or other symptoms prior to the failure, and when did they first appear? No warning lamps or messages appeared prior to the incident. The first symptoms were the "Check Vehicle Electrical System" and "Check Vehicle Power Supply" messages, which appeared suddenly upon re-entering the vehicle after a grocery stop, approximately one week after purchase (used) at roughly 8,000 miles.

NHTSA ID

11745637

Incident

Jun 13, 2026

OnXXX, as we approached what I call the 6 o’clock position of a round-about in [XXX], we had braked almost to a full stop (0-5 mph) to wait on the car ahead of us to enter the round-about when we felt increasing movement. Despite braking, to wait on that car, our car with increasing speed started shoving that car into the circle. Fortunately, he was able to drive away from us, but that car had been damaged on the back and right side. With that obstacle out of the way, our car rapidly and exponentially increased speed - all while we were fully braking. Two witnesses said they saw our brake lights as we sped along. We hit the curb as we approached the 12 o’clock exit, and that turned us so that we crossed both lanes of the road and headed towards the far sidewalk and storefronts. When we hit that curb it pushed us diagonally to face the street again. Hard to estimate but we must have been doing 50 mph when we hit a very large brick planter and we finally were wedged to a stop when we slammed in between two vehicles parked parallel to the sidewalk. The motor ran for a few seconds after we stopped, and finally quit on its own. We KNOW the brake was applied the whole time; there were no visual or audible alarms from the car as we entered “UNINTENDED ACCELERATION”. Despite the incredibly strong impact (our car has been deemed totaled) the front air bags did not deploy. Only the driver’s side curtain deployed. The bumper of the parked transport van on our front left was damaged, and the small SUV on our front right was deemed totaled. No people were in those two parked cars; the first car was hit at the initial slower speed so those people were not injured. By some grace, no pedestrians were in our path or they would surely have been killed. The driver of our car (my husband) was miraculously not injured, but CT scans and x-rays showed I had several contusions and a fractured tibia that will require surgery due to brake, propulsion, no air bags. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

NHTSA ID

11743216

Incident

Jun 2, 2026

Car indicated 12v battery was critically low and that I should stop safely. I was just starting it in a parking lot. This is a classic ICCU failure and the car is up to date on all recall updates. The car requires manual key unlocking for outside access at this point, and the rear hatch is only unlockable using the manual release mechanism which is recessed into the rear hatch and needs the key. The back two doors cannot be opened at all, from either direction and the handles don't work when the electrical system has failed and the child lock was engaged accidentally when it happened. This legitimately terrifies me for anyone traveling with back seat passengers who need quick exit. There isn't one.

NHTSA ID

11739646

Incident

May 22, 2026

The Integrated Charging Control Unit (ICCU) failed on my 2023 Hyundai Ioniq 5. The vehicle stopped charging prematurely overnight via AC Level 2 charging and then refused to charge again at all. The ICCU is responsible for maintaining the 12V battery by topping it up during normal operation. No warning or check engine light came on, I was only made aware when I attempted L2 charging and the car would refuse to take the charge. I understand that with a failed ICCU, if I'm unaware of the failure (e.g., relies solely on DC fast charging which bypasses the ICCU), the 12V battery can deplete without warning while the vehicle is in motion, potentially causing sudden loss of vehicle systems including power steering, brakes, and other safety-critical electronics. The vehicle was parked at the time charging failure was discovered. No injuries occurred.

NHTSA ID

11738922

Incident

May 14, 2026

The ICCU died a second time

NHTSA ID

11738416

Incident

May 17, 2026

ICCU failed at 20,000 miles, 2 years after I first got the vehicle. Blue link showed the P1a9096 ICCU code failure. Car could not be driven for more than a few minutes then the message to stop safely came about and car would die. It took the dealer 2 months to replace the ICCU with the SAME defective part. It is only a matter of time before it fails again.

NHTSA ID

11734215

Incident

Jan 14, 2026

Iccu failure. Vehicle stops working completely

NHTSA ID

11734182

Incident

Apr 3, 2026

My Hyundai IONIQ 5 has repeatedly lost 12V power and shut down. The vehicle had to be jumped by AAA multiple times. After being restarted, it died again, and after two days of use it was dead again. I am concerned this is related to the known ICCU / 12V battery charging issue affecting IONIQ 5 vehicles, which can cause loss of motive power or make the vehicle undrivable. The vehicle is currently at Hyundai Southern States in Raleigh, NC for diagnosis and repair.

NHTSA ID

11733953

Incident

Apr 24, 2026

See attached document for complaint.

NHTSA ID

11733495

Incident

Mar 13, 2026

On XXXXX, while parked at a campsite approximately two hours from my home, the vehicle displayed an “electrical failure” warning on the dashboard. The vehicle had been parked for less than 20 minutes when this issue occurred. I contacted Hyundai customer support that same evening to report the problem (Case #XXXXXX). On April 4, 2026, the vehicle was towed via Hyundai roadside assistance to Winner Hyundai in Dover, Delaware, where Tracy is my current point of contact. This situation left my family of four, along with our belongings and pet, stranded without transportation. Despite significant effort, we were unable to secure a rental vehicle in the Dewey Beach area, even after contacting multiple rental agencies and the dealership directly. This was later resolved, and I am currently in a rental through Enterprise; however, the stress and uncertainty of potentially being stranded was significant and unacceptable. While at the dealership, my wife witnessed the tow operator unloading the vehicle without proper equipment to safely lower it. As a result, the vehicle’s hitch made forceful contact with the pavement and became lodged. Multiple dealership employees observed the incident. After considerable effort to free the vehicle, it was released abruptly and rolled into another vehicle on the lot, causing additional damage. An argument then occurred between the dealership owner and the tow operator, which my wife was forced to witness. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11730289

Incident

Apr 4, 2026

There was sudden power reduced and turn to the limp mode(Turtle symbol popped up). After pull over my vehicle to highway shoulder, the vehicle became total power loss. Unable to drive anywhere. It was a dangerous situation for my family. We waited tow car and took my vehicle to Hyundai dealership which located close to my house. They diagnosed my car and after a day. They told me it needs to be replaced a ICCU assembly and Fuse. There was no ETA for the parts. They provided me a loaner’s car. After about 15 days, they fixed and I was able to take my car.

NHTSA ID

11730155

Incident

Jan 23, 2026

7 incidents of electrical drive problem incidents 1-3car would not start despite full battery Incident 4 same thing and car went to dealer, they said know problem and they would fix it overnight by downloading new software and charge about $400 for new 12V battery Incident 5 While on freeway using cruise control card speed varied wildly I disabled cruise control and with manual throttle same problem Incident. 6 In middle of traffic car went blank no lights or anything. I tried to restart 3 times and nothing, so I sat back and was in process of calling for tow. I did nothing and car violently accelerated and turned into steel pole. Only injury I had was bump on head that went away. As soon as the ghost mode engaged I hit the brake which likely prevented more damage to me, but front end of car was damage Incident 7 While I was detained someone else drove car to dealer and driver reported felt like driving on ice with rapid direction and speed changes Currently at dealer where neither dealer or Hyundai will take of problem and I get run arround from Hyundai and dealer. Dealer claim the don’t know is the problem. Dealer has had car for approximately 65 days Bottom line, the car is totally unsafe to drive and very dangerous

NHTSA ID

11729695

Incident

Feb 19, 2026

On 11/7/25 , we were driving my 2023 Hyundai Ioniq 5 to a friend's home in rural [XXX] , a trip of approximately 160 miles. At around 5:00 PM, we stopped about halfway to our destination to charge the battery. The car would not charge above 47%. While we continued to attempt to charge the battery, the console displayed a Check Electrical System Warning message, and we received the DTC P1AA700 via BlueLink. We were concerned about our safety on the drive up to the mountains. We were afraid the car would stop running on the highway and cause an accident. We were also concerned the car would die in a remote area and we would be stranded. However, the dealership was closed for the weekend. We drove carefully to our friend's home. I contacted Stevens Creek Hyundai on 11/10/25 and arranged to bring the car in on 11/11/25. It had 13,652 miles on it at that time. Eventually, the dealer confirmed the DTC P1AA700 and said they would need to order a new EGMP battery. The car was in the shop for 128 days, waiting for Hyundai to "build a battery" in [XXX] . Eventually, Stevens Creek Hyundai replaced the EV battery and I picked up the car. Given the delay in repairing my car and the growing evidence of Hyundai battery failures, we wanted to report this problem to the authorities. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11729574

Incident

Nov 7, 2025

While driving the vehicle, the ICCU failed. The vehicle shut down in the middle of traffic without any warnings.

NHTSA ID

11729262

Incident

Mar 20, 2026

Failure of Integrated Charge Control Unit (ICCU). Vehicle stopped charging 12V service battery from main high voltage battery. Displayed "Check Electric Vehicle System" followed by "Stop vehicle and check power supply". Vehicle to operate normally though Cruise Control stopped working. Continued to drive the few miles to our home. Once home checked service battery with battery monitor. Showed 12.1V and did not show battery being charged with vehicle ON (Ready) or OFF. Had vehicle towed to Hyundai service facility where the ICCU failure was confirmed.

NHTSA ID

11728787

Incident

Mar 25, 2026

On Mar 29th, I got a 12v battery low voltage warning sign at 4pm. Jumpstarted the car and drove back to the home. On Mar 30th, car would not start so I had it towed to Downey Hyundai by roadside assistance. On Mar 30th, 12:41pm dealer confirmed that the it will need an "ICCU" and have ordered the part, but there are no loaners and no ETA for the part at this time. Problem has been reproduced and confirmed by dealer. There were no other warning signs prior to the failure.

NHTSA ID

11728697

Incident

Mar 29, 2026

My vehicle lost power as I was driving after warnings from the electrical system. The vehicle was towed to a Hyundai dealership where it was diagnosed with ICCU failure. The ICCU system was replaced by dealer.

NHTSA ID

11727468

Incident

Jan 31, 2026

ICCU failed

NHTSA ID

11727345

Incident

Mar 12, 2026

AWD functionality of car broken. Had to get traction motor replaced.

NHTSA ID

11727344

Incident

Jan 2, 2026

Car lost charge quickly, went into limp mode while I was driving on the highway. I had to pull of the road several times and try to get it to a charging station. It barely made it after the lose of power. Charged it to 80% and it would only go up to a range of 100 miles. Took it to the dealership and they confirmed it needed a whole new main battery. ICCU had already been replaced. Had to wait over 5 months for replacement parts.

NHTSA ID

11726747

Incident

Oct 15, 2025

My 2023 Ioniq 5 had the ICCU replacedin 2025 and then it failed again in late January 2026. The car has been at the dealership since then awaiting a new part.

NHTSA ID

11726622

Incident

Jan 29, 2026

The ICCU unit malfunctioned and needed to be replaced. It occurred while I was driving home and I was lucky enough to make it to my driveway. If it had been on the freeway I would have been stuck.

NHTSA ID

11726200

Incident

Mar 9, 2026