Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 154 NHTSA owner-reported complaints for the 2012 Hyundai Sonata Hybrid. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 154 · page 1 of 7
While driving and everything is going along fine it will suddenly jerk and make a sound as if I've been hit behind. I'm not sure if it's part of the detached shift cables or transmission or something else. Sometimes it will jerk violently while going uphill also.
2012 Hyundai Sonata Hybrid well maintained by original owner, under 130,000 miles. May of 2025 AC stopped working intermittently (Hyundai dealer replaced AC hose). Aug 2025 AC stopped working AGAIN (same dealer could NOT identify problem). Car has consistent Hybrid System Warning! Safely Stop and Do not Drive messages lights and sirens when braking. Code PA186 comes up (low state of charge code for hybrid battery). December 2025 brought car back to SAME Hyundai dealer who NOW says car suddenly needs a 10k transmission (BUT still no idea what PA186 code is related to). Got transmission drained at different shop and NO NEW TRANSMISSION NEEDED! Every repair shop OUTSIDE OF HYUNDAI who has scanned for codes gets the PA186 error and say it is related to HYBRID BATTERY LOW STATE OF CHARGE (I am the original owner THUS lifetime hybrid battery warranty). June 2026 different Hyundai dealer for repair of AC and PA186 code. NEW Hyundai dealer says AC issue is NOT related to the PA186 code. They still dont know what PA186 code is but want to charge me $5100 for engine wiring harness electrical short. SIDE NOTE!! Engine wiring harness electrical short is known issue for ABS module recall 251 for this car. Hyundai has denied the engine wiring harness electrical short repair as part of ABS recall 251 warranty and STILL cant tell me why Hybrid System Warning Lights and PA186 code is come on. Is electrical issue really harness or HYBRID battery?? Car is currently at Hyundai dealer.
The contact owned a 2012 Hyundai Sonata. The contact stated that while driving at 75 MPH on the highway, while depressing the accelerator pedal, the vehicle failed to accelerate. No warning lights illuminated. The contact veered over to the right side of the road, turned the vehicle off, and she noticed smoke coming from the engine. A bystander behind her noticed the flames coming up from the engine. The contact mentioned she exited the vehicle and called 911. No injuries were sustained. No medical attention was required. A police report was filed. The fire department extinguished the fire. The vehicle was destroyed. The vehicle was towed to Atow lot. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 160,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. Additionally, the ABS warning light was illuminated. The contact stated that the vehicle had to be turned off and restarted every ten minutes. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the vehicle was recently serviced by the dealer and NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) was completed. The contact stated that the failure was present prior to the recall repair being performed. In addition, the contact stated that the failure reoccurred a week after the recall repair was completed. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while attempting to close the passenger’s side rear door, the door failed to lock as needed. The contact tied the door closed. The contact stated that the driver's side rear door was locked, and the contact was unable to open the door. The contact had taken the vehicle to a dealer when the passenger’s side door was not locking. The dealer diagnosed the vehicle and determined that the latch and locking mechanism needed to be replaced. The vehicle was not repaired. The contact stated that when the driver's side rear door failed to lock securely, the vehicle was not returned to the dealer. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 41,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and the low battery warning light illuminated. In addition, the contact heard a rattling sound coming from the engine before the engine seized. The vehicle was towed to the dealer where it was diagnosed with a failed hybrid system and that the hybrid system needed to be replaced. The contact was also informed that the transmission was not the original transmission, and the cooler was damaged. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the brake warning light illuminated. The contact pulled over on the side of the road and the vehicle was towed to the dealer to be diagnosed. The contact was informed that the ABS and hydraulic pump needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) that was previously performed. The manufacturer was made aware of the failure and informed the contact the failure was not related to the recall repair. The failure mileage was approximately 151,020.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed and depressing the brake pedal, the vehicle lunged forward. The vehicle was taken to an independent mechanic and diagnosed with automatic transmission failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 76,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at an undisclosed speed, the brakes became inoperable. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The approximate failure mileage was 155,290. Parts distribution disconnect.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) and would like to be removed from the recall distribution list because she no longer owns the vehicle. The local dealer was contacted. The manufacturer was not contacted.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, he became aware that the electronic power steering was not functioning properly, noticing an excessive amount of understeer. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the steering column. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 80,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called another local dealer, Red McCombs Hyundai Northwest, (13663 I-10, San Antonio, TX 78249) who informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The contact stated that when the vehicle was started, the check brake and hybrid system message was displayed. Additionally, the contact stated that while driving at various speeds on several occasions, the ABS activated inadvertently. The vehicle was taken to a dealer where it was determined that unknown parts needed to be replaced; however, the parts were unavailable. The manufacturer was not notified of the failure. The failure mileage was approximately 126,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the Check Brakes and Hybrid System Warning: Safely Stop and Do Not Drive messages were displayed. The brakes then made a grinding sound while the brake pedal was depressed. Additionally, the vehicle lost motive power while driving. The contact pulled over and restarted the vehicle. The vehicle was taken to the dealer, where it was diagnosed with a faulty HCU (Hybrid Control Unit) and AHB (Active Hydraulic Boost). The dealer retrieved DTC Codes: P1886 (Inappropriate and Low SOC) and C1237: (Primary Pressure Sensor Signal). The dealer replaced the oil valve gasket and recalibrated the brakes. The manufacturer was made aware of the failure. The failure mileage was approximately 113,340. VIN tool confirms parts not available.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at various speeds, the message "Pull Over. Stop the Vehicle" was displayed, and the vehicle failed to respond upon depressing the accelerator pedal. The contact veered to the side of the road and turned off the vehicle. The contact stated that the vehicle became drivable after waiting 30 minutes to an hour. The contact stated that the failure had been recurring while driving. Additionally, the contact stated that while reversing and depressing the accelerator pedal, the vehicle jerked, made an abnormally loud sound, and failed to respond. The contact shifted into park(P) and shifted back into reverse(R), and the vehicle jerked and responded. The contact stated that while driving at various speeds and depressing the accelerator pedal, the vehicle jerked and hesitated to respond. There was no warning light illuminated. The contact stated that she had taken the vehicle to an independent mechanic, where a diagnostic test was performed. The contact was referred to the dealer for assistance. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed and attempting to accelerate up a hill, the vehicle inadvertently lost motive power. Several attempts to restart and jumpstart the vehicle failed. The hybrid system warning light was illuminated on the instrument panel. The vehicle was towed to the residence and later towed to an independent mechanic, who determined that the engine had failed due to metal shavings in the engine oil. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V746000 (Engine) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 55,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at approximately 50 MPH, the brake pedal was depressed and the vehicle began to stall. The contact stated that the accelerator pedal was then depressed but the vehicle would not accelerate as needed. The contact stated that the check engine warning light and the hybrid engine warning message was displayed and advised the driver to “Safely Stop and Do Not Drive” the vehicle. The contact pulled over and turned off the vehicle. The vehicle was restarted and the contact parked the vehicle in a parking lot and turned off the vehicle and waited for a while. The contact then restarted the vehicle and the check engine warning light remained illuminated. The vehicle was taken to the local dealer where it was diagnosed that the engine control module (ECM) needed to be replaced. The vehicle was not repaired and remained at the dealer awaiting the parts for the repair. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 130,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at various speeds, the brake pedal was depressed; however, the vehicle failed to stop. The contact stated that he heard a grinding sound in the wheels. The contact stated that the Hybrid System and brake warning lights were illuminated. The vehicle was taken to an independent mechanic where the brake pads, rotors, and calipers were replaced; however, the failure recurred. The vehicle was taken to several independent mechanics however, the failure could not be duplicated. The dealer was notified of the failure and an appointment was scheduled for October. The manufacturer was not notified of the failure. The failure mileage was 204,900.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving approximately 20 MPH, there were abnormal sounds coming from the vehicle. There was no warning light illuminated. The vehicle was towed to the dealer and diagnosed with a catalytic converter and engine failure. Additionally, the vehicle was consuming an excessive amount of engine oil. The check engine warning light was illuminated. The dealer replaced the engine; however, the failure reoccurred. The manufacturer was notified of the failure. The approximate failure mileage was 68,000.
The contact owns a 2012 Hyundai Sonata. The contact stated while driving at 70 MPH, the oil pressure warning light illuminated and the vehicle started losing motive power. The accelerator pedal was depressed but the vehicle failed to respond and jolted. The contact veered to the side of the road. The contact turned off and restarted the vehicle. The contact continued to drive at a slower speed however, the failure reoccurred several times while driving to her residence. The vehicle was taken to the dealer who informed the contact that the failure was associated to Manufacturer Recall Number: 198. However, the dealer informed the contact that they could not repair the vehicle under the recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 168,000.
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that he had received notification of NHTSA Campaign Number: 15V568000 (Engine). The contact took the vehicle to a dealer where the recall was serviced. Soon after the recalled pair, the "Hybrid System Warning Light, Safely Stop and Do Not Drive," warning message appeared on the instrument panel. The contact had the vehicle towed to a dealer where it remained in their possession. The manufacturer was notified of the failure but offered no assistance. The contact was given an estimate for the repair but was declined. The vehicle had yet to be repaired. The failure mileage was 155,000.
The contact's wife owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving approximately 65 MPH, there was an abnormal banging sound coming from the engine compartment. The contact stated no warning light was illuminated. The vehicle lost motive power and decelerated to 30 MPH. The contact pulled over and had the vehicle towed to his residence. The Customer Service Department was contacted and the representative suggested that the vehicle be taken to an authorized dealer to be diagnosed. The contact was informed that the connecting rods failed and punctured the engine block and the engine needed to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The dealer had been informed of NHTSA Campaign Number: 20V746000 (Engine) however, the dealer stated that the vehicle was past warranty period. The failure mileage was approximately 150,000. Consumer stated when the incident happened a little above mileage warranty.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .