2019 Hyundai Sonata Owner Complaints

Vehicle stalled in traffic due to recall defect. Manufacturer recall remedy is delayed beyond reasonable timeframe, creating ongoing safety exposure.

NHTSA ID

11755086

Incident

Jul 31, 2026

The contact owns a 2019 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, smoke started coming from the hood and the vehicle was pulled over into a parking space. While opening the hood, the contact saw that fire was coming from the top of the engine. The contact stated that the fire consumed the front of the vehicle, including the windshield and the dashboard. The smoke coming from the vehicle was dark gray and turned black afterwards. The contact called 911, and the Fire Department was able to extinguish the fire. There were no injuries reported. A vehicle parked next to the vehicle was damaged by the flames. The contact's vehicle was not inspected or officially deemed a total loss. The vehicle was towed to an independent mechanic where an oil change had been performed prior to the failure. The mechanic stated that there might have been a high-pressure fuel valve on top of the engine that possibly caused a gas leak, which started the fire. The vehicle was not diagnosed or repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was 172,000.

NHTSA ID

11752343

Incident

Jul 16, 2026

Mileage

172,000 mi

Driver's side seatbelt retraction mechanism failed without warning. Intentionally brought car to dealer ASAP since it was close to 100,000 miles pointed out. This was serious safety defect dealer refused to repair under warranty.

NHTSA ID

11750832

Incident

Jul 10, 2026

The air bag light suddenly illuminated when turning on my car. My car has around 60k miles. It was previously repaired a few times for a power steering faliure while driving making it hard to stear. I believe that this latest failure is due to a failure of the stearing wheel clock spring or another SRS module. failure.

NHTSA ID

11748085

Incident

Jul 2, 2026

2019 Hyundai Sonata Sport. (Original owner). Problem: Transmission. [XXX] (9,912 miles). Lack of power, vehicle did not move when trying to merge onto freeway. Very unsafe. Also, hesitation and jerking. [XXX] (10,619 miles). Lack of power, hesitation, jerking. Hyundai tech performed TSB, TCU updates, ECU update for knock sensor performance, reset engine & transmission updates. [XXX] (41,332 miles). Harsh shifts, hesitation, jerking, clunk sound, gear grabs, bursts of power, lack of power. Unsafe to drive. February 2, 2026 (41,751 miles). Hyundai tech found leak at case seal. Hyundai replaced transmission. [XXX] rough start, vibration in pedals. March 9, 2026 Hyundai tech found transmission fluid leak at case seal. Hyundai replaced transmission. March 25, 2026 Hyundai service advisor voicemail said, have to submit to Hyundai another transmission replacement because new transmission is not good. Issues shifting in reverse, hard slams, loses gears. [XXX] picked up vehicle from Hyundai service dept. Harsh shifting, hesitation, jerking, clunk sound, gear grabs, bursts of power. Clunk sound in steering wheel when turned back-and-forth. Front end vibration & wobbly. Vehicle unsafe. May 26, 2026. I notified Hyundai Motor America. Case #[XXX]. June 10, 2026 (43,000 miles). Hyundai service dept. informed me of right and left front axle replacement, universal steering joint replacement. Vehicle unsafe. [XXX] (43,000 miles). Test drove car with Hyundai tech. Verified front end vibration & shaking. Vehicle unsafe to drive. Hyundai service manager said that Hyundai should recall the transmissions. To date, my car is still at Hyundai service dept. Hyundai's service manager said that the Hyundai service dept. will have a meeting regarding my car and include Hyundai's service director, etc. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11745802

Incident

Apr 14, 2021

The engine is the component or system failed or malfunctioned, and it is available for inspection upon request. Sudden loss of engine power while driving, including during highway speeds or intersections, increasing the risk of a crash. Engine stalling or failure to accelerate, preventing me from safely maneuvering away from hazards. Overheating events, which resulted in complete engine seizure and an unexpected loss of vehicle control, all which can potentially causing catastrophic incident without warning. To include, the increased risk of collision, especially if the failure occurs during traffic, merging, passing, or emergency situations. It has been reported to CC Transmission Auto Repair and independent service center. It was previously inspected by Hyundai dealer. Check engine light present September 2025.

NHTSA ID

11745390

Incident

Sep 22, 2025

after the car is driven for a while in warm weather, the steering can feel sticky after doing a slight turn doing more than 30 MPH. It takes extra force to return the steering wheel to the straight/neutral position. It acts as though the steering wheel is stuck in this slight turn position. The problem is intermittent but does create a safety hazard with the risk of the car being unable to easily remain in its correct lane position. Symptom summary: Intermittent; Worse in warm weather; happens after small steering inputs; Feels like the wheel is “hung up”.

NHTSA ID

11742988

Incident

Jun 7, 2026

For the past several years, this vehicle has experienced a recurring and unresolved engine malfunction that creates a safety hazard. The problem manifests as follows: Symptoms when check engine light illuminates: • Idle RPM elevation to approximately 1500 RPM (normal idle: 800 RPM) • Sudden unintended forward acceleration when foot is removed from brake pedal • Significantly reduced acceleration performance during normal driving • Vehicle becomes difficult to control safely The malfunction occurs intermittently but follows a consistent pattern. This is not an isolated incident but a recurring defect that has persisted for years. Multiple diagnostic and repair attempts have been unsuccessful: • Coconut Creek Hyundai service center - unable to diagnose [DATE(S)] • Independent mechanics - unable to resolve [DATE(S)] • Issue remains unresolved despite multiple service visits Despite multiple attempts by qualified technicians, the root cause has not been identified and the defect has not been corrected. This malfunction creates a significant safety hazard: • Unintended acceleration increases risk of collision • Reduced acceleration capability limits ability to merge or accelerate safely • Check engine light indicates undiagnosed system failure • Problem is intermittent and unpredictable, making it unsafe to drive I am concerned this may represent a defect pattern affecting multiple 2019 Sonata vehicles. NHTSA should: 1. Investigate whether this represents a defect pattern in 2019 Hyundai Sonata vehicles 2. Determine if a safety recall is warranted 3. Contact Hyundai Motor America to address this systemic issue

NHTSA ID

11738831

Incident

Mar 8, 2023

Ecm, p0303, yes, not yet, no, cel light before the car was brought to the dealership, 2019 Hyundai Sonata SE, 2.4L Theta II GDI. Perryville Hyundai IL refused applicable TSB in writing 5/4/26 despite active P0303 misfire, fuel-in-oil smell, crankcase pressure. I have Photos prove falsified multi-point inspection: 1.0 inch (.0833') wheel well discrepancy, same mileage in/out. Vehicle has stall risk. Case Manager [XXX] non-responsive 2hr 45min after requesting written tow instructions on safety matter. RSPM escalated 1:00 PM CDT 5/5/26 with 3:00 PM deadline. No contact received as of 3:03 PM. Vehicle unsafe to drive. Theta II Lifetime Warranty Settlement violation. Case #XXX. Requesting federal investigation. Photo upload is not working, I'll need a email to send them in apparently INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11735872

Incident

Apr 29, 2026

Automatic Emergency Braking Blind Spot Warning/Blind Spot Detection Forward Collision Warning Antilock Brake System/ABS Lane Departure Warning Lane keeping Assistance I bought this vehicle last month from a dealer and two days later all the warning lights start popping up on the dashboard so I contacted the dealer and told them what was going on with the car they told me to bring it in so that the technician can check to see what’s wrong with it they told me that there’s nothing wrong with the vehicle so I went back home and the same day all the warning lights came back on so now I’m concerned about my daughter’s safety because she use the vehicle to drive to and from school and you never know when the brakes might fail, again I just bought this vehicle a month ago just one month not even a year and it’s having all this problem even though it’s a pre-owned vehicle I shouldn’t have to take it to the shop after one month please help… thank you

NHTSA ID

11734528

Incident

Mar 9, 2026

I wanted to report the failure of my rear camera and/or the electrical circuit that is tied to it. It's my understanding that Hyundai has issued multiple recalls across different years/vehicles for issues in this area. My 2019 Sonata is NOT included in those current recalls. I was without my vehicle for a week and was charged over $1600 to repair. The issue was diagnosed and repaired by an independent mechanic. When they system failed numerous error lights/warning went off and continued to cycle thru (plus beeping). I wanted to report this in hopes of continued pressure on Hyundai to add this model/year to their recalls.

NHTSA ID

11733342

Incident

Apr 17, 2026

On April 14, 2026, my 2019 Hyundai Sonata was parked at a retail store parking lot. Returning from the store, I attempted to start the car, and it did not start. I attempted to start it again, and I saw smoke coming out from under the hood. I immediately exited the vehicle and opened the hood. I saw open flames coming out of the engine area, about 4” high. I called 911 and waited about 10 minutes for the fire department to arrive. During this time, the flames engulfed the entire engine compartment and extended vertically above the hood height. The hood eventually melted and fell back onto the engine area. The fire department came and put out the fire. The car is totaled. There were no injuries, thank God!

NHTSA ID

11732956

Incident

Apr 14, 2026

My 2019 Hyundai Sonata has been experiencing excessive oil consumption since I purchased it. The vehicle requires oil to be added approximately every two weeks, which indicates a serious internal engine issue. Recently, the check engine light turned on, and I took the vehicle to a dealership for inspection. I was told that the engine is “operating normally,” despite the ongoing oil consumption problem. I was also informed that the engine would only be replaced under warranty if it fails completely, such as through connecting rod bearing damage. This means I am expected to continue driving a vehicle that may suddenly fail without warning. I drive daily with my children, and I am concerned about the risk of sudden engine failure, loss of power, or engine seizure while driving, which could lead to a serious accident. I believe this is a known issue with these engines, and it represents a significant safety hazard that should be addressed before a catastrophic failure occurs.

NHTSA ID

11730703

Incident

Apr 5, 2026

I was driving on the interstate when my engine started shutting down on me and I’m glad I had moved to the right lane because someone would’ve hit me from the back because I never had this problem and now the mechanic telling me it jumped timing.

NHTSA ID

11729912

Incident

Apr 1, 2026

My oil pan cracked. I’ve never had any issues with oil pans until this one. Hyundai will not replace this under warranty.

NHTSA ID

11729007

Incident

Dec 1, 2025

I respectfully submit the following additional information.In connection with this matter, the dealer in question asserted in writing that I "should have refused to participate" in the manufacturer-authorized "Z05 Service Campaign"—a measure designed to prevent potential damage—and characterized the program as nothing more than "free paint work." Service campaigns administered by manufacturers are conducted within the framework of federal safety regulations pursuant to Title 49, Chapter 301 of the U.S. Code; they are neither optional nor merely cosmetic in nature. Rather, they constitute systematic procedures intended to preserve vehicle integrity and support public safety. Statements suggesting that consumers should decline participation in such campaigns—or that they may bear financial responsibility for damage incurred during their execution—raise concerns regarding how these federally supervised programs are communicated and implemented and may discourage participation and undermine public confidence in the national vehicle safety campaign system. Although the dealership subsequently offered to replace the windshield at no cost, I have not received confirmation that the repair has been completed. This offer was made only after the vehicle remained at the facility for an extended period, during which I was repeatedly placed under pressure to assume financial responsibility for damage that occurred while the vehicle was under dealership custody. I was presented with two conditional options; however, in either scenario, I would ultimately be required to accept financial responsibility for the outcome. Ultimately, I was required to assume financial responsibility for issues arising during the work. On 2/23, I was told the loaner could be reported as "stolen," and I returned it immediately. After returning the vehicle, no alternative transportation was provided while my own vehicle remained unrepaired.

NHTSA ID

11727389

Incident

Jan 14, 2026

consuming oil a quart every 2-3 weeks sonata hyundai in 2000 miles 3 quarts of oil were used. what happens when the motor locks up from be extremely low on oil. Possible accident! I cannot expect my wife to be checking the oil level every time she drives.

NHTSA ID

11725416

Incident

Mar 18, 2026

Safety Concern — Damage to Windshield During Manufacturer Recall Repair (Z05) My vehicle was brought to an authorized Hyundai dealership on January 14, 2026 for a manufacturer-directed paint recall repair (Campaign Z05), which required removal and reinstallation of the windshield as part of the procedure. The repair was originally expected to be completed between January 14 and January 28, 2026. However, I received no explanation for the delay during that period. On February 13, 2026 — nearly one month after check-in — I was informed for the first time that the windshield had cracked during the reinstallation process while the vehicle was in the dealership’s custody. As of March 18, 2026, the windshield has not been replaced, and the vehicle remains at the dealership without this safety-critical component restored. Because the windshield is a structural element essential to roof strength, airbag deployment performance, and overall crash integrity, the prolonged failure to properly restore it raises serious safety concerns. The unresolved condition of this component creates uncertainty regarding the vehicle’s crashworthiness and may expose occupants to significant risk of injury in the event of a collision. Damage occurred during a manufacturer-mandated recall repair while the vehicle was under the exclusive control of an authorized service provider, and the vehicle has not been returned to a safe, operable condition for an extended period. This situation raises broader concerns regarding the handling of safety-critical components during recall procedures and the timely restoration of vehicles to safe operating condition. This matter is also currently under review by the Arkansas Motor Vehicle Commission (AMVC), Case #26-009, due to the prolonged inability to restore the vehicle to a safe condition. I am submitting this complaint in the interest of vehicle safety oversight and to help prevent similar situations from affecting other consumers.

NHTSA ID

11725388

Incident

Feb 13, 2026

Steering wheel panel glued/tampered (Safety Hazard) Motor/Pump assembly broken. Recall couldn't be done due to tampered parts.

NHTSA ID

11719616

Incident

Feb 21, 2026

Steering will stay stuck in left or right position when turned slightly, a couple of inches. The wheel has to be jerked back to center. Vehicle will not go back to center. No lane assist of any kind are on. Excessive tire wear. Consistent issue especially when it’s hot weather. Steering wheel tilts to left when brought to centerz Cannot be reset to stay centered. Dead spot in steering.

NHTSA ID

11716400

Incident

Feb 1, 2022

The contact's mother-in-law owns a 2019 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the vehicle started shuddering. There was no warning light illuminated. Minutes later, the failure reoccurred with the messages "Check Hybrid System” and “Turn Engine Off" being displayed. The contact immediately pulled over and had the vehicle towed to a dealer for assistance. A diagnostic test was performed, and it was determined that there was engine failure and that the engine needed to be replaced. The dealer requested proof of the last two oil changes. The contact obtained a Carfax Report, which showed proof of the oil changes and maintenance records. The manufacturer denied the goodwill request after several months of negotiations. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 32,000.

NHTSA ID

11714435

Incident

Sep 26, 2025

Mileage

32,000 mi

I have had my car in 7 times for the same issue. Metal shavings in oil and burning excessive amounts of oil between oil changes. This is a very well known issue with 2019 Hyundai Sonata. They have done nothing but add oil and run tests which the car failed. No attempt to fix it or replace it. I have been in contact with Corporate who refused to help. My car has an extended warranty for this specific issue, but they only give me the run around.

NHTSA ID

11709374

Incident

Jul 22, 2025

See attached document for complaint.

NHTSA ID

11708884

Incident

Jun 22, 2025

The engine is burning oil around 1 quart every 700 miles. I check the car oil level around every 10 days. I have experienced when I didn't check the oil and the low oil engine light would come on in the instrument panel. Hyundai shows no recall for this 2019 Hyundai Sonata Limited edition. I believe that this type of incident occurred back around 2011 with Hyundai's models for that time

NHTSA ID

11707477

Incident

Nov 19, 2025

My vehicle has an oil consumption problem. I put in 5 quarts of oil last week after changing the oil three weeks before this. I am down today December 19, 2025 2 1/2 quarts when I put in 5 quarts last Friday. Hyundai motor Corp. says I have to pay for the $90 oil change to do the oil consumption test then I have to go back 1000 miles later and pay $600 for an oil combustion cleaning and drive it another thousand miles and come back and see the oil level to see if I need an engine. I think this is absolutely a safety hazard and needs to be taken very seriously for all customers that drive a Hyundai that are having these issues.

NHTSA ID

11706209

Incident

Aug 9, 2025