Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 179 NHTSA owner-reported complaints for the 2022 Hyundai Santa Cruz. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 179 · page 1 of 8
The cars transmission has become very jerky at low speeds. The drive train will either hesitate or rev without power for a couple seconds. The problem started at around 14k miles.
The transmission failed. The dealership computer identified the failure with Safety Recall 236.
October 2025 while driving the vehicle at highway speeds, vehicle started bucking, losing power and then stalled. The check engine light did not come on. I was able to get off the side of the road and had it towed to the dealer. Dealer found injectors to be leaking and replaced all 4 GDI fuel injectors-mileage was 29,598. On July 1, 2026, again the same issue while driving the vehicle at highway speeds, it started bucking, losing power and stalling when slowed. This time the check engine light came on. Again, it was undrivable and had to be towed to the dealer. Dealer found after 15,000 miles, some of the new injectors failed and were leaking and all 4 GDI injectors were replaced again-mileage 44,492. Both times there was no warning signs that the fuel injectors were about to fail. No other tests were performed on the engine to find out why the fuel injectors are repeatedly failing. I have filed a report with Hyundai National Consumer Affairs because the vehicle will be out of warranty by the end of 2026, and the underlying issue has not been investigated nor resolved. I am concerned that once vehicle is out of warranty, a major issue with the engine will be found that caused repeated failure of the fuel injectors. I did request an extension of the warranty, but was told that normally doesn't happen.
The tailgate of this vehicle opened by itself while driving and pulling a trailer. The key fob was stored safely in the cup holder of the vehicle. When I attempted to back the trailer into a driveway, the open tailgate was caught between the vehicle and the trailer, causing serious damage to the tailgate as well as the trailer that was being towed. If items that were stored in the bed of the vehicle had fallen out into the path of another vehicle or pedestrian, they could have been injured or killed. This problem has been reported to both my local Hyundai dealership as well as to the Hyundai Corporate Case Management group (HCCM). (case #[XXX] of the HCCM) The dealership attempted to reproduce the incident while the vehicle was parked in the shop and was unable to duplicate the condition that happened while driving on a rough public road, towing a trailer. No warning lamps or messages appeared prior to the failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving my vehicle on a two-lane highway, I experienced multiple sequential electronic system failures (including the vehicle no longer detecting the smart key), and all electronic systems on the car became inoperative. I lost all instrumentation, including my speedometer and tachometer. At the same time, I also experienced a loss of motive power, and the engine of the vehicle began running extremely erratically before completely cutting off. I attempted to make a safe stop on the side of the road, but after doing so, could not restart the vehicle. The electrical systems of the vehicle continued to behave erratically, and the engine would not restart. I contacted roadside assistance, but they were unable to start the vehicle as well. It was towed to my local Hyundai dealership, but instead of expressing any genuine concern for the significant risk I endured while being placed In harm's way, they refused to fully diagnose the vehicle, and instead accused me of "jumping in reverse," even though I did no such thing (and don't even know what that means). The dealership has no evidence to suggest any such event took place, and simply wants me to pay over $1,800 for replacement of the battery connection terminals, despite being in-warranty. Obviously, the vehicle was already running – there is no way that the dealership's false allegations could possibly be correct. I contacted Hyundai Motor America and was assigned a caseworker, but they were not interested in finding a resolution, and unable to compel the servicing dealership to perform a full diagnostic or provide warranty service. Feeling that I was running out of options for the vehicle to be properly diagnosed, I contacted the dealership where I purchased the car, and provided the photographic evidence & service documentation required. They agreed that there's no way that I could have created this issue, and that further investigation is warranted, but HMA only cares about money – not my or my family's safety.
Loss of power from the engine while accelerating from a stop in heavy traffic. Car began shaking and sputtering with intermittent spurts of power, unable to exceed 10 mph on narrow bridge. Pulled over and the vehicle smelled heavily of gasoline near the engine. This issue is the Third instance of my engine sputtering and losing power. The first instance, injectors 2 & 4 were replaced. The second instance Injector 3 was replaced. I followed dealer recommendations and only used top tier gas from busy stations, and manufacturer technician recommended techron additive every 1000 miles. There have been two additional instances where the engine sputtered but regained power, with the dealer unable to replicate the issue.
The contact owns a 2022 HYUNDAI Santa Cruz. The contact stated while driving 74 MPH, while depressing the accelerator pedal the vehicle failed to respond. The contact pulled over to the right side of the road and turned the vehicle off and on and the vehicle began to work as intended. A dealer was contacted. The vehicle was towed to the dealer where it was diagnosed that the transmission needed to be replaced. The contact then had the vehicle towed to another dealer where they informed her there were no recalls. The contact mention this failure has occurred on several different occasions. The vehicle was repaired as the transmission was replaced twice. The manufacturer was notified on the failure, and they informed her to request a prior authorization from the dealer ship which was denied. The approximate failure mileage was 200,000.
After starting vehicle and shifting to Drive, the vehicle does not want to shift out of 1st gear and only accelerating to 25 to 30 mph. So far the only quick fix is to stop and turn the vehicle off and then restarting.
"The 8-speed Dual Clutch Transmission and engine (Cylinder 4) failed on my 2022 Hyundai Santa Cruz SEL Premium AWD with 37,780 miles. Both components are available for inspection upon request. While merging onto the highway in Sport Mode, the vehicle experienced violent shuddering and noise so severe I believed I had multiple flat tires simultaneously — specifically both front and rear passenger side tires. I immediately activated hazard lights and exited the highway. I was unable to safely operate the vehicle. Other drivers on the highway were also put at risk by my sudden need to exit. The dealer has NOT been able to reproduce or confirm the transmission issue despite multiple documented visits over the past year. However, AutoZone confirmed diagnostic code P0304 Cylinder 4 Misfire Detected on March 19, 2026 via OBD-II scan. The vehicle has been inspected multiple times by the Hyundai dealership over the past year. Hyundai Motor America has an open case on this vehicle and has escalated it to their buyback department. The Check Engine Light illuminated during the highway incident then self-cleared. Transmission slipping, shuddering at low speeds, high RPMs at low vehicle speeds, and failure to shift properly have been reported to the dealer for over one year. This vehicle contains the identical DCT transmission covered under Hyundai Recall 236 but my VIN was excluded despite identical symptoms. Backup camera has also failed twice — a federally mandated safety device."
The vehicle was involved in a collision in which the airbags failed to deploy. Despite the severity of the impact, no airbags deployed. As a result, both adult occupants (my daughters) were injured. The failure of the airbag system to deploy raises serious safety concerns regarding the vehicle’s restraint system and crash sensors.
My 2022 Hyundai Santa Cruz has an ongoing powertrain/transmission malfunction that occurs during cold starts. The vehicle will not upshift out of 1st gear and becomes stuck around 25 mph with the accelerator fully pressed. There are no warning lights or messages. The only way to temporarily fix the issue is to pull over, turn the vehicle off, and restart it. This creates a serious safety risk because I am unable to accelerate to normal traffic speeds when merging or crossing intersections. The vehicle and components are available for inspection upon request. The issue has been brought to two Hyundai dealerships multiple times. One dealership replaced the entire transmission, and on a later visit they topped off the transmission fluid. Despite these repairs, the problem continues to occur. Hyundai corporate is involved and has an active case open, but the defect remains unresolved. The problem has not been consistently replicated by the dealers because it only occurs on cold starts, but it happens repeatedly in daily use.
ALL SAFETY FEATURE WARNING ALERTS (3) OF THEM, SINCE IT WILL NOT ALLOW ME TO CHECK ALL THAT APPLY THEY ARE THE FOLLOWING ADAPTIVE CRUISE CONTROL NOT WORKING, BLIND SPOT WARNING NOT WORKING, FORWARD COLLISON DETECTION NOT WORKING, LANE DEPARTURE WARNING NOT WORKING, LANE KEEPING ASSISTANCE NOT WORKING, PARKING COLLISION WARNING NOT WORKING REAR CROSS TRAFFIC WARNING NOT WORKING.
The contact owns a 2022 Hyundai Cruz. The contact stated that while driving 70 MPH, the vehicle lost motive power but was unable to accelerate above 30 MPH. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 22V760000 (Power Train); the VIN was included, but the vehicle was already repaired in 2022. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 63,000.
2nd replacement DCT transmission failed Loss of power while driving on the interstate , upon acceleration no increase in speed, went from 65mph to 38mph before able to pull off the highway. Intermittently it is not shifting, shuttering, hard reverse shift, hesitation from park into drive
when pulling out on a intersection I was hit by a large box truck on the front and side drivers side at aprox. 20 to 25 mph. my air bags did not go off and my seat belt did not hold me from hitting the steering wheel Hyundai is saying the impact was not enough to force either one to help in this situation
Vehicle began running roughly. CEL came on. Began to misfire. Limped it off the FWY under limited power. Had vehicle towed to dealership. Was diagnosed as having bad fuel injectors. Was told by service writer that Hyundai Santa Cruz trucks have been experiencing a lot of injector failures. Looking at the various Hyundai Santa Cruz forums, it appears that this has been a very common issue and has occurred in 2022 through 2025 model year vehicles
The contact owns a 2022 Hyundai Santa Cruz. The contact stated that while driving 62 MPH, the Forward Collision Avoidance: Automatic Emergency Braking system erroneously engaged. The Forward Collision Avoidance: Automatic Emergency Braking warning light illuminated. A dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but offered no assistance and informed the contact that the vehicle needed to be diagnosed. The failure mileage was 30,000.
The contact owns a 2022 Hyundai Santa Cruz. The contact stated that while driving at approximately 60 MPH, the accelerator pedal was depressed to pass another vehicle however, the vehicle started to lose motive power. The contact stated that the check engine warning light was illuminated. The contact stopped the vehicle but did not turn off the vehicle. The contact stated that after shifting to drive(D) the vehicle failed to accelerate above 15 MPH. The contact stopped the vehicle and had the vehicle towed to the local dealer. The dealer diagnosed the vehicle and determined that a fuel injector had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 62,000.
My 2022 Santa Cruz Limited Edition keeps losing power intermittently. No accident yet but very risky to drive.
My tailgate is opening unexpectedly while driving. Hyundai has assured people that the tailgate locks while the vehicle is on and moving but that doesn't seem to be the case. I always check to make sure the tailgate is latched after accessing it, since this has happened several times now. I have now lost 2 separate items out of the bed while driving with the tailgate unexpectedly down. This issue could pose a safety risk to other drivers.
I purchased my 2022 Hyundai Santa Cruz new from Hallmark Hyundai in Tennessee. Ever since the purchase of my Hyundai Santa Cruz I have had issues with fuel injectors. I have had two fuel injector failures that had to be covered under warranty, the last fuel injector that failed under warranty was on cylinder 3 and was replaced a year ago at Coastal Hyundai in Melbourne, Florida. Three weeks ago, the fuel injector failed again on cylinder 3 and isn’t covered under warranty. This makes the third fuel injector (two on the same cylinder) to have failed in the three years of owning my vehicle. With less than 80,000 miles on it. Hyundai knows it’s a problem as they recently changed their service bulletin mandating all four fuel injectors to be replaced with an upgraded part. However they won’t cover the charges and I’m on the hook for the bill. Also, the new upgrade kit is on back order. I’ve been given three dates know for when it was supposed to be in stock, but they moved the date out again to May 25 and they’re not confident that it will be here then. There needs to be a recall ordered for the fuel injector replacement as Hyundai knows it’s a problem. There are over 3,000 customers waiting across the country for this new upgraded part.
I was driving on the freeway at 65mph and experienced a sudden loss of power. I depressed the gas pedal but the car would not accelerate past 45 mph. I had to drive all the way home with my hazard lights on. There were no lights on the dashboard to signify a problem. This happened several times. I took it into the Hyundai Service center and they could not replicate the problem. It happened again. and again. and again. finally got an error "possible condition with your engine control module". Took it into the dealer and after they drove it around for hundreds of miles they said they were able to recreate the problem, pulls some codes and relaced the fuel injection pump. It happened again. and again. and again. I took it back to the Hyundai Service center. They could not re-create the issue. They told me to use Chevron gas only and added an additive to the car. It worked for a while. Then it happened again. And again. I took it to a different Hyundai Service Center. They were not able to re-create the problem. Apparently, every time I drive the car, after 5-10 minutes on the street roads, the car fails to accelerate and I have to pull over, stop the car, and then re-start it. Re-starting it seems to clear the issue. I am driving in SMART mode and my car is at 39000 miles. Every time I take it to the service center, they can not re-create the issue. This is outrageous. Do I need to get into a car accident in order to bring legal action to Hyundai for not fixing this loss of power/failure to accelerate issue? Worst part is, the first Hyundai service center went out of business and I can not get any of the maintenance records for the fuel pump replacement.
The contact owns a 2022 Hyundai Santa Cruz. The contact stated while driving approximately 30 MPH, the vehicle intermittently lost automotive power. No warning lights were illuminated. The failure had occurred on several occasions. The vehicle was taken to a dealer and the dealer informed the contact that the cause of the failure was not yet determined. The vehicle was not repaired. The vehicle was taken to a different dealer to be diagnosed. The contact was informed that there was a recall related to the failure, for which a software update was needed. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.
On multiple occasions the car had trouble starting and while on the road it would idle like it was struggling. My concern was the car dying on me while on the road and causing an accident for myself and the other drivers or pedestrians. The manufacturer hasn't inspected it nor has it been confirmed by the dealer. I haven't had any warning and they first started to appear in the beginning of 2024. I just recently read the fuel injectors are the cause of this and so far there has not been any recall by the manufacturer
On the interstate mid-route, the engine light went on and the car started acting sluggish and slightly shaking on the interstate and would not respond to pressing the gas to accelerate and started to slow down. When I pulled over to the berm it was vibrating as if it was going to stall out. I turned the car off and returned to the interstate with no issues for the rest of my ride (the engine light remained on). On the next trip to the dealership for an appointment to have it checked, I was merging onto the interstate, and again, the car was not responding to me putting on the gas and would not accelerate. Could not push the car over 35MPG, and had to ride to the dealership with the car varying in speed anywhere from almost a complete stop to 30MPH on the berm where I could with flashers, often it felt as if it would stall out. It was a very dangerous & unsafe ride. FYI - The dealership replaced all 4 fuel injectors to fix
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .