2011 Hyundai Sonata Exterior lighting Problems

On my 2011 Hyundai Sonata GLS, both rear tail lights have melted to the point that the lightbulbs cannot be extracted and the brake and tail lights no longer work. When I looked into this, I found out this is a common issue on 2011 Hyundai Sonatas. It is almost always caused by excessive heat from the standard incandescent bulbs, which damages the wiring harness and deforms the plastic housing. When I called the closest Hyundai dealer (in Chico, California), they told me the warranty had expired last year and that I should have received a notice about it after I obtained ownership of the car in March 2025 (a little over a year ago). However, I did not receive a notice about this. Since the tail lights do not work properly as a result of this problem, it is a safety issue as it could cause an accident. It should be a recall repair instead of a warranty that expires. My car is still well under the 200,000 mile limit that was set on the extended warranty, but they're refusing to honor that because of the warranty being expired.

NHTSA ID

11738903

Incident

May 9, 2026

I bought this car from someone in April of 2024 and the person who i bought it from said everything was perfectly fine, they brought it to the Hyundai dealership and according to the mechanic there the engine was fine….i have taken care of the engine since i bought the car, kept up with oil changes and everything….until a few days ago when the whole thing ceased up on me while driving down the road to my sons school. I wasnt going fast either, the speed limit is 40mph where i was when it happened, but I’m glad i have quick reflexes because otherwise we would have wrecked the car. Everything shut off on me and now its knocking. There is alot of metal shavings in my oil and my mechanic tried to drain it a few times to get the debris out of the oil but it does no good.

NHTSA ID

11694680

Incident

Oct 19, 2025

To Whom It May Concern, Subject: Formal Complaint – 2011 Hyundai Sonata GLS Tail Light Meltdown / Fire Hazard Date: August 3, 2025 I am writing to formally report a serious safety issue with my 2011 Hyundai Sonata GLS, specifically concerning the tail light assembly, which has melted and poses a potential fire hazard and traffic safety risk. Approximately a year and a half ago, I noticed melting in the tail light housing and took the vehicle to a Hyundai dealership to address the issue. At that time, the car had approximately 208,000 miles. Despite the obvious manufacturing defect and safety implications, the dealership refused to repair or inspect the issue without charging a $275 inspection fee, stating the vehicle was out of warranty. I believe this to be an unfair and irresponsible business practice. Tail light assemblies should not melt under normal use, and such a defect could lead to: Electrical fires Brake light failure (increasing the risk of rear-end collisions) Potential traffic citations for inoperative brake lights Damage to other vehicles or individuals I have already notified Hyundai Motor Corporation about this issue, placing them on notice that should any damages or incidents occur as a result of this defect, they may be held liable. This is not a minor cosmetic issue but a major safety defect, and I strongly urge the NHTSA to investigate whether this is an isolated issue or part of a wider trend affecting Hyundai and Kia vehicles. If so, a safety recall may be warranted. I also intend to report this situation to the Indiana Attorney General's Office as a matter of consumer protection and product safety. I have been backwards and forwards with the Hyundai Corporation Via and Emails...... I look forward to a prompt response. Please!

NHTSA ID

11678048

Incident

Dec 5, 2023

I was gifted the car for graduation and immediately my brakes weren’t working right my interior electrical stopped working and my window switches stopped working as well as my lights for my car all went out including the brake lights changing the bulbs didn’t help and my check engine light stays on at all times.

NHTSA ID

11566680

Incident

Jan 20, 2024

When I have my headlights turned on, and am driving my headlights flicker on and off. It mostly happens when I use the turn signal, but not always. sometimes it happens when I hit bumps. The headlights and the dash lights all go out when this happens, it usually lasts from 1 to 20 seconds at a time. I have taken it to my local garage(straight and clear) and they tested all electrical components and replaced the alternator and I still have the issue. They looked it up and determined that this is a known issue with the Hyundai Sonata, and one of the modules needs replaced in the steering column. This is a major safety issue because my headlights go out when driving and could cause and accident, and depending on the exact issue of the module it could cause a fire. There are no warning lights, just the lights go on and off. I will be getting the car repaired around November 9th 2023, because I need my car to be safe, and can submit my invoice at that time if this becomes a recall.

NHTSA ID

11552535

Incident

Aug 16, 2023

The brake lights stay on all the time, thus preventing vehicles behind mine from knowing if I'm actually stopping. Hence, they may stop without reason, and endanger drivers behind them. The manufacturer has likely known of this being an issue in Sonatas from, at least, 2007 through 2013 models. The manufacturer is putting the task of solving the problem (if that's even possible), upon a dealer. And, my trip to that (nearest) dealership (75 miles away) creates its own danger. The danger is added to by a pre-existing unsolved issue of the horn not functioning. As per the brake light issue, I've been to the dealership about it twice, and they weren't even aware that the brake light switch they think attaches to my car doesn't. So, I wonder if the manufacturer tried to address the issue in the middle of the 2011 model year, installed a different model switch and wiring on more newly built cars in that model year, and decided to ignore the owners of vehicles sold earlier in that model year. As for an additional related issue, unless I disconnect my battery when not in the car. the lights stay on and run down the battery. That can contribute to its own safety issue.

NHTSA ID

11541794

Incident

Aug 30, 2023

My right brake light has melted my housing due to the bulb getting too hot and my cruise control suddenly stopped working one day the light comes on but when I go to hit the set button it doesn't set or activate

NHTSA ID

11538816

Incident

Jul 5, 2023

My brake lights constantly go out new bulbs don't work either...it sems to be a malfunction in the wiring for the lights. The seatbelt on driver side will not latch no matter what. All electrical has issues, dash will go in and out as well as radio and heating/ac lights.

NHTSA ID

11536971

Incident

Jun 1, 2023

Brake light housing has melted and deformed so that the bulb is stuck in the tail light assembly and cannot be changed. Without working brake lights the car is unsafe to be driven on the road. I’m assuming there is an electrical problem that caused the lights to overheat and melt the housing. This is a common complaint with this make and model based on my research. The socket also does not lock into the assembly due to the deformed housing. My daughter is the owner of the vehicle and made me aware of the issue today.

NHTSA ID

11523088

Incident

May 21, 2023

I have had replaced my taillight bulbs 8 times in the last year. They keep blowing out and getting so hot they melt the taillight assembly. I replaced the whole assembly a couple months ago and it is already melted so bad the light bulb will not fit properly or stay in place. This is a fire hazard and also a safety hazard as my taillights quit working at anytime.

NHTSA ID

11520736

Incident

Apr 30, 2023

The contact owns a 2011 Hyundai Sonata. The contact stated that the headlights ceased to operate as designed. The vehicle was taken to an independent mechanic, where the headlight bulbs were replaced three times within a month; however, the failure persisted. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 150,000.

NHTSA ID

11520270

Incident

Apr 3, 2023

Mileage

150,000 mi

The NHTSA has filed a Consent Order (RQ17-004) for a Engine Replacement due to safety concerns while driving the vehicle on the road, Vehicle may stall and cause / be involved in a accident. Please make this recall public so the affected vehicles can be properly repaired as the Consent Order states I have reviewed the Consent Order and I will not continue to drive this vehicle, I will not risk being involved in a accident The Hyundai dealership in Alexandria Virginia has refused to repair this recall under the Consent Order, My vehicle Vin# is [XXX] My vehicle has been at this dealership location for over 3 weeks and I was told that they were not going to perform this recall and I noted that If I pick up my vehicle and drive it away and the engine fails, stalls or stops in the middle of the highway and I survive I will have to file a lawsuit in this matter and the dealership still told me to pick up my vehicle. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11511357

Incident

Mar 1, 2023

2020 wiring harness overheated and melted - replaced taillight 6 times in 1 year. Hyundai fixed. 2021 tailight out again - Hyundai stated the taillight assembly melted, needs to be replaced (403.00) light bulb cannot be replaced (warped). Safety issue is what is causing things to heat up and melt. Many others reported same issue online - Hyundai is not taking ownership to fix whatever is causing this? No warning lamps.

NHTSA ID

11498402

Incident

Oct 26, 2022

when driving randomly the cars engine will rev really high while pressing the gas pedal but the car doesn't move. After a little while the car eventually makes a loud clunking noise which shakes the car and typically causes the tires to spin. It seems to happen when the car is trying to decide whether to switch the gas engine or back to EV mode. This has been happening for a long time an even after the engine was replace under the recall. This is a safety issue that causes major concerns for myself an passengers. Also it happen when turning onto highways or exits which at high speeds there is a high likelihood of causing an accident. I have reported this to Hyundai several times but they cannot figure out the cause but rather keep trying different things an charging me. the car also seems to burn oil fast which doesn't make any sense being that its a newly installed engine.

NHTSA ID

11493938

Incident

May 18, 2022

I have had to replace my brake lights, sometimes, every few months. My third brake light only works intermittently. Recently, my brake lights and my door lights failed to shut off after I turned the engine off. Also, my abs light came on on the dash, but after turning the engine off and back on, that light went out. After re-starting my car and repeatedly, stepping on the brake, my lights finally shut off. I checked the internet for similar problems and found out that there had been a Hyundai recall for this issue. I phoned Hyundai customer support. They told me the recall had been repaired on my car by the dealer . Obviously, it had not. (The dealer also claimed to have corrected another recall regarding seat belts, but that too is a lie, since my seat belt dash light is on although I have never been involved in an accident) I believe that the dealer billed Hyundai, but failed to either deliberately or inadvertently failed to perform the recall work. The recall involved replacing the brake stopper pad which engages the brake light switch. Obviously, Hyundai considered this a safety issue since the brake lights are always on, so the driver behind my car never knows what I'm doing. This has also affected the interior overhead light which only intermittently goes off when I close the door, so I have to keep the light in the off position.

NHTSA ID

11493263

Incident

Nov 10, 2022

The vehicle dash and center console lights flicker and/or dim between bright and dim lights while the headlights temporarily turn off at random intervals while driving. This random, but frequent occurrence happens often when applying the turn signal in either direction. The problem generally exist between 1 to 5 seconds, causing impaired driving during nighttime operation. The turn signal appears to work as expected during the electrical issue. The vehicle is available for inspection upon request. This safety issue can impair nighttime driving visibility which can result in an accident, distracted driving to the primary vehicle driver and other motorists, and false driving signals to other drivers. This issue has been reproduced by an authorized Hyundai dealer and other drivers with similar Hyundai Sonata GLS model years. The following online forum is 1 example that provides driver examples and descriptions of the same issue with the same model and year as well as other vehicle model years: https://www.carproblemzoo.com/hyundai/sonata/headlights-turn-off-while-driving-problems.php The vehicle has been used as a daily driver under normal driving conditions and has been maintenanced and inspected by an authorized Hyundai dealership for recalls, service, and the mentioned electrical issue. There are no warning lamps prior, during, or after the electrical issue occurence.

NHTSA ID

11492038

Incident

Oct 24, 2022

All the electrical on the drivers side conti ues to fail. The blinker on the driver side only works if the headlights are on and the brake/blinker lights constantly go out even though the bulbs are fine.

NHTSA ID

11485962

Incident

Sep 1, 2020

break lights burn out in less than 3 months after replacing the light bulb

NHTSA ID

11485447

Incident

Jan 1, 2020

I can’t drive my car in the dark. This has been on going since I bought the car and has just gotten worse. Everytime I turn my lights on all of my rear lights stop working and if I’m driving and the back light stop working my gas peddle also will not let me accelerate until I let my foot off and go back on to it but at this point I have no tail lights or brake lights.. I’ve tried so many things to fix this but this is a serious issue I had another friend who bought the same car and sold it a week later because of the same issue. I also can open my trunk and wiggle the wires and it’s a whole light show back there.

NHTSA ID

11479965

Incident

Aug 18, 2022

My passenger rear brake light will not come on after car has been in repair shop 11 times to correct issue. They have replaced the bulb, socket, light wiring harness, fuse etc. The brake light will work for a very short time after repair shop, but then go out again.

NHTSA ID

11476240

Incident

Jan 1, 2020

The taillight socket is melting disabling the effective use of the brake system to alert other drivers the vehicle is stopping. The light works but can not be reinserted into the given space because it has melted close on the tailight cause my entire tail light to have to be replaced. The light bulb then melted into the trunk space and could have caused a fire but luckily we smelled it and moved the placement. I have almost been rear ending multiple times cause long the oncoming driver to swerve off the road to avoid hitting me because they were not able to see I was stopped. I have been stopped by law enforcement and given a warning thankfully. I have sent a complaint to hyundai and have seen multiple complaints and myself seen multiple sonatas on the road with no tail light/brake light issues. My dealer wants to charge over $600-1000 to repair this imperative issue. There was no indication they were malfunctioning until they had melted into the socket. On both lights. I have read multiple complaints on this same issue. This is an important part of the car that needs to be fixed for driver safety.

NHTSA ID

11473206

Incident

Jul 22, 2021

The contact owns a 2011 Hyundai Sonata. The contact stated that after turning off the vehicle, he and his wife exited the vehicle and both noticed that the brake lights had remained illuminated. The brake lights failed to turn off as designed. The dealer and the manufacturer were both contacted and stated that the VIN was not included in NHTSA Campaign Number: 15V759000 (Exterior Lighting). No additional assistance was provided. The failure mileage was 120,000.

NHTSA ID

11472972

Incident

Jul 5, 2022

Mileage

120,000 mi

I have replaced my front driver door actuator, the back driver and front passenger side 3x and it’s still having issues. I replaced all fuses an wiring harness. Front headlights keep blowing out after about a week of putting in new ones.

NHTSA ID

11470170

Incident

Jun 20, 2022

Brake lights have been needed to be replaced multiple times a year, since I purchased the car. Now this past year I have had to replace my break lights more often and noticed the port that holds the light appears to be burnt. So after I noticed the situation, I googled to see if there were any recalls and there have been, but my dealership advised me that my car had no recall for the break lights but had other recalls (which nothing was ever sent to me stating any recalls). Also be advised approximately every 5 hyundai sonata has a break light out. I am EXTREMELY upset that there has not been a recall for the break lights and also upset that the dealer charged $115.00 for two break light bulbs and “labor”) and why was I not aware of recalls on my vehicle until I went into the dealership with a problem.

NHTSA ID

11463765

Incident

Dec 1, 2011

my passenger headlight continuously goes out. I also have where my headlights completely go out as well as my interior lights. there is nothing out of the ordinary when it happens. Sometimes it will do it when I use a turn signal, other times just on it's own. I will have it happen very frequently and then not again for months. I also have the taillight burn out very often

NHTSA ID

11453555

Incident

May 5, 2021