2005 Hyundai Tucson Problems

This car accelerates while unattended. Most likely due to an ECM malfunction and unable to properly respond/send signals to the motor. On 4 occasions, the car has accelerated, even if in park. It will go 25mph on its own and to stop I had to put it in neutral. I’ve seen that my car isn’t the only one experiencing this. Considering it’s an ECM issue there should be a recall because that is not a part you change during the life of a car.

The contact owns a 2005 Hyundai Tucson. The contact stated that on several occasions while driving 65 MPH and attempting to accelerate, the RPM failed to raise, and the vehicle failed to respond. No warning lights were illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 105,000.

I acquired my vehicle as a used car. Although, to my knowledge my vehicle air bags have not deployed, the air bag light is illuminated on my dash panel and this issue is preventing me from obtaining an updated vehicle registration in my state of residence (Delaware). Since the year make and model are listed under the "recall" section of the NHTSA website, specifically for an airbag issue, I am requesting information regarding what nest-steps I nay take to have this problem repaired by Hyundai without any cost to me.

The contact owns a 2005 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the front passenger side air bag wiring harness; however, the part was discontinued. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 75,880.

This car accelerates while unattended. Most likely due to an ECM malfunction and unable to properly respond/send signals to the motor. On 4 occasions, the car has accelerated, even if in park. It will go 25mph on its own and to stop I had to put it in neutral. I’ve seen that my car isn’t the only one experiencing this. Considering it’s an ECM issue there should be a recall because that is not a part you change during the life of a car.

ESP off ligh comes on and off have to turn suv off to ture light off Had report it to nhtsa twice but no one replied 2/28/22 # 05V119000 2/14/22 #11454471

The contact owns a 2005 Hyundai Tucson. The contact stated while driving 45 MPH, the Electronic Stability Program (ESP) warning light was illuminated. The contact parked on the side of the road and restarted the vehicle. The contact stated that after restarting the vehicle, the warning light disappeared. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 109,000.

MY ESC LIGHT KEEPS COMING ON. I SEE THERE WAS A RECALL ON IT. CAN YOU TELL ME IF AND WHEN THAT RECALL WAS PERFORMED ON MY CAR?

REAR SUBFRAME IS ROTTED. MY 17 YEAR OLD WAS DRIVING ON THE HIGHWAY, SHE LOST CONTROL, IT COULD HAVE BEEN TRAGIC.THE CAR HAS BEEN TOWED AND SITTING IN A PARKING LOT FOR 2 MONTHS AS I CAN NOT FIND THIS PART! MY MECHANIC SAID IT WAS A RECALL WITH THESE CARS.

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME AND SUSPENSION WERE SEVERELY RUSTED AND CORRODED. THE OIL PAN, FUEL TANK, FUEL TANK CLAMPS, REAR CHASSIS CRADLE, AND FRONT END SUSPENSION (INCLUDING THE STRUTS, SWAY BARS, SWAY BAR CLAMP, SWAY BUSHINGS) WERE REPLACED BY AN INDEPENDENT MECHANIC. GARBER HYUNDAI (5450 BAY RD, SAGINAW, MI) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT INDICATED THAT THE VEHICLE STILL EXPERIENCED FRONT END VIBRATION WHILE DRIVING. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 155,000.

Brake light no coming on when brake pedal is being push

BRAKE LIGHT AND BATTERY LIGHT ARE STAYING ON

ESP off ligh comes on and off have to turn suv off to ture light off Had report it to nhtsa twice but no one replied 2/28/22 # 05V119000 2/14/22 #11454471

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT TOOK THE VEHICLE TO VISION HYUNDAI WEBSTER (755 RIDGE RD, WEBSTER, NY 14580, (585) 787-2111) FOR AN UNKNOWN NHTSA CAMPAIGN FOR CORROSION ON THE REAR SUBFRAME. THE DEALER TOOK PHOTOS TO SUBMIT TO THE MANUFACTURER FOR REPAIR APPROVAL. THE DEALER INFORMED THE CONTACT THAT THERE WAS AN 80% CHANCE THAT THE SUBFRAME COULD FRACTURE AND THE VEHICLE WOULD BE UNDRIVABLE. THE DEALER OFFERED NO GUARANTEES THAT ANOTHER VEHICLE WOULD BE PROVIDED FOR THE CONTACT IF THE SUBFRAME WAS FRACTURED BEYOND REPAIR AND WOULD CHARGE THE CONTACT FOR FURTHER REPAIRS. THE CONTACT CALLED THE MANUFACTURER AND WAS ASSIGNED A CASE NUMBER AND CASE MANAGER. THE MANUFACTURER HAD NOT CALLED BACK AND THE VEHICLE WAS CURRENTLY UNREPAIRED AT THE CONTACT'S HOME. THE CONTACT CONTINUED TO DRIVE THE VEHICLE AND THE DEALER REFUSED TO PROVIDE A LOANER VEHICLE. THE FAILURE MILEAGE WAS 161,000.

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME AND SUSPENSION WERE SEVERELY RUSTED AND CORRODED. THE OIL PAN, FUEL TANK, FUEL TANK CLAMPS, REAR CHASSIS CRADLE, AND FRONT END SUSPENSION (INCLUDING THE STRUTS, SWAY BARS, SWAY BAR CLAMP, SWAY BUSHINGS) WERE REPLACED BY AN INDEPENDENT MECHANIC. GARBER HYUNDAI (5450 BAY RD, SAGINAW, MI) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT INDICATED THAT THE VEHICLE STILL EXPERIENCED FRONT END VIBRATION WHILE DRIVING. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 155,000.

THE CAR STALLS THEN CUTS OFF WHILE IN MOTION.

DRIVER AIR BAG LIGHT STAY ON WILL NOT TURN OFF HEAD LIGHT SLIVER MELTED

HEAD LIGHT INSIDE BOTH SLIVER AREA ARE BURN ?? CAN'T FIND WHAT CAUSES IT NEED HELP PICTURE ATTACHE

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT WHILE OPENING THE HATCH DOOR, THE REAR GLASS WINDOW SEPARATED FROM THE FRAME. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF FAILURE. THE FAILURE MILEAGE WAS 118,000.

AS I WAS DRIVING DOWN THE HIGHWAY, I NOTICED THAT ONE OF THE WINDOWS IN MY 2005 HYUNDAI TUCSON SOUNDED LIKE IT HAD BEEN ROLLED DOWN. ALMOST IMMEDIATELY, MY DAUGHTER YELLED, "OUR WINDOW IS COMING OFF!" I HAD JUST ENOUGH TIME TO LOOK IN MY REARVIEW MIRROR TO SEE THE RIGHT REAR QUARTER PANEL WINDOW BEING HELD ON BY JUST A SMALL STRIP OF SOME SORT OF ADHESIVE. IN LESS THAN A SECOND, THE WINDOW FLEW OFF, BEGAN PINWHEELING THROUGH THE AIR AND NARROWLY MISSED THE VEHICLE JUST BEHIND ME. EVEN THE REPAIRMAN AT THE HYUNDAI DEALERSHIP THAT REPLACED THE WINDOW FOR ME WAS SPEECHLESS WHEN I TOLD HIM WHAT HAPPENED. I CONTACTED HYUNDAI, AND ALL THEY WOULD TELL ME IS THAT MY CAR IS OUT OF WARRANTY. WHILE IT WOULD HAVE BEEN NICE FOR THEM TO OFFER TO PAY FOR THE REPAIR, I WAS MUCH MORE CONCERNED WITH THEIR LACK OF CONCERN FOR ANYTHING OTHER THAN THE FACT THAT THE VEHICLE WAS OUT OF WARRANTY. THEY DID NOT ASK FOR ANY DETAILS OR OFFER ANY CONCERN FOR THE POSSIBLE DAMAGE AND/OR LOSS OF LIFE THAT COULD EASILY HAVE OCCURRED HAD THAT WINDOW HIT THE CAR BEHIND ME. *TR

ALL FOUR YOKOHAMA AVID TOURING S P215/65/16 TIRES HAVE EXTREME TREAD/MOLD SEPARATION AT 40,000 MILES MAKING THEM UNSAFE TO DRIVE ON. *TR

PROBLEMAS CON EL POWER TRAIN. HISTORY = EN EL PRIMER AO SE DAO CD PLAYER LO CAMBIARON PERO EMPECE A TENER DIFICULTADES CON EL HORN POR UN MAL ENTENDIDO CAMBIARON EL CLOCK, HASTA LA FECHA NUNCA ME ARREGLARON EL HORN EL CUAL DEJA Y EMPIEZA A FUNCIONAR EN CUALQUIER MOMENTO. EL VEHICULO EN VECES PRENDIA LA LUZ DEL "CHECK" PERO POR UNAS HORAS O UN DIA EL DEALER NUNCA ENCONTRO NADA EN VECES TAMBIEN SE DABA COMO JALONES COMO QUE SE QUERIA PARAR, SE LLEGO A PARA 3 VECES, LOS DEL DEALER NUNCA ENCONTRARON NADA SIEMPRE LA LLEVE AHI PARA MANTENIMIENTO Y CAMBIO DE ACEITE, ELLOS COBRAN DEMASIADO POR LOS SERVICIOS, YA CAMBIE HEADLIGHTS 2 VECES Y OTRAS LUCESITAS DEL FRENTE, SE CAMBIO SERPENTINE BELT,BATERIA , LLANTAS, PARABRISAS, FRENOS; EN LOS ULTIMOS 9 MESES CAMBIE A OTRO LUGAR PARA CAMBIO Y CHEQUEO DE FLUIDOS. EL 12/17/09 7AM, PRENDIO A LA 3RD VEZ QUE TRATE FUI Y VINE AL TRABAJO Y CASA SIN PROBLEMAS, POR LA TARDE SALI A LOS 15 MINUTOS SE EMPEZO A JALONEAR Y CADA VES QUE BAJABA LA VELOCIDAD SE QUERIA APAGAR EL MOTOR LO CUAL SUCEDIO AL HACER ALGUN STOP, PERO LA PRENDIA DE NUEVO SIN NINGUN PROBLEMA AL REGRESO A CASA VOLVIO A PARARSE VARIAS VECES, ADEMAS SE PRENDIO LA LUZ DE "CHECK" Y A LOS 5 MINUTOS SE PRENDIO OTRA QUE POR EL SEOR QUE LEVANTO EL VEHICULO SE QUE INDICABA PROBLEMAS EN EL "POWER TRAIN" Y MENCIONO TAMBIEN EL 4X4. TOTAL QUE AL PRENDER ESA LUZ YA NO QUISO LEVANTAR LA MARCHA NOMAS COMO A 1 MILLA POR HORA Y ESO JALONENDOSE MUCHO, BUENO POR UNA U OTRA RAZON YO HABLE HASTA EL 12/29/09 PARA QUE LA LEVANTARAN Y HASTA HOY SE ME COMUNICO QUE TENIA UN SENSOR DAADO ALGO ASI COMO "THROTLE POSITION CENSOR" POR LO CUAL ME QUIEREN COBRAR 455.00 + TAXES. YO NO TENIA IDEA DE ESTE SITIO, Y CREO QUE TENIA DERECHO DE QUE SE ME COMUNICARA EN EL DEALER ACERCA DE TODOS LOS RECALLS PARA ESTE TIPO DE VEHICULO, ESTOY INSATISFECHA CON EL VEHICULO Y POR LOS ALTOS COSTOS DE MANTENIMIENTO QUE HE TENIDO QUE PAGAR DE ALGO QUE YA SABIAN QUE EXISTIA. NECESITO AYUDA URGENE, PLEASE. *TR RECEIVED COMPLAINT WRITTEN IN ENGLISH.

The contact owns a 2005 Hyundai Tucson. The contact stated that on several occasions while driving 65 MPH and attempting to accelerate, the RPM failed to raise, and the vehicle failed to respond. No warning lights were illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 105,000.

INITIAL ISSUES ON VEHICLE PRESENTED IN JANUARY 2021 WITH VARIOUS CHECK ENGINE LIGHT CODES INCLUDING P0133. ALTHOUGH VEHICLE PASSED EMISSIONS IN 2020, VARIOUS CHECK ENGINE CODES FOR MASS AIR FLOW SENSOR, OXYGEN SENSORS, MISFIRE FOR VARIOUS CYLINDERS. AFTER REPLACING INDICATED MASS AIR FLOW SENSOR, OXYGEN SENSORS INDICATED VIA OBD II TOOL, BATTERY, ALTERNATOR (MORE THAN ONCE), BOTH FRONT CV BOOTS, HEAD GASKET SEALS FOR BOTH CYLINDER BANKS, MORE CHECK ENGINE LIGHT ISSUES APPEAR ACCORDING TO THE VEHICLE. CURRENTLY ANOTHER CYLINDER MISFIRE CHECK ENGINE CODE HAS APPEARED AFTER ALL SPARK PLUGS HAVE BEEN REPLACED WITH OEM RECOMMENDED BRAND REPLACEMENTS (NKG PRE-GAPPED SPARK PLUGS). THE MISFIRE CODE HAS CLEARED AT THIS TIME. THE CURRENT CHECK ENGINE CODE FROM THE OBD II TOOL IS ERROR CODE FOR DRIVE TRAIN DRIVEABILITY P0420 REGARDING CATALYST SYSTEM OPERATING BELOW THRESHOLD AT BANK 1. I HAVE UTILIZED LOCAL STORE CATALYTIC CLEANER LIQUIDS TO CLEAN THE SYSTEM, WHICH HAS NOT RESOLVED THIS ISSUE. ADDITIONALLY, BEGINNING IN JANUARY 2021, THE VEHICLE WAS TAKEN TO THE CLOSEST LOCAL DEALSHIP FOR A LARGE MAJORITY OF THESE REPAIRS INCLUDING A $150 DEALERSHIP FEE JUST TO HAVE THESE CODES REVIEWED AND ADDITIONAL FEES FOR THE LABOR TO ADDRESS FOR EACH ISSUE FOR EACH REPAIR.

MY AXLE NUTS ARE SERIOUSLY CORRODED, TO THE POINT THEY NO LONGER LOOK LIKE NUTS. I'M VERY CONCERNED THE AXLES MAY SEPARATE FROM THE WHEELS.

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED THAT WHILE MAKING A TURN AT 20 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS ABLE TO RESTART AFTER WAITING. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,000.

TL* THE CONTACT OWNS A 2005 HYUNDAI TUCSON. THE CONTACT STATED WHILE DRIVING 45 MPH, THE ENGINE COMPLETELY SHUT DOWN WHEN THE ACCELERATOR WAS NO LONGER DEPRESSED. THE VEHICLE WAS TAKEN TO A DEALER, AND THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 57,000 AND THE CURRENT MILEAGE WAS 57,500.

MY WIFE'S HYUNDAI TUCSON (EITHER 2005 OR 2006) ALMOST CAUSED AN ACCIDENT TODAY WHEN THE ACCELERATION BECAME ERRATIC AND THEN STALLED WHILE AT AN INTERSECTION. SHE IMMEDIATELY BROUGHT IT INTO OUR HYUNDAI SERVICE CENTER. I SPOKE WITH A SERVICE MANAGER TO TELL HIM ABOUT A TPS (THROTTLE POSITION SENSOR) PROBLEM THAT I HAVE FOUND OUT ABOUT SPECIFIC TO THE 05-06 HYUNDAI TUCSON. I ALSO CALLED HYUNDAI BECAUSE THIS PROBLEM WILL NOT SHOW UP AS A 'FAULT CODE'. I HAVE INCLUDED HERE ONE OF MANY NOTES FOUND ON THE INTERNET CONCERNING THIS SAME PROBLEM: AFTER HAVING OUR 2006 TUCSON IN THE DEALER'S SERVICE SHOP FOR OVER THREE DAYS, IT WAS DETERMINED THAT THE CAR NEEDED A NEW TPS(THROTTLE POSITION SENSOR). THIS WAS AFTER THEY CONTACTED HYUNDAI TECHLINE AND AFTER I SUGGESTED THAT THEY TEST THE TPS AS A POSSIBLE CAUSE (CAME TO THIS CONCLUSION AFTER REVIEWING MANY WEBSITES/AUTOFORUMS. SOME FACTS: YOU WILL NOTICE A STUTTERING OR JERKING FEELING ALMOST AS IF YOU HAD A MANUAL TRANSMISSION, WERE DOWNSHIFTING AND RELEASING THE CLUTCH QUICKLY WHEN THE ENGINE RPM WAS NOT MATCHED TO THE LOWER GEAR, OR AS IF YOU TAPPED ON THE BRAKE TWICE WHILE DECELERATING. THIS MOTION CAN BE EITHER VERY SLIGHT OR RATHER VIOLENT (ONCE CAUSED US TO BE ACTUALLY PUSHED AGAINST OUR SHOULDER SEAT BELT. 1. ALMOST ALWAYS OCCURS WHEN EITHER COASTING OR DECELERATING, NEVER WHEN ACCELERATING. 2. USUALLY HAPPENS BETWEEN 40 -45 MPH. 3. NO FAULT CODE EVER COMES UP SO DON'T EVEN HAVE THE TECH WASTE HIS TIME. THE SERVICE DEPARTMENT DROVE THE CAR FOR OVER THREE TOTAL HOURS TO TRY TO GET A FAULT CODE READING WITH NO RESULTS. 4. CAR WILL STALL WHEN COMING TO A STOP 50% OF THE TIME. 5. HAPPENS WHEN THE TRANSMISSION IS WARM. 6. FEELS LIKE TRANSMISSION IS TRYING TO FIGURE OUT WHAT GEAR IT WANTS TO GO INTO WHEN DECELERATING. *TR

I OWN A 2005 BOUGHT BRAND NEW HYUNDAI TUCSAN. TODAY WE WENT TO PUT SOMETHING IN THE HATCH USING THE WINDOW AND IT FELL INTO MY HANDS. THE LATCHES ARE SO CORRODED THAT THEY JUST FELL OFF. THIS SHOULD NOT BE HAPPENING TO A 6 YR OLD VEHICLE. *TR

WHILE OPENING THE REAR HATCH WINDOW OF MY 2005 HYUNDAI TUCSON, BOTH WINDOW HINGES BROKE AND THE WINDOW FELL INTO MY HANDS. THE VEHICLE WAS PARKED IN THE DRIVEWAY. WHEN I CALLED THE DEALER HE SAID THE HINGES WERE $97. A PIECE AND SAID HE HAD A LOT OF THEM IN STOCK (WHICH LEADS ME TO BELIEVE THIS HAPPENS A LOT MORE FREQUENTLY THAN IS REPORTED!)

MY AXLE NUTS ARE SERIOUSLY CORRODED, TO THE POINT THEY NO LONGER LOOK LIKE NUTS. I'M VERY CONCERNED THE AXLES MAY SEPARATE FROM THE WHEELS.

ALL FOUR YOKOHAMA AVID TOURING S P215/65/16 TIRES HAVE EXTREME TREAD/MOLD SEPARATION AT 40,000 MILES MAKING THEM UNSAFE TO DRIVE ON. *TR

MY DAUGHTER REAR-ENDED ANOTHER VEHICLE AT APPROXIMATELY 10 MPH THE AIRBAGS DID NOT DEPLOY AND THE SEATBELTS DID NOT LOCK. SHE HIT HER HEAD AND CHEST ON THE STEERING WHEEL. SHE NOW HAS SEVERE WHIPLASH AND BRUISING. *TR

1-2-05 I BOUGHT MY TUSCAN HYUNDAI-MAT ROLLING UP/SUNGLASS CASE STICKING. MATS WERE REPLACED. GLASS CASE FIX 06 PROBLEMS LIST: AUGUST 22, 005--PERFORM RECALL 068-ESP-HECU REPROGRAMMING- PASSENGER DOOR GETS STUCK--NPF UNABLE TO DUPLICATE CUSTOMERS CONCERN-CUSTOMER TO RETURN AT A LATER DATE.---- SUNGLASS CASE GETS STUCK--THEY WERE UNABLE TO DUPLICATE IT. D C/S CHECK ENGINE LIGHT IS ON--CHECK AND REPORT M PERFORMED SCAN TOOL TEST FOUND GAS CAP LOOSE--RESET LIGHT--OK--- C/S CHECK BRAKES THEY LOCK UP THEN SLIDE--M PERFORMED BRAKE CHECK--NO PROBLEM FOUND--- C/S SEAT BELT ON P/S SQUEAKS WHILE DRIVING--CANNOT LOCATE FEBRUARY 22, 06 C/S PERFORM OPEN CAMPAIGN AS REQUIRED--50B035R1--RECALL 922 C/S PLASTIC CAP ON PASSENGER SEAT BOTTOM, CRACKED PART ON ORDER- C/S EYEGLASS CASE NOT OPENING AT TIMES--PART ON ORDER D C/S PERFORM L.O.F. LOF PERFORM OIL AND FILTER CHANGE/LUBE SUSPENSION/CHECK AND ADJUST TIRE PRESSURE SERVICE ADVISOR APRIL IRRIZARY AUG 02, 06-- C/S BRAKES PULSATING--CAUSE 99--51712A00--BRAKE DISC SERVING ON BOTH SIDE C/S SEAT TRACK COVER MISSING ON PASSENGER SIDE--PART IS ON ORDER C/S ESP LIGHT IS ON--E REFER TO LINE 1. THE VERY NEXT DAY ON I-95 IN RUSH HOUR THE ESP LIGHT COMES ON, I LOOSE POWER BUT THIS TIME BOTH FUEL/BRAKE GET STUCK. AUG 04,06 I BROUGHT BACK THE VEHICLE ----C/S CAR LOOSES POWER, BRAKES LOCK, ESP LIGHT GOES ON-CAUSE 99--THEY GAVE ME A LONER CAR AND TOLD ME NOT TO WORRY ABOUT THE MILEAGE AND THEY WOULD CALL ME WHEN IT WAS READY. I HAD THE CAR FOR 9 DAYS. CAUSE 99--REAR WHEEL SPEED SENSOR (RH) ABS RE--214-W 1-95690-2E300 SENSOR ASM. YESTERDAY, SUNDAY, AUGUST 20, 2006--I DROVE AROUND ALOT AROUND 7:30 PM. WHILE SLOWING DOWN FOR A LIGHT MY BRAKE LOCK CAUSE ME TO SWIRL TO THE SIDE TO AVOID HITTING THE CAR IN FRONT OF ME. CAN SOMEONE HELP ME PLEASE! I DON'T WANT TO CRASH OR HAVE INDIVIDUALS HURT IN MY VEHICLE NEITHER! *NM