2024 Hyundai Ioniq 5 Problems

On 5/27/26, when the car was parked in parking lot, received an alert on dashboard, "check electric vehicle system", when the car was turned on. The car would not shift in to drive or reverse so had to get towed to nearby Hyundai dealership. The EV system was recalibrated and test driven 122 miles to verify proper operation. Then on 6/23/26, when driving on road received an alert on dashboard "power limited". The car would not accelerate and had to get it towed again to same dealership. The dealership performed tests on ICCU and 12V battery but came back negative.

During routine driving, the vehicle suddenly displayed an electrical system. Error code followed several minutes later by a 12-volt battery error. The vehicle was stopped and turned off. When turned back on all warnings disappeared and vehicle was returned to service for approximately 3 MI before warnings appeared again. Vehicle was then parked as it entered limp mode with a maximum speed of 11 mph. manufacturers roadside assistance was called and arrived to jumpstart the 12-volt battery which resulted in the vehicle turning on but not charging despite sufficient charge in the high voltage battery. Vehicle was stranded in a secure parking lot after hours with Windows unable to be closed and doors unable to lock. The vehicle is immobilized due to being unable to put the vehicle into neutral to move it to a suitable location for a tow. Vehicle was certified by dealership as a certified pre-owned vehicle approximately 45 days ago. All listed recalls have been checked and no undue stress has been placed on the vehicle since purchase. Vehicle stranded to adults and one toddler in 80 plus degree heat without any ability to remove the car to a safe location or secure transportation to an appropriate business.

This is an EV . We use the regenerative braking to slow down. This car has both a front and rear dash cam. The car is about two and a half years old and has about 20,800 miles. We were approaching a red traffic light with several vehicles stopped in front of us. My partner was driving and had slowed to 8 mph, with her foot off the accelerator, advancing slowly towards the car in front of us when the vehicle experienced unanticipated, rapid acceleration. With quick reflexes, she was able brake hard and avoided a collision. Ten minutes later she was parking at our house, going 4 mph and it did it again, coming within four feet of the building. Neither time was she touching the accelerator, but the car accelerated like the accelerator was pressed to the floor. This is very dangerous.

On June 13, 2026, my 2024 Hyundai Ioniq 5 experienced a sudden and dangerous propulsion failure while in active motion. The vehicle had approximately 9,447 miles on it and was at 58% battery charge at the time of the incident. The vehicle was leased in January 2025 and has been serviced exclusively at the Hyundai dealership. While driving with two occupants, the vehicle abruptly lost all ability to accelerate. The dashboard displayed a critical warning: “Stop vehicle and check power supply” along with a red battery icon. This failure occurred without warning and immediately placed us in danger of being struck by surrounding traffic, as the vehicle could no longer maintain speed or respond to throttle input. I was able to coast the vehicle off the roadway. Shortly after stopping, the vehicle issued an additional warning stating that auxiliary functions were draining the battery. Within moments, the vehicle shut itself down completely. This left both occupants stranded in extreme heat (over 100°F) with no air conditioning, no ventilation, and no ability to restart or power the vehicle while waiting for rescue. This created a serious risk of heat-related medical distress in addition to the initial roadway hazard. The vehicle’s complete loss of propulsion followed by a full electrical shutdown represents a severe safety defect. At no point should an electric vehicle with more than half a charge and fewer than 10,000 miles lose propulsion during active driving or shut down all systems while occupants are inside. This incident posed a significant risk of collision, injury, or heat-related harm. I am requesting that NHTSA investigate this failure mode, as it may indicate a broader defect affecting the propulsion or battery management systems of the Hyundai Ioniq 5. The vehicle is currently at the Hyundai dealership undergoing diagnostics and they confirmed they had difficulty jumping it to move it from where the tow truck had parked it on arrival.

Was driving to vegas, it was 103-107 degrees After fast DC charging drivetrain had issues that when pressing acceleration the car would have almost a loss in power that caused a stuttering movement. If forcefully driven, the error message drivetrain electrical system would pop up. Issue can be resolved but only after letting the car stay in park for 10-15 minutes after finished charging. Issue was repeatable but only if weather was hot enough. This shouldn't happen or at least warn the driver to not drive for a certain period instead of guessing the issue.

As I began a drive cycle, I heard a pop sound and received the “check electric vehicle system” warning associated with ICCU failure. With ICCU failure, if I had continued to drive the 12V battery would have run to zero and the car would have died completely. Vehicle goes to dealer tomorrow for confirmation.

The car engine shutdown mid drive. One minute before the complete stop, the car was stalling every 20 sec or so, then the acceleration stop responding to the drive pedal. The car was gliding to a stopping point. The "Engine " warning was on the display. Afterward, the car was towed to the Earnhardt Hyundai North Scottsdale, where the service center could not recreate the problem. They concluded that is a non issue since they did not observe the same issue during the test and diagnostic.

On June 13, 2026, my 2024 Hyundai Ioniq 5 experienced a sudden and dangerous propulsion failure while in active motion. The vehicle had approximately 9,447 miles on it and was at 58% battery charge at the time of the incident. The vehicle was leased in January 2025 and has been serviced exclusively at the Hyundai dealership. While driving with two occupants, the vehicle abruptly lost all ability to accelerate. The dashboard displayed a critical warning: “Stop vehicle and check power supply” along with a red battery icon. This failure occurred without warning and immediately placed us in danger of being struck by surrounding traffic, as the vehicle could no longer maintain speed or respond to throttle input. I was able to coast the vehicle off the roadway. Shortly after stopping, the vehicle issued an additional warning stating that auxiliary functions were draining the battery. Within moments, the vehicle shut itself down completely. This left both occupants stranded in extreme heat (over 100°F) with no air conditioning, no ventilation, and no ability to restart or power the vehicle while waiting for rescue. This created a serious risk of heat-related medical distress in addition to the initial roadway hazard. The vehicle’s complete loss of propulsion followed by a full electrical shutdown represents a severe safety defect. At no point should an electric vehicle with more than half a charge and fewer than 10,000 miles lose propulsion during active driving or shut down all systems while occupants are inside. This incident posed a significant risk of collision, injury, or heat-related harm. I am requesting that NHTSA investigate this failure mode, as it may indicate a broader defect affecting the propulsion or battery management systems of the Hyundai Ioniq 5. The vehicle is currently at the Hyundai dealership undergoing diagnostics and they confirmed they had difficulty jumping it to move it from where the tow truck had parked it on arrival.

This is the second time the ICCU failed. The car is waiting for a full EV battery replacement. The first time the failure happened on 12/11/25, at 9,165 miles, the alert happened just before the car came to a full stop as we were driving along the road near our house, it was very difficult to steer, we were sort of stopped in the road and had to get it towed. The second time the alert came on 4/16/26 and we were able to get it to the dealer.

While driving northbound on US-280 freeway, the vehicle experienced sudden deceleration with maximum speed limited to approximately 40 mph. The dashboard displayed a "Check Power Supply" warning. The vehicle required a tow to the dealership. Dealer diagnosis indicates likely ICCU (Integrated Charging Control Unit) failure. This is a known issue affecting multiple Hyundai Ioniq 5 vehicles, with numerous consumer reports of the same failure mode. The sudden loss of propulsion at highway speed created a significant safety hazard though we were able to make it off the freeway with hazards on. However shortly after exiting the vehicle further slowed and eventually died on the side of the road as did the hazard signals.

“While stopped at a red light my 2024 Hyundai IONIQ 5, the car moved forward slowly the brake pedal became completely unresponsive and would not slow or stop the vehicle. I had to turn off the engine to bring the car to a stop. This is a complete brake system failure on a vehicle with only approximately 10,000 miles that was purchased new on September 28, 2024. This is a critical safety defect that put myself and others at serious risk.”

On [XXX] at [XXX] Pacific Time , I was entering my garage when my vehicle had a surge of acceleration and went through thee wall seperating the garage from the kitchen. There wasn't any emergency braking , even with myself applying the brake , my vehicle refused to stop. My vehicle was totaled by Progressive Insurance .I am now furnishing the Progressive claims name and adjuster"s phone number: Grace Villard 440-910-6852. North Las Vegas Police Dept Accident report #[XXX] It was the Progressive Insurance aduster ,vehicle inspector who called me and told me there was a safety issue with my vehicle and declared it a total loss. Whatever aid you can avail me to I'd appreciate.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The tubing that is used to connect the windshield washer reservoir to the nozzles that deliver the washer fluid to the windshield is prone to rodent activity. This tubing has been punctured by rodents twice now - with one intervening tube replacement. I have to replace the tubing again today. It has been less than two weeks since I last replaced the tubing. The replacement tubing was purchased from a Hyundai dealership. It appears that this will be an ongoing issue that will impact the operational safety of the vehicle.

I purchased a 2024 Ionic 5 on January 29th on a day without rain/snow. The first time it rained I found out that there was no rear wiper. I assumed there to be one as its a SUV with a slanted back window, not straight up and down. When it rains or snows the water/snow just sits on the back window, making it impossible to see out the back window. I know every Ionic 5 is like this. On researching the 2025's now have them due to customer feedback. I don't believe this is a convenience issue, but a safety one not being able to see out the back window.

Going thru a parking lot to a drive thru at a fast food place, rounding a small curve at a very low speed then trying go to 1 st lane out of 2 lanes the car suddenly went out of control and accelerated to center pole. The pole was a barrier protecting the support pole for the canopy. The car front center hit the pole so hard that the front collapsed. The hood buckled in the center and the pole went half way to the windscreen. The air bags did not deploy. The driver got hit with steering or something in the chest and caused lot of pain for about 10 days. No internal injury was detected. The car was totalled. The car did not complain of any incident except the dash reported something binding when tried to back off from the pole. The car repair company declared it as write off including the auto insurance company. Police was called and they did not take any data no other investigation was done. We feel the car computer malfunctioned and caused the accident.

Vehicle steering or at least power steering failed catastrophically. Started with some electronic sounds at extremes of turning radius but subsequently failed completely and rendered car undriveable. Hyundai repair center attributed this to "excessive dirt and dust" or some external force, but was unable to substantiate or demonstrate any damage to parts they say need replacing. Ultimately this remains undiagnosed with regards to cause but dealer clearly identifies need to replace P/S motor and rack and pinion assembly. Insurance inspection documents no sign of external involvement in the failure. No warning lights/messages. Problem is repeatable. While failure would have been a safety risk at higher speed, it went from "noise at edge of turning radius" to "cannot steer the car" at a point in time where the car was moving at low speeds.

As we drove toward the highway to begin our journey home in our 2024 RWD Ioniq 5 with our entire family and luggage in the vehicle, we received a "Check Electric Vehicle System" warning and immediately pulled over and called Hyundai Roadside Assistance. They initially were going to send someone to jump the car, assuming it was an ICE, but once we said it was an EV, they said they didn't have the equipment to jump an EV. We then spoke to Hyundai Customer Care, and we reported that we received the "Check Electric Vehicle System" warning. The HCC rep said that she did not see any issues with the vehicle on her end, so we would be OK to drive it. We specified that we had a 1.5 hour drive home and asked her explicitly if we would be OK to drive this length of time with this warning and make it home? She again said that we would be OK to drive it. After getting off the phone with her, we proceeded onto the highway and within about 2 minutes, received the "Stop Vehicle and Check Power Supply" warning and then, within a few seconds, began to lose power. This was extremely dangerous, as we were going down a hill on a highway frequented by semi trucks in the rain. Fortunately, we were still able to turn on the hazard lights and coast into a nearby hotel parking lot. As we were losing power, we were afraid we would not be able to get out of the car because all the doors were locked and the windows were up due to the rain, so we quickly unlocked two of the doors as soon as we pulled into the parking lot. One of us then had to stay with the car at all times because we couldn't lock or unlock the car. We eventually had the car towed to the Hyundai dealer closest to us who determined that the ICCU and fuse had failed and needed to be replaced, but they could only replace them with new parts of the same design that could potentially fail again; Hyundai does not yet have a fix for the ICCU failure.

On the morning of [XXX] I received an error message on my dashboard (attached) "Stop Vehicle and Check Power Supply". The car had started to lose acceleration power to no more than 30MPH. I contact the service department at my local dealer. They instructed me to bring it in or have it towed. I was about 2 miles from home so I headed back. While in transit the car lost all power in the middle of traffic. It stopped completely ! No emergency flashers, lights, power for the doors, windows, etc. I could not even put into Park. If I lifted my foot off of brake, it started to roll backwards. Luckily I was not on the expressway or at a railroad crossing. Fortunately a local police officer saw my dilemma and directed traffic and pushed my car to the side of the road ([XXX]) After doing research online I found this to be a common issue with Hyundai/Kia EV vehicles. The ICCU fails with no warning leaving drivers stranded.. The unit is on backorder because of so many failures and there is no ETA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Going thru a parking lot to a drive thru at a fast food place, rounding a small curve at a very low speed then trying go to 1 st lane out of 2 lanes the car suddenly went out of control and accelerated to center pole. The pole was a barrier protecting the support pole for the canopy. The car front center hit the pole so hard that the front collapsed. The hood buckled in the center and the pole went half way to the windscreen. The air bags did not deploy. The driver got hit with steering or something in the chest and caused lot of pain for about 10 days. No internal injury was detected. The car was totalled. The car did not complain of any incident except the dash reported something binding when tried to back off from the pole. The car repair company declared it as write off including the auto insurance company. Police was called and they did not take any data no other investigation was done. We feel the car computer malfunctioned and caused the accident.

While driving the car on the highway at about 50 mph, the driver side door unlatched and opened.

Going thru a parking lot to a drive thru at a fast food place, rounding a small curve at a very low speed then trying go to 1 st lane out of 2 lanes the car suddenly went out of control and accelerated to center pole. The pole was a barrier protecting the support pole for the canopy. The car front center hit the pole so hard that the front collapsed. The hood buckled in the center and the pole went half way to the windscreen. The air bags did not deploy. The driver got hit with steering or something in the chest and caused lot of pain for about 10 days. No internal injury was detected. The car was totalled. The car did not complain of any incident except the dash reported something binding when tried to back off from the pole. The car repair company declared it as write off including the auto insurance company. Police was called and they did not take any data no other investigation was done. We feel the car computer malfunctioned and caused the accident.

While turning a corner at low speed to enter a parking lot, the right rear tire lifted up onto the curb. The car stopped at a parking spot 100ft later. A low tire pressure alarm indicated an issue, upon inspection there was an audible hiss and the right rear of the car was lower than the other sides. As there was no spare, roadside assistance was contacted and towed the car to the nearest dealership for estimate. The dealer found the right rear wheel was bent on the inside and the wheel, tire, pressure sensor would need to be replaced. The cost was $1,612.68 and was covered by insurance. The point of failure on the wheel was not at the site of impact with the curb. The right rear wheel/tire would touch the curb on the outside first. There was no observable damage to the outside wheel. The inside wheel would have been exposed to much less force, most due to the mass of the car lifted on that corner. If not related to the specific wheel, but to the design, repeat incidents can happen when hitting potholes or other road obstacles/debris and result in a quick deflation while at speed. There was no visible damage, cracks, impressions on the tire. Only the rim was visibly damaged by this incident. The car had been purchased 4 days prior.

The yellow airbag SRS critical safety restraint wire runs exposed and loose and drooping beneth the front seats with NO space between the harness and the floor (it could have been run above the seat plate or otherwise protected. Mine snagged on something and was torn from the terminal block and has disable the airbag. Hyundai denies it a defective design or assembly and had denied warranty coverage but wants $10,000 to enable it - $6,933 for the part - $3,000 labor. The driver seat moves back and forth automatically when entering and existing - there is no control of the movement and anything more than 1/2 high is able to become tangled and disable the airbag without warning. Hyundai via emails to their legal counsel as well as customer care is fully advised but has denied warranty status or other fix or accomadation. The warrenty for this car - for which coverage has been denied - is in full force per Hyundai's express terms. This is a critical safety issue which upon limited investagation effects numous ioniq5's of multiple years besides the 2024 limited. Note also the 2024 limited has a movable drivers seat foot rest which is prone to sweep matters under the seat when lowered.

TIRE SIZE 235 / 55 R 19. Vehicle is a 2024 IONIQ 5. Issue began at/around 10k miles of use. Sound dampening foam inside of the tires comes loose and bunches up in the tire, creating varying degrees of car shaking and vibration. At its worst, the steering wheel and tires violently shake, especially between 50 - 75 mph. On the highway this causes a very dangerous situation of the driver fighting the wheel to remain safely within their lane. This can happen with no warning (or very little) as the vibration may be subtle at lower speeds on local roads, only to become unexpectedly extreme and violent while speeding-up to join highway traffic. Local Hyundai dealership inspected and tried rotating and balancing which did not fix the problem. Finally they removed the tires and inspected the foam which fixed the issue on one single tire. Cost was passed to the consumer, who is not at fault. And with only one tire addressed, the potential remains for each tire to experience the same failure without warning as time goes by. This is a very dangerous issue, well known as evidenced by complaints since 2023 online, and is going to cause accidents. It is unacceptable that drivers have risk their safety and that of other drivers if they lose control of the car due to the inability to control the steering wheel. Then have to pay to fix this issue or pay for new tires after only 10-12k miles.

The yellow airbag SRS critical safety restraint wire runs exposed and loose and drooping beneth the front seats with NO space between the harness and the floor (it could have been run above the seat plate or otherwise protected. Mine snagged on something and was torn from the terminal block and has disable the airbag. Hyundai denies it a defective design or assembly and had denied warranty coverage but wants $10,000 to enable it - $6,933 for the part - $3,000 labor. The driver seat moves back and forth automatically when entering and existing - there is no control of the movement and anything more than 1/2 high is able to become tangled and disable the airbag without warning. Hyundai via emails to their legal counsel as well as customer care is fully advised but has denied warranty status or other fix or accomadation. The warrenty for this car - for which coverage has been denied - is in full force per Hyundai's express terms. This is a critical safety issue which upon limited investagation effects numous ioniq5's of multiple years besides the 2024 limited. Note also the 2024 limited has a movable drivers seat foot rest which is prone to sweep matters under the seat when lowered.