2023 Hyundai Santa Fe Driver assistance Problems

COMPONENT/SYSTEM: The powertrain launch control system — the Transmission Control Unit (TCU) and 8-speed wet dual-clutch transmission paired with the 2.5T engine — fails to deliver engine power in response to full accelerator input from a stop. The engine does not rev and the vehicle does not move for approximately 1–2 seconds despite the accelerator pedal being fully depressed, then power engages abruptly and violently. The vehicle is available for inspection upon request. SAFETY RISK: The failure occurs when launching from a stop into intersections and cross-traffic. In the most recent incident, I was turning left across the roadway from a stop with an oncoming vehicle approaching. I applied full accelerator and the vehicle did not respond at all for approximately 2 seconds — no engine response, no movement — leaving me stationary in the oncoming vehicle’s path. Power then engaged violently and without warning, causing the vehicle to lurch across the road. I was nearly struck. Similar events have occurred multiple times throughout my ownership; this was the closest to a collision. DEALER CONFIRMATION: Not yet inspected by a dealer. A dealer service appointment is being scheduled. OTHER INSPECTIONS: The vehicle has not been inspected by the manufacturer, police, or insurance representatives. WARNING LAMPS/PRIOR SYMPTOMS: No warning lamps or messages have appeared before, during, or after any of the events. The failure is intermittent and occurs without warning. The condition has been present since I purchased the vehicle in October 2022 and has occurred regularly throughout ownership — numerous occurrences over more than three years. No warning lamps have ever accompanied it. ADDITIONAL: Condition persists with Idle Stop & Go disabled, ruling out engine-restart delay. Same 8-speed wet DCT was subject to Recall 236 (NHTSA 22V-746) on 2021–2022 models for similar throttle non-response; 2023 excluded despite identical hardware.

NHTSA ID

11749868

Incident

Jul 11, 2026

First Failure occurred 7 months after purchase at 5,270 miles on August 1, 2024. The vehicle suddenly went into "Limp Mode" abruptly decelerating to 25 mph with a non-responsive gas pedal. A code reader displayed PO653 Sensor Reference: "Voltage B Circuit High". Dealer found corroded wire to battery and cleaned it. Second Failure: Horn loss to 1 tone. Fixed at 30K mile dealer service on June 12, 2026 and found to have faulty packing resulting in corrosion. At the same standard service the Brake System was flushed. 3rd Failure was 5 days and 437 miles (30,712 miles) after the 30K dealer service. On June 17, 2026 during my early morning commute while merging onto the interstate, alarms began to blare and the gas pedal suddenly became unresponsive. The initial alarms read Blind Spot Failure. Car would not accelerate from 40 mph that it was going coming down the bridge ramp so I took the very close off ramp down from the aqua duct and the console display alert showed "Engine Management System: details: Braking and Body Control System with a recommendation to get "a full system check...TODAY". I brought it to the dealer that afternoon and as of yesterday, 6/26/26 they can find nothing wrong, declaring it an intermittent issue and asked me to come get the car, refusing to continue looking or providing alternate options other than referring me to Hyundai Consumer Affairs.

NHTSA ID

11746876

Incident

Jun 17, 2026

We were at full stop with Auto Hold feature enabled. Car lurched / jumped forward with no depression of the gas pedal. This caused us to strike the car in front of us.

NHTSA ID

11743508

Incident

May 16, 2026

I was driving down the road and came to a stop at a stop light. After accelerating again my car lost the ability to increase speed above 20 miles/hour and would not shift gears. I was heading to the turn lane to get on the interstate and quickly had to change lanes to find an area to pull over as I could not reach highway speeds. I turned the car off. I turned the car back on and the problem resolved. This is the second time this has happened. I have seen this problem mentioned dozens of time on Reddit message boards including Hyundai buybacks on some of these vehicles. It doesn't sound like Hyundai has any idea what is causing this issue. This issue should be looked into further.

NHTSA ID

11741734

Incident

May 19, 2026

My vehicle activates the emergency braking system while driving. It has happened several times now, almost causing a collision. I took it to the dealership, they held it for a week and gave it back to me telling me they could not find anything wrong with it. They did not fix anything at all. It has since done it once more.

NHTSA ID

11740276

Incident

Mar 2, 2026

While driving on the interstate, while using cruise control, my vehicle braked and decelerated, uncontrollably. The collision alert alarm went off. I forced the vehicle to accelerate and it stopped the braking and the collision alarm ceased. I took the car to the dealer and they spend the day checking it over. They said they couldn’t get the same reaction I reported, but reset the cruise control. On my way back home on, again on the interstate, and with the cruise control activated, it again had the same failures. I called the dealer and told them. They asked if I had recently mounted any new equipment on the windshield. I said I had Velcro attached and EZPASS toll reader. They asked me to remove it, because might be interfering with the cruise sensor. After I removed it, and while continuing on the interstate, with cruise activated, it again repeated the same failures. The dealer arranged to have my vehicle towed to their shop.

NHTSA ID

11737167

Incident

May 11, 2026

It is not just this vehicle; it is ALL vehicles with adaptive cruise control and automatic emergency braking. When sensors get snow or debris on them, they shut the vehicles down without warning. I have had 3 times this winter when the roads were fine, cruise control set, and because another vehicle was kicking up road salt, the vehicle instantly shut off the cruise control without any warning to the driver, all 3 times I had traffic behind me at 55mph or on the highway at 70mph. The emergency braking is another issue, as it will bring the vehicle to almost a stop, and does not take into account if there are other vehicles behind it or not! How more people have not been killed because of these 2 systems is beyond me! BOTH of these systems and the vehicle they are on NEED to be recalled and either sensors removed or workarounds implemented, that at least give the driver some advanced notice before the cruise control is turned off or before a vehicle decides to hard-brake itself!

NHTSA ID

11734056

Incident

Feb 12, 2026

On March 4, 2026, at approximately 7:30 AM EST, while driving my 2023 Hyundai Santa Fe Limited on [XXX] , the vehicle experienced a sudden loss of propulsion while traveling at approximately 70 mph (posted speed limit). The vehicle would not accelerate or maintain speed and would not move forward when placed in drive, indicating a failure within the powertrain/transmission system. The vehicle is currently located at a Hyundai dealership and is available for inspection upon request. This incident created a significant safety risk, as I was traveling at highway speed in active traffic when the vehicle unexpectedly lost the ability to move under its own power. This placed me at risk of being rear-ended and made it difficult to safely maneuver out of traffic. The vehicle was inspected by a Hyundai dealership. Diagnostic trouble code P284001 (Shift Fork “D” Position) was identified, and I was informed the failure is transmission-related. The condition was reproduced by placing the vehicle in drive, at which point the vehicle would not move. The vehicle has been inspected by the dealership. The manufacturer has been notified but has not physically inspected the vehicle. No police or insurance inspection was involved. There were no warning lights, messages, or prior symptoms before the failure. The issue occurred suddenly without any indication of a problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11728065

Incident

Mar 4, 2026

On a clear road a sencor comes on detect comes on says detection collision. The breaks come on when you are traveling on interstate or two lane roads. When you are traveling 75 mph and breaks come on all of a sudden on the highway. We are lucky we never got hit in the back of the car going that fast. We will stop 75 to 35 mph in 10 seconds.

NHTSA ID

11703865

Incident

Dec 8, 2025

Component/System: Automatic Emergency Braking / Forward Collision-Avoidance (AEB/FCA) system and/or Electronic Parking Brake (EPB). The vehicle is available for inspection upon request. What happened: While driving my 2023 Hyundai Santa Fe (VIN: XXX) at highway speeds, the vehicle suddenly and aggressively applied the emergency braking system on two separate occasions within the same day (approximately 45–60 minutes apart). In both instances, the red emergency braking warning lights illuminated on the dashboard, and a warning sound activated. There were no vehicles, obstacles, or hazards in front of me either time. The braking was forceful and abrupt, causing rapid deceleration at highway speed. Both events occurred under normal, clear driving conditions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Safety risk: My safety and the safety of other drivers were put at significant risk. Sudden unintended braking at highway speeds can easily lead to a rear-end collision since the deceleration was not caused by driver input and gave no warning. Reproduction / dealer confirmation: The dealer has not been able to reproduce the issue, and no diagnostic trouble codes have been found so far. The vehicle is currently at the dealership for inspection. Inspection: The vehicle has been inspected by the Hyundai dealership, but the cause has not been identified. No manufacturer field engineer, police, or insurance inspection has taken place yet. Warning lamps / prior symptoms: During the failures, the red emergency braking indicator and audible warning activated immediately when the brakes engaged. There were no warning lights or symptoms prior to either event. Assessment: Cause UNKNOWN. The problem appears to be an intermittent malfunction of the Automatic Emergency Braking system, forward collision sensors, or related braking components. No diagnostic codes were stored. This is a serious safety issue that occurred twice within one hour and could easily result in a collision.

NHTSA ID

11699416

Incident

Nov 9, 2025

The vehicle's software was updated on Oct 21, 2025. The software has serious flaw. When driving on slight incline on the passing lane the vehicle will apply the brakes without warning. This has happened 3 times. At times, when vehicles were following me they also had to apply the brakes unexpectedly. Had they not applied their brakes, they would have rear ended me at highway speeds. I also recall that there were no vehicles either in front or to the right ahead of me when it occurred. Also there was a guardrail on the left side of the highway at the time. This did not occur with the previous installed software. Every time this happened, the vehicle was in cruise control and driver assist was ON to keep vehicle in the lane.

NHTSA ID

11696870

Incident

Oct 30, 2025

I was travelling at 50mph a car pulled in front of me and stopped unexpetedly. I braked hard. My car began to slow, but the brake pedal went to the floor and did not slow, AFter a few seconds, the brake pedal came up from the floor and braking was resumed. I held the pedal to the floor the whole time trying to stop. It was as though the braking system failed and recovered. There was no pulsing felt on the brake pedal typical of ABS working. After my car resumed braking thte collision avoidance system took over and the car stopped just inches from the stopped car in front of me. I had just taken the car in for dealer service at 24,200 and everything was supposedly checked out as required by maintenance. I have contacted Hyundai but have not gotten a response yet.

NHTSA ID

11684386

Incident

Aug 29, 2025

On two occasions, once at 70mph and once at 45mph vehicle suddenly lost power and displayed warning to check collision system, there were no vehicles close enough to warrant this. I had to limp the car to the side of the road as safely as possible and shut car off, wait a few minutes and restart vehicle to clear error and allow proper power/ acceleration again.

NHTSA ID

11679085

Incident

Aug 7, 2025

At 22000 miles wheel speed sensor went out, all control system shut down and car became unstable. At 44000 miles fuel injector went out, was driving on freeway and car started shaking and losing power, then in parking lot would not start at all, had to be towed to dealer. This is way to many breakdowns for a car with such low mileage.

NHTSA ID

11678488

Incident

Jun 7, 2025

On May 15th, I was involved in a serious accident caused by a malfunction in a rental vehicle provided by Enterprise a 2023 Hyundai Santa Fe. After reversing into a parking spot, I placed the vehicle in “Park” and exited the car to retrieve belongings from the trunk. My young son remained in the back seat. To my shock, the vehicle suddenly began to move on its own despite being in “Park.” I immediately ran to the driver’s side and jumped back into the vehicle in an attempt to stop it. I pressed the brake pedal multiple times, but the car would not respond. I also pressed the “Park” button repeatedly, yet the vehicle continued to move uncontrollably. The steering wheel was unresponsive, and I was unable to redirect the vehicle or bring it to a stop. The car ultimately crashed into two other vehicles. During the collision, one of the vehicles pinned my left leg in its door, causing physical injury. I am now dealing with both physical and emotional trauma as a result. To be clear, this incident occurred on a flat surface. No airbag deployed upon impact, and there were no warning signs or alerts from the vehicle beforehand which is highly concerning, especially for a modern electric/hybrid vehicle. This car presents a major safety hazard and, in my opinion, should be recalled and removed from service immediately before it causes a fatality. I have contacted Enterprise multiple times to report this issue and urge them not to rent this vehicle to anyone else.

NHTSA ID

11663585

Incident

May 15, 2025

Early March 2025 the vehicle was put car in park, got out of car to close yard gate, turned around to walk back to car but car was rolling forward and hit the flat bed trailer causing approximately $5000 in damage. It was put in park before getting out but jumped gear before getting back in. Another common problem is slamming the emergency brake on when attempting to drive. Was at a red lite left turn stop sign with foot on the brake. When the light turned green took foot off brake & put foot on accelerator to go forward, the car slammed the emergency brake on. This has happened approx 6 times in the 1-1/2 years of ownership.

NHTSA ID

11661942

Incident

Mar 1, 2025

My car won’t shift on the highway and all of a sudden I can’t drive more than 40mph. It also has not wanted to let me press on the gas and make it go as I’m driving bc Its jerking 4 or 5 times before it’ll register and go. Also, not too long ago, I was in a parking lot and went to leave and my car never notified me that there was a huge pillar next to me and I crashed into it, it was in my blind spot and couldn’t see it. My car has had many many other issues in which I can’t list, but I truly bought a lemon.

NHTSA ID

11654802

Incident

Apr 15, 2025

I had adaptive cruise control on and debris hit my windshield and I went into the rumble strip and eventually into the guard rail where the car essentially pingponged from there until it eventually stopped when the metal hit the front. It appears the emergency brake did not activate and the lane keep did not activate. My air bags did not deploy.

NHTSA ID

11649463

Incident

Mar 10, 2025

The accelerator stuck and the vehicle crashed. The vehicle is totaled. It happened [XXX]. No one has yet inspected the vehicle. I notified Hyundai about 5 days ago. The phone number of the towing company is 516 433 1011. The following link is a YouTube video of the accident: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11644603

Incident

Feb 2, 2025

In January, 2024, my vehicle (2023 Hyundai Santa Fe) started shuddering when brakes were applied at high speed, on quick or hard stops, in stop and go traffic, and especially going downhill. I had only been driving the vehicle for about 5 months. I took the vehicle to an independent mechanic, who explained that my front rotors had burn spots. He recommended that I have them resurfaced. I did not want to pay for the problem to be fixed when I believed it was a factory defect and should be covered by warranty. I asked the Mission Hills Hyundai dealership Service Department to investigate and correct the problem, because I felt that my family's safety was jeopardized by faulty brakes. They showed me the burn spots on the front rotors and recommended resurfacing. They said I could wait for the pads to wear down and do the resurfacing at the same time as the pad replacement. Their estimate for resurfacing was higher than the one from my mechanic. I found a Hyundai Technical Service Bulletin, Number 23-BR-004H, which described the exact defects of my vehicle. I returned to the dealership with the TSB in February, 2024. They replaced the two defective front rotors and front disc pads at no charge. The shuddering was no longer evident, and I thought the problem was resolved. However, 10 months later in December, 2024, I once again experienced the shuddering while braking on the freeway while going downhill and when slowing for stops from high speed. Since I had been told that the new rotors and pads were covered by warranty for 5 years or 60,000 miles, I returned to the dealership on 1/16/25 and asked them to evaluate the brakes again. They said that the front rotors again had burn spots. They once again recommended resurfacing at a cost of $249. I reminded them that there was a warranty on the new parts, they claimed that the only warranty was for the original parts that had been replaced. They agreed to resurface no charge. Please investigate and respond to my complaint.

NHTSA ID

11636536

Incident

Dec 21, 2024

Automobile approached and stopped at stop sign. When accelerator pressed to continue, car remained in place, shuddering (as if transmission were slipping),and making significant noise. Car would not shift out of gear, nor move. Operator shut off car and then restarted car. Car started normally and was in park without shuddering. Expectations at busy intersection was that it was my turn to move and did not do so, creating doubt on what my car might do next. Traffic flow was briefly confused and some drivers honked and were unsure what they should do. This could have caused an accident with an impatient driver re-ending my car, or with others going through the intersection "out of turn" and unclear on my situation. No lights or other warnings were displayed before this incident. It has not re-ocurred. I brought into the dealer who had no other reports of this type of behavior.

NHTSA ID

11632758

Incident

Dec 17, 2024

While travelling at highway speed, attempted to accelerate to pass slow traffic. Rather than accelerating, the car hunted for a gear, and wouldn't shift properly. The car downshifted but engine would not go beyond 4000 RPM and speed remained the same. This has happened multiple times. By unexpectedly not accelerating, this created a risky situation by not allowing car to pass slower traffic as expected creating a potentially dangerous situation. (Video of one of the instances exists). No warning lamps, messages or symptoms occurred up to that point. Car was brought to dealer but since no codes were contained in the computer, they said there was no trouble found.

NHTSA ID

11632756

Incident

Aug 20, 2024

Emergency brakes engage while driving for no apparent reason. This has happened on several occasions over the last 6 months.

NHTSA ID

11628701

Incident

Nov 28, 2024

Currently have 518 Diagnostic History Codes (DTC)in memory. Additionally, I have 3 Active DTC’s. The codes are: DTC C160C87 DTC System CHASSIS DTC Sub System LKAS, and DTC C160C87 DTC System CHASSIS DTC Sub System SCC, and DTC C163881 DTC system CHASSIS DTC Sub System SCC FIRST OCCURRENCE: during actual assembly in Montgomery, AL plant. I have asked three Hyundai Service dealers for help. All have tried. Noting noted that contributes to the issues above. At first, my dealer replaced the front camera. Was told it was a heating issue. I have contacted Hyundai BLUELINK service for help. An information report was filed, TWICE. The first report I received feedback that Hyundai’s engineers had corrected the issue. On the following day, the codes returned. A second concern was filed with Hyundai BLUELINK. Hyundai Motor America Case#: [XXX] to wit: “Thank you for contacting Hyundai Motor America. We are in receipt of your e-mail and one of our representatives will get back to you shortly. Sincerely, Hyundai Motor America” Is my vehicle going to fail and cause me injury while operating it on an Interstate highway? This is quite concerning as I drive my car. All I want from Hyundai is to get this issue repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11621650

Incident

Sep 1, 2024

The forward collision warning system engages and slows the car, often very abruptly, when on the highway and only when cruise control is on. It happens after we have been on the highway for a few hours, thus the dealer cannot reproduce the incident. It happens a few times on every road trip and is very disturbing when there are no other vehicles or obstacles in the road or nearby. We have reported this to the dealer several times and they can find nothing wrong. I provided a photo to the dealer of the dashboard showing the cruise control on, the forward collision system DISENGAGED, and the forward collision warning activated. Dealer states they have recalibrated the system but can replace no parts unless a part is found to be faulty. The latest suggestion yesterday from the dealer was to "get out" of the car before the issue gets worse.

NHTSA ID

11615547

Incident

Aug 17, 2024