2013 Hyundai Santa Fe Sport Problems

I was driving down a highway and was slowing down as motorcycle in front of me was turning. I than proceeded to drive, I heard a loud noise which everyone in the vehicle thought it was the motorcycle (it wasn't) we pulled over into the nearest gas station and saw that my oil light was barely blinking (it was barely noticeable) was fading in and out) we got out checked the dipstick and it was low. Was not due for an oil change for another 1500miles. We put oil in and waited checked the dip stick it was then reading between the two lines of L and F. We waited another 5-10 minutes before leaving. We pulled out and the vehicle acted as if it had no power. I pushed on the gas to get up to speed and the car died out; I got pulled over to the side of the road. The car gave me no indication of anything. No oil light. I drove the days before with no issues I was 38miles from home.

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that after a routine oil change, while driving back to the residence, the vehicle stalled. The vehicle was towed to the dealer to be diagnosed. The contact was informed that there were metal shavings inside the engine. The vehicle was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was made aware of the failure and stated that the vehicle was not eligible for a recall repair because the engine software update was not performed. The failure mileage was approximately 136,434.

In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17th 2023 to replace the failed ABS module. Hyundai Corporate has twice denied reimbursement, arguing that Recall 251 only covers a multi-fuse replacement and claiming internal fluid leaks are not covered. This contradicts NHTSA 23V-651 documentation, which explicitly identifies internal ABS module fluid leaks and electrical shorts as the core safety defect. Installing a fuse current-limiter cannot repair an already-ruined ABS circuit board or resolve a safety-mandated Limp Mode. I am reporting this to document on the official public record that Hyundai is actively denying reimbursement for the exact root-cause failure identified in NHTSA Campaign 23V-651. PLEASE NOTE: This report is submitted solely to document Hyundai Motor America's non-compliance and improper reimbursement denial for official record-keeping under Campaign 23V-651. I do not require follow-up contact from NHTSA regarding this submission.

After having the ABS recall fixed a while back all of the lights came back on about a week ago. There has been a loss of oil meaning i have been adding oil in between oil changes at least once a week, there has been smoke coming from under the hood and if you run the heat or air you have to have circulate cabin air button pushed or it pulls the smell inside the car and it is overwhelming. The smoking has been going on for about at least a month now.

In October/November of 2023, while Hyundai was actively initiating Safety Recall 251 (NHTSA Campaign 23V-651), my vehicle's ABS Control Unit suffered an internal fluid leak that resulted in an electrical short-circuit. The failure caused major electronic communication errors, illuminated dashboard warning lights, and placed the vehicle into Limp Mode, rendering it unsafe to drive. Because the failure occurred prior to receiving a formal owner notification in the mail and the vehicle was un-drivable, I paid $1,300.54 out-of-pocket on November 17th 2023 to replace the failed ABS module. Hyundai Corporate has twice denied reimbursement, arguing that Recall 251 only covers a multi-fuse replacement and claiming internal fluid leaks are not covered. This contradicts NHTSA 23V-651 documentation, which explicitly identifies internal ABS module fluid leaks and electrical shorts as the core safety defect. Installing a fuse current-limiter cannot repair an already-ruined ABS circuit board or resolve a safety-mandated Limp Mode. I am reporting this to document on the official public record that Hyundai is actively denying reimbursement for the exact root-cause failure identified in NHTSA Campaign 23V-651. PLEASE NOTE: This report is submitted solely to document Hyundai Motor America's non-compliance and improper reimbursement denial for official record-keeping under Campaign 23V-651. I do not require follow-up contact from NHTSA regarding this submission.

I was driving on March 20, 2026 at about 12:00 PM when I suddenly noticed smoke, a strong gasoline smell, an oil smell, and a burning odor coming from the vehicle. I pulled over immediately because I believed the vehicle was unsafe and at risk of fire. The vehicle had to be towed. An independent repair shop later found a fuel leak at the high-pressure fuel line / fuel pump area, a loose ground wire on the right-hand side of the engine, a valve cover gasket leak, and engine timing chain noise. I was informed that gasoline had sprayed throughout the engine bay. This created an immediate fire hazard even though no actual fire occurred. This problem was especially concerning because the vehicle had been inspected and serviced by an authorized Hyundai dealer in December 2025, less than about 3,000 miles earlier. The loose engine ground wire and fuel leak raise serious concerns about vehicle safety and the adequacy of the prior inspection. I contacted Hyundai the same day and reported this as a fire-risk safety issue, but I did not receive timely assistance. Because immediate dealer service was not available, I had to authorize emergency repairs at a local shop for safety reasons. No warning lights were noted before the incident. The failure was confirmed by the repair shop.

2013 HYUNDAI SANTA FE SPORT TURBO. PAST/PRESENT SAFETY-SENSITIVE DEFECTS, NOTED OVER THE PAST SEVERAL YEARS: 1. One Confirmed Open Recall [CAMPAIGN #/NHTSA RECALL #—Recall 251 / 23V651000] (To Be Scheduled ASAP). 2. RPM/Propulsion Limp-mode Conditions: Vehicle periodically loses RPM READINGS on Dash and goes into the Propulsion sputtering/restricted-speed limp-mode hesitation condition. This condition may occasionally normalize by stopping, turning off engine and restarting. This intermittent RPM/Propulsion condition sometimes occurs, signified by a temporary sputtering/bucking while driving vehicle. ❓️CHECK STORED CODES ASAP...To Do. 3. Several times the car failed to accelerate predictably. For example, as when trying to accelerate up to highway speed from the on-ramp, leading to a fear of a near-miss, stalling and getting rear-ended. On such occasions, since attention is directed outside of the vehicle for safety, the state of the RPM READING on the dash has not been noted. ❓️CHECK STORED CODES ASAP...To Do.

THIS CAR WAS INCLUDED IN THE RECALL OF OVER 1.5 MILLION HYUJDAI AND KIA VEHICLES DUE TO A FACTORY DEFECT THAT CAN LEAD TO PREMATURE ENGINE FAILURE. THIS CAR BROKE DOWN ON APRIL 28TH, 2019. I AM HAVING IT TOWED TO THE HYUNDAI DEALERSHIP FOR DIAGNOSIS. THE "WHAT TO LOOK FOR" SECTION ON HYUNDAI'S WEBSITES LISTS A NUMBER OF SYMPTOMS OF THIS RECALL ISSUE AND WHAT I EXPERIENCED WHEN MY CAR LEFT ME STRANDED ALONG THE HIGHWAY IS EXACTLY WHAT IS DESCRIBED ON THE HYUNDAI WEBSITE. THE ENGINE ALSO SHUTDOWN GOING 65MPH ON THE HIGHWAY.I WANTED TO BRING THIS TO YOUR ATTENTION SINCE THE NHTSA WAS INSTRUMENTAL IN ORDERING THIS RECALL. THANK YOU VERY MUCH.

I was driving on March 20, 2026 at about 12:00 PM when I suddenly noticed smoke, a strong gasoline smell, an oil smell, and a burning odor coming from the vehicle. I pulled over immediately because I believed the vehicle was unsafe and at risk of fire. The vehicle had to be towed. An independent repair shop later found a fuel leak at the high-pressure fuel line / fuel pump area, a loose ground wire on the right-hand side of the engine, a valve cover gasket leak, and engine timing chain noise. I was informed that gasoline had sprayed throughout the engine bay. This created an immediate fire hazard even though no actual fire occurred. This problem was especially concerning because the vehicle had been inspected and serviced by an authorized Hyundai dealer in December 2025, less than about 3,000 miles earlier. The loose engine ground wire and fuel leak raise serious concerns about vehicle safety and the adequacy of the prior inspection. I contacted Hyundai the same day and reported this as a fire-risk safety issue, but I did not receive timely assistance. Because immediate dealer service was not available, I had to authorize emergency repairs at a local shop for safety reasons. No warning lights were noted before the incident. The failure was confirmed by the repair shop.

Circuit board inside the fuse box stopped working and there was no speed indicator, no cruise control, no odometer registering while driving. Also the mechanical fuel pump started leaking fuel at 148,000 miles and now at 156,000 miles it is burning through oil and no oil light came on and the engine went into limp mode and is also now going through coolant too.

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that the front driver’s side door failed to unlatch as intended using either the interior or exterior door handles or the locking mechanism. In addition, the contact exited the vehicle using the front passenger’s side door to exit the vehicle. An appointment was scheduled with the local dealer. Upon further investigation, the contact associated the failure with TSB: 14-01-004-1. The contact stated that it might be a potential safety risk for passengers in an emergency. The manufacturer was made aware of the failure by telephone. The failure mileage was approximately 142,622.

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated while driving at an undisclosed speed, the accelerator was depressed; however, the vehicle failed to accelerate as intended. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with engine failure and waste gauge. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the original engine was previously replaced under an unknown recall repair in 2021, however the failure reoccurred. The contact stated that the mileage of the new engine was approximately 20,000. In addition, the contact stated that while driving at an undisclosed speed, the doors were independently unlatched. The contact stated that the driver's side rear door independently unlatched and independently opened. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 111,000.

Circuit board inside the fuse box stopped working and there was no speed indicator, no cruise control, no odometer registering while driving. Also the mechanical fuel pump started leaking fuel at 148,000 miles and now at 156,000 miles it is burning through oil and no oil light came on and the engine went into limp mode and is also now going through coolant too.

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated while driving at an undisclosed speed, the accelerator was depressed; however, the vehicle failed to accelerate as intended. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with engine failure and waste gauge. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the original engine was previously replaced under an unknown recall repair in 2021, however the failure reoccurred. The contact stated that the mileage of the new engine was approximately 20,000. In addition, the contact stated that while driving at an undisclosed speed, the doors were independently unlatched. The contact stated that the driver's side rear door independently unlatched and independently opened. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 111,000.

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that the subframe was rusted. The vehicle was taken to the dealer, who determined that the rear control arms and subframe were rusted and needed to be replaced. The contact was informed that the vehicle had previously been repaired under Service Campaign Number: 996 (Underbody Corrosion Preventive Service); however, the contact stated that the protective spray was only applied to the unibody and not the rear underbody. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 103,483.

Day 1 – Feb 11 at 4pm incident occurred my daughter was driving the vehicle on [XXX] , she was in the far right hand lane preparing to take an upcoming exit. Suddenly and unexpectedly the hood opened obstructing her view of the roadway and smashed the front windshield. Because she was in the right hand lane she was able to pull the vehicle to to the shoulder of the road immediately. No other vehicles were involved because of both her location (right hand lane) and ability to access the shoulder immediately. She could have been killed! The problem has not been confirmed Hyundai has informed me it will take 5/6 weeks to determine if an inspection is warranted. -Thursday February 19 We got the vehicle to the closest Hyundai dealer Metro West in Framingham Massachusetts on Thursday February 19 - I explained to the service representative the history (recall and repair in 2017) and a request to investigate recurrence of the recall defect as well as to prepare an estimate for repair. I never received a phone back so I called them on Wednesday February 27 and was informed that the vehicle estimate and inspection was in progress. At that point I contacted Hyundai corporate offices and was given a case number. On March 3, I called again and completed the preliminary investigation report - i was informed they would get back to me in approximately 48 hours. - On 3/9/26 after a phone conversation I was emailed a request to inspect my vehicle authorization form and another form (11 questions that had been answer numerous time by phone already) both were completed and submitted the following day 3/10/26. Dealership now threatening storage fees - Because the vehicle experienced failure of a component that was previously repaired under a federal safety recall, I am formally requesting that Hyundai preserve all evidence relating to the hood latch assembly and related components for purposes of regulatory review and potential insurance subrogation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U

While my vehicle was at an authorized Hyundai dealership for engine warranty repair, I reported a suspension grinding noise and requested that it be inspected. This concern was raised while the vehicle was in the dealership’s possession and was communicated as a safety concern. The engine repair was completed and the vehicle was returned to me. No inspection findings, documentation, or technician notes were provided addressing the suspension concern. The repair documentation I later received does not include any reference to the suspension issue or any inspection findings related to that concern. The dealership has also confirmed that no additional documentation exists beyond the repair order. After the vehicle was returned, warning lights appeared that were not present prior to the repair. A suspension grinding noise may indicate issues affecting steering, suspension, or vehicle stability. I am concerned that the vehicle was released without inspection or documentation of a reported safety related condition.

WHEN DRIVING AT SPEEDS ABOVE 45 MPH THE CAR IS UNSTABLE. IT CONSISTENTLY SWERVES TO THE LEFT AND TO THE RIGHT FORCING THE DRIVER TO CONSTANTLY ADJUST THE STEERING. IT DOES NOT MATTER WHAT MODE THE STEERING IS IN. IT DOES IT IN ALL THREE MODES. IT FEELS UNSAFE AND UNSETTLING.

MY 2013 HYUNDAI SANTA FE SPORT HAS A PANORAMIC SUNROOF THAT EXPLODED ON OCTOBER 9TH 2018 WHILE I WAS DRIVING (PICTURES ATTACHED). I HAD JUST LEFT WORK LESS THAN ONE MINUTE DOWN THE ROAD WHEN I HEARD CRACKLING NOISE FOLLOWED BY A LOUD EXPLOSION AND THEN SOUNDS OF A LOT OF CHATTERING HITTING THE SHADE, FOLLOWED BY WIND AND OUTSIDE NOISE (LIKE I OPENED A WINDOW). WHEN IT WAS SAFE TO PULL OVER TO CHECK WHAT HAD HAPPENED. I FOUND THE FRONT GLASS OF THE SUNROOF EXPLODED UP AND OUT! I HAD THE SHADE CLOSED SO THE GLASS DIDN'T GET IN THE VEHICLE. I IMMEDIATELY TOOK PICTURES AND CALLED THE DEALERSHIP I BOUGHT THE VEHICLE THAT WAS ABLE TO TAKE THE VEHICLE IN LATER THAT SAME DAY AND WOULD HAVE TO LEAVE IT OVERNIGHT. I RECEIVED A CALL FROM THEIR SERVICE DEPT. THE NEXT DAY TELLING ME THAT HYUNDAI WOULD NOT COVER THE SUNROOF! I HAD NEVER HEARD OF THIS HAPPENING TO A PANORAMIC ROOF BEFORE. SO, I DID SOME RESEARCH ONLINE TO FIND THIS HAS HAPPENED NUMEROUS TIMES AND HYUNDAI KNOWS OF THE ISSUE. IF THIS IS A KNOWN ISSUE, I DO NOT UNDERSTAND WHY HYUNDAI WOULD NOT COVER THE REPAIR? WHY THERE IS NOT A RECALL OR WARNING THAT THIS CAN HAPPEN?

WHILE IN REVERSE BACKING CAMERA SCREEN BLACKS OUT FOR SEVERAL SECONDS WHILE CAR IS BACKINGA. (EVERYTIME)

While my vehicle was at an authorized Hyundai dealership for engine warranty repair, I reported a suspension grinding noise and requested that it be inspected. This concern was raised while the vehicle was in the dealership’s possession and was communicated as a safety concern. The engine repair was completed and the vehicle was returned to me. No inspection findings, documentation, or technician notes were provided addressing the suspension concern. The repair documentation I later received does not include any reference to the suspension issue or any inspection findings related to that concern. The dealership has also confirmed that no additional documentation exists beyond the repair order. After the vehicle was returned, warning lights appeared that were not present prior to the repair. A suspension grinding noise may indicate issues affecting steering, suspension, or vehicle stability. I am concerned that the vehicle was released without inspection or documentation of a reported safety related condition.

THE REAR AND FRONT SUSPENSION MAKE A NOISE EVEN WHEN THE CAR WAS STATIONARY. EVEN WHEN THE DOORS ARE CLOSING, THE NOISE CAME OUT FROM THE SUSPENSION. IT'S BEEN THIS WAY FROM THE BEGINNING OF DRIVING MY CAR.

I have great concern that certain vehicles of Hyundai are getting a little bit of extended warranty occupant classification system forward slash occupant detection system known issues. OCS/ODS I will try to attach a picture of the letter. As a nurse manager I find this once again appalling on Hyundai behalf, after these years pass we won't know if our air big warning lights or trouble codes or even a a passenger is detected when driving. They offered to pay if you had issues with this problem or in my case in the next four and a half years they would cover it but after that do I feel that this is my problem because they're having defect sensors and warning lights or maybe lack thereof altogether after speaking to them when I called and made a case number XXX with Hyundai Motor America. I strongly believe this should be a recall. I would never trust anybody sitting in my passenger seat, and I don't think you would either. They always try and find some way to get around doing the right thing and obviously they have problems with intermittent airbags warning lights trouble codes and this needs to be looked into if there are any risk/issues detecting or possibly never detecting a grandchild sitting in that front seat! After 5 years I will worry if anybody sits in the front seat now. I have started the process and will wait for your reply, of communicating with [XXX] our Minnesota State Attorney General's office on this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2013 Hyundai Santa Fe Sport. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

TL* THE CONTACT OWNS A 2013 HYUNDAI SANTA FE SPORT. THE CONTACT STATED THAT THE VEHICLE MADE AN ABNORMAL KNOCKING NOISE. THE DEALER (JOE MACHENS HYUNDAI, 1300 VANDUVER DR, COLUMBIA, MO 65202) STATED THAT THE TIRES NEEDED TO BE REPLACED. THE CONTACT REPLACED THE TIRES, BUT THE FAILURE RECURRED LESS THAN A YEAR LATER. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 115,000.

RESET BRAKE LIGHT ASSEMBLY SHORTS OUT EVERY YEAR. THIS HAS BEEN AN ON GOING ISSUE SINCE I HAVE OWNED THE CAR AND THE DEALER ALWAYS SEEMS TO BE RELUCTANT TO REPAIR IT. THIS NEEDS A RECALL URGENTLET!