2006 Hyundai Tucson Problems

The contact owns a 2006 Hyundai Tucson. The contact stated while driving at various speeds, he noticed that the air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed with the air bag module needing to be replaced. The independent mechanic cleaned the contacts for the seat sensors however, the failure recurred. The manufacturer was not informed of the failure. The contact related the failure to an unknown recall. The failure mileage was approximately 100,000.

RECALL FOR MY AIRBAG WAS NOT DONE. BRAKE LIGHTS DON'T WORK, ELECTRICAL PROBLEMS.

The contact owns a 2006 Hyundai Tucson. The contact stated that while attempting to start the vehicle, the vehicle hesitated. The vehicle was taken to an independent mechanic, where it was diagnosed; however, the cause of the failure was not yet determined. The contact stated while driving at an undisclosed speed, the vehicle stalled. The check engine warning light and the TPMS warning light were illuminated. Additionally, the engine overheated. The contact related the failure to an unknown recall and Technical Service Bulletin: 952. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

When I drive my car and right after I put gas in my car I smell gas to the point that my husband and I are coming home with headaches and we're sick to her stomach I've taken it to a mechanic and they say there's nothing wrong the engine check engine light keep on coming on and then it will go off after it sit for a couple minutes turned off I'm about ready to have a baby in June and I'm so worried to have the baby in the car the brakes have stopped working to the point that I've gone in through lights and I can hardly put the brakes on I have to use emergency brake sometimes and nobody will help me get it taken care of I have had almost couple wrecks because I cannot get the brakes to stop take a lock on me and it's scary when you're having a baby and you know your seatbelt your brakes are locking but you for your seat belt to keep safe and my brakes locked to the point I cannot get them after the kick hit them with all my might just to unlock them and nobody will help me fix it

ESC OFF light does not turn off. I press it off and on while driving and nothing happens. It stays on all the time.

At first brakes were making noise so I went to replace them after getting parts and I noticed that the brake pedal went to the floor I was able to get it on concrete pad but when I jacked it up I say big chunks of rust falling when I looked under car rear axle subframe was pretty much gone after I say that I decided to order the replacement subframe but when it come in and I was getting ready to do it I body mount where it is bolted also needs replaced I was trying to find them when I come across a factory recall about this issue when I contacted them and the dealer about this issue dealer said it couldn't be done because there was nothing left and he refused to put on a lift because he said the rear subframe would fall on ground but manufacturer denied to repair or make any resolutions for it even though they had in past and they new about the problem I have found over 1000 issues listed and they have repaired a bunch of the same vehicles for the same issue I told them I never received anything about the issue and they said it was my responsibility not there's so not only did they not do or even try to do what they have on recall but they refused to do anything for me and I was glad I didn't try driving after I heard noise because I could of caused a major accident and been severely injured in process not to mention someone else due to rear frame and brakes falling and falling out of car

THE VEHICLE WHILE FOOT ON BRAKE OR WHILE IN PARK ACCELERATES ON ITS OWN! I ALMOST GOT INTO AN ACCIDENT BECAUSE MY FOOT WAS ALL THE WAY ON THE BRAKE FOR CAR TO STOP BUT ENGINE WAS STILL INCHING FORWARD WHILE IN STOPPED POSITION! WHEN IT IS IN PARK IT TRIES TO ACCELERATE BUT ENDS UP STALLING OUT AND THEN IM UNABLE TO START BACK UP FOR ABOUT 10 MINUTES ALSO WHEN GOING A STEADY CITY WIDE SPEED MY CAR CHOOSES TO ACCELERATE WITHOUT MAKING IT DO SO THIS IS SCARY I HAVE 2 SMALL CHILDREN AND THIS IS DANGEROUS I HAVE CARRIED IT TO 2 DIFFERENT MACHANIC SHOPS ONE BEING FIRESTONE BEST OF THE BEST AND HAVE HAD DIOGNOSTIC TESTS CONDUCTED AND THEY ARE UNABLE TO FIND THE CAUSE OF MY ISSUE! IT HAPPENS AT VARIOUS TIMES I HAVE READ MANY OF THE SAME ISSUES HAPPENING ONLINE WITH THE TUSCONS AND SANTA FE THIS ISSUE NEEDS TO BE INVESTIGATED! I ALMOST HIT SOMEONE IN THE REAR END WITH MY FOOT COMPLETELY ON THE BRAKE! AND IT WAS AS IF I WAS FIGHTING WITH MY VEHICLE TO STOP

WHILE DRIVING ONE DAY, I FELT MY CAR SHIFT AS IF THE WHEEL HAD SLIPPED, THIS OCCURRED MANY TIMES AFTER MAKING A TURN. I RECENTLY HAD WORK DONE TO THE FRONT (STRUT, TIE ROD, KNUCKLE, BALL JOINT) AND AM ALSO IN NEED OF A WHEEL ALIGNMENT. I WONDERED IF THIS WAS WHY, SO I CALLED THE MECHANIC BACK, BUT HE TOLD ME THAT IT WAS MY TIRES. HOWEVER THERE IS STILL A FAIR AMOUNT OF TREAD ON MY TIRES, SO I AM NOT SURE IF THATS REALLY TRUE. NEXT THING I KNOW, MY CAR ACCELERATED OUT OF NOWHERE AND WAS ALMOST LIKE DRIVING ITSELF AT 20MPH (THE SPEED IT WAS STUCK ON EVEN AFTER SLOWING DOWN). ALSO WHILE ON THE HIGH WAY IT DID THE SAME THING-- ACCELERATED ON ITS OWN AND JERKED TO THE RIGHT. I HAD TO PRETTY MUCH HURRY AND CATCH THE WHEEL BEFORE SLAMMING INTO ANOTHER CAR WHILE ON A TURN AND GOING ABOUT 55MPH. AT RANDOM TIMES IT WILL ACCELERATE AND PRETTY MUCH DRIVE ITSELF WHILE I AM DRIVING. I TYPICALLY HAVE TO APPLY PLENTY OF PRESSURE TO THE BRAKES TO KEEP IT FROM ROLLING WHILE I AM STOPPED. ALSO I AM HAVING AN ISSUE WITH OVERHEATING. IF I IDLE TOO LONG THE CAR WILL OVERHEAT, EVEN THOUGH THE TANK IS FULL. EVEN WITH ADDING MORE IN, THE TANK STAYS WHERE IT IS, IT DOESN'T OVERFLOW. IT'S ALMOST AS IF THE CAR IS JUST DRINKING IT BUT IT'S NOT FILTERING THROUGH THE HOSE IF THAT MAKES SENSE. LASTLY, THE CAR DID NOT WANT TO TURN ON THIS EVENING, AFTER ABOUT THE 5TH TIME I HELD IT LONGER THAN USUAL AND IT FINALLY PUTTERED TO LIFE RELUCTANTLY. I DON'T FEEL VERY SAFE IN THIS TRUCK ANYMORE.

When it rains my steering wheel locks up when I drive thru a puddle I have brought my car to used car dealer where I bought it from and they say nothing is wrong but steering wheel locks when driving that to me is major problem they checked belt water is getting somewhere and causing a short hence power steering to lock it only happens when it rains

HYUNDAI NEVER NOTIFIED US OF THE SUBFRAME RUST RECALL. OUR MECHANIC JUST POINTED OUT THAT OUR'S. HE SAID THE CAR IS UNSAFE TO DRIVE. GETTING IT REPLACED AT OUR EXPENSE. BRAKE LINES HAVE ALREADY FAILED AND HAD TO BE REPLACED AT OUR EXPENSE. ALTERNATOR AND POWER STEERING PUMP, FRONT SUSPENSION ALL AT OUR EXPENSE. HYUNDAI UNRESPONSIVE.

The contact owns a 2006 Hyundai Tucson. The contact stated while the vehicle was parked, the contact noticed that the rear subframe had become inoperable and the contact noticed that the rear subframe was corroded. The vehicle was towed to an independent mechanic but was not diagnosed or repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 180,000.

At first brakes were making noise so I went to replace them after getting parts and I noticed that the brake pedal went to the floor I was able to get it on concrete pad but when I jacked it up I say big chunks of rust falling when I looked under car rear axle subframe was pretty much gone after I say that I decided to order the replacement subframe but when it come in and I was getting ready to do it I body mount where it is bolted also needs replaced I was trying to find them when I come across a factory recall about this issue when I contacted them and the dealer about this issue dealer said it couldn't be done because there was nothing left and he refused to put on a lift because he said the rear subframe would fall on ground but manufacturer denied to repair or make any resolutions for it even though they had in past and they new about the problem I have found over 1000 issues listed and they have repaired a bunch of the same vehicles for the same issue I told them I never received anything about the issue and they said it was my responsibility not there's so not only did they not do or even try to do what they have on recall but they refused to do anything for me and I was glad I didn't try driving after I heard noise because I could of caused a major accident and been severely injured in process not to mention someone else due to rear frame and brakes falling and falling out of car

At first brakes were making noise so I went to replace them after getting parts and I noticed that the brake pedal went to the floor I was able to get it on concrete pad but when I jacked it up I say big chunks of rust falling when I looked under car rear axle subframe was pretty much gone after I say that I decided to order the replacement subframe but when it come in and I was getting ready to do it I body mount where it is bolted also needs replaced I was trying to find them when I come across a factory recall about this issue when I contacted them and the dealer about this issue dealer said it couldn't be done because there was nothing left and he refused to put on a lift because he said the rear subframe would fall on ground but manufacturer denied to repair or make any resolutions for it even though they had in past and they new about the problem I have found over 1000 issues listed and they have repaired a bunch of the same vehicles for the same issue I told them I never received anything about the issue and they said it was my responsibility not there's so not only did they not do or even try to do what they have on recall but they refused to do anything for me and I was glad I didn't try driving after I heard noise because I could of caused a major accident and been severely injured in process not to mention someone else due to rear frame and brakes falling and falling out of car

Rear cross member frame broke in 2 spots due to rust. I’ve searched this and found numerous vehicles with same problem contacted dealer and they said they can’t do anything about it. What steps should I take. I called there corporate office left They don’t don’t return calls callsor or texts complaints.

Rear control arm mount broke away from subframe while on the highway going 65mph. Violent shaking and steering malfunction occurred immediately. Passed WV inspection just a few months ago.

When it rains my steering wheel locks up when I drive thru a puddle I have brought my car to used car dealer where I bought it from and they say nothing is wrong but steering wheel locks when driving that to me is major problem they checked belt water is getting somewhere and causing a short hence power steering to lock it only happens when it rains

DRIVING ON AN INTERSTATE THE "AIR BAG" LIGHT CAME ON. EVENTUALLY DIAGNOSED SRS CODE B1706 "PASSENGER BUCKLE PRETENSIONER RESISTANCE TOO HIGH" ADVISED AIR BAG MAY NOT DEPLOY PROPERLY OR AT ALL UNTIL REPAIRED. ON VACATION AT THE TIME, NOT CLOSE TO A DEALER. PASSENGER SEAT BELT SYSTEM WILL HAVE TO BE REPLACED.

I PD A HYUNDAI TUCSON DEALER A $100.00 TO PUT A COMPUTER ON MY 2006 CAR TO FIND OUT WHY MY AIR BAG LIGHT WAS ON TOOK THEM JUST A FEW MINUTES TO TELL ME IT WAS THE SEAT BELTS WAS THE REASON THE LIGHT WAS ON AND IT WOULD ONLY COST $600.00 TO CHANGE THEM. I AM IN MY 70 TS ON FIXED INCOME AFTER MY MEDICARE I ONLY HAVE $400.00 SS TO LIVE ON. THAT MEANS I WON'T EAT FOR 3 MOUTHS OR HAVE HEAT OR PAY ANY OTHER BILLS IF I WONT TO DRIVE MY CAR AND I LIVE A LONG FROM TOWN AND AM HANDICAPPED. THE DEALER TOLD ME THAT THE SEATBELT PROBLEM IS THE MOST REASON THE AIR BAG LIGHT COMES IN THIS CAR THEY CHANGE A DOZEN OR MORE A MONTH, HYUNDAI AND NTSB SHOULD BE ASHAMED TO LET THIS HAPPEN PLEASE HELP [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

STOP LAMP SWITCH MALFUNCTIONING CAUSING THE ILLUMINATION OF THE "ESC" (ELECTRONIC STABILITY CONTROL) INDICATOR LAMP IN THE INSTRUMENT CLUSTER TO STAY ON. THIS CONDITION ALSO OCCURRED ON MY 2008 HYUNDAI TUCSON FOR WHICH THERE WAS A RECALL. THE PROBLEM WAS REPAIRED ON 5/23/2013 AT ADVANTAGE HYUNDAI IN HICKSVILLE, NY. ATTACHED TO THIS COMPLAINT IS THE RECALL NOTICE FOR THE 2008 TUCSON AND THE REPAIR RECEIPT OF 5/23/13. I INQUIRED ON 6/25/2017 AS TO WHETHER THERE WAS A RECALL FOR THE 2006 TUCSON I OWN AND WAS INFORMED THAT THERE IS CURRENTLY NOT AN OPEN RECALL FOR THIS CONDITION. IT IS APPARENT TO ME THAT THIS ISSUE ALSO AFFECTS 2006 HYUNDAI MODELS ALSO. I AM REQUESTING YOUR ASSISTANCE IN OPENING AN INVESTIGATION REGARDING MY 2006 HYUNDAI TUCSON AND FOR THIS MODEL TO BE INCLUDED IN THE AFFECTED GROUP AND FOR HYUNDAI TO CORRECT THE ISSUE ON MY VEHICLE.

TL* THE CONTACT OWNS A 2006 HYUNDAI TUCSON. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ESC AND THE ABS WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SWITCH ASSEMBLY STOP LAMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V280000 (EXTERIOR LIGHTING) HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V113000 (EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE WAS 58,197.

TL* THE CONTACT OWNS A 2006 HYUNDAI TUCSON. THE CONTACT STATED THAT THEY HEARD A LOUD THUMPING COMING FROM UNDERNEATH THE VEHICLE. THEY INSPECTED THE VEHICLE AND NOTICED A METAL CONTAINER WITH A PLASTIC CASING THAT WAS GETTING BURNED DUE TO A FUEL LINE LEADING TO IT. THE CONTACT STATED THEIR VEHICLE WAS INCLUDED IN A RECALL WHERE THE STRAPS WERE PLACED TO HOLD THE GAS TANK WAS NEAR A UNIT THAT HAD WIRES RELATING TO THE GAS TANK AND TOWARDS THE ENGINE, INDICATING IT WAS THE COMPUTER USED FOR THE FUEL LINE CONNECTION BETWEEN THE GAS TANK AND THE ENGINE. THE CONTACT SPOKE WITH THE DEALER (LIBERTYVILLE LINCOLN 941 S MILWAUKEE AVE, LIBERTYVILLE, IL 60048; (847) 367-1700) WHO STATED THAT DUE TO THEIR VEHICLE NOT BEING INCLUDED IN A RECALL THEY WERE UNABLE TO DIAGNOSE THE VEHICLE FREE OF CHARGE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE 165,000.

MY 2006 TUCSON HAS FAILED TO START MULTIPLE TIMES. IT CRANKS, BUT DOESN'T START. DEALER HAS REPLACED THE FUEL PUMP 4 OR 5 TIMES, AND IT THEN WORKS, BUT THE PUMP KEEPS FAILING. SOME TIMES THE PUMP LASTED OVER A YEAR, AND OTHER TIMES THE PUMP HAS FAILED WITHIN A COUPLE OF MONTHS. *JS

The contact owned a 2006 Hyundai Tucson. The contact stated that after parking his vehicle in the driveway, he looked through the window of his residence and noticed that the vehicle had caught fire from underneath the hood. The contact related the fire to an electrical system failure. The fire department was able to extinguish the fire. Police and fire department reports were filed. The vehicle was towed to a tow yard and deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 198,000.

TL* THE CONTACT OWNS A 2006 HYUNDAI TUCSON. WHILE DRIVING IN REVERSE, AN ABNORMAL NOISE EMITTED FROM THE REAR OF THE VEHICLE. THERE WAS A VIBRATION FROM THE VEHICLE AND THE CONTACT NOTICED THAT THE WHEELS WERE LEANING SIDEWAYS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WHEEL CRADLE WAS RUSTED AND FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. UPDATED 01/27/17*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED AT THEIR EXPENSE. *TR

TL* THE CONTACT OWNS A 2006 HYUNDAI TUCSON. WHILE DRIVING 35 MPH, THE GEAR SHIFTED WITHOUT NOTICE AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (CLASSIC HYUNDAI LOCATED AT 8460 TYLER BLVD MENTOR, OH 44060 440-210-4114), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 103,000.

AFTER TAKING LEFT TURN THE REAR END STARTED TO SHAKE HAD CAR TOWED TO GARAGE WHERE IT WAS FOUND THE REAR SUB FRAME HAD COMPLETE BROKEN OFF. *TR

2006 TUCSON 5-SPEED MANUAL TRANSMISSION SUV REMAINS STUCK IN 3RD GEAR. CAR PARKED AND IGNITION TURNED OFF WHILE GEAR STILL ENGAGED RESULTS IN THIS LOCKED-UP GEAR BACKLASH PROBLEM. WORK AROUND: LEAVE PARKING BRAKE RELEASED. LEAN ON CAR BUMPER AND PUSH SLIGHTLY TO FREE THE POWER TRAIN. *TR

MY HYUNDAI TUCSON WILL STALL EACH TIME THE VEHICLE IS DRIVEN STEADILY AT HIGHWAY SPEED FOR 20 MILES OR SO. GETTING BACK ON SURFACE STREETS IT BEGINS TO SUDDENLY DOWNSHIFT INTO 2ND OR FIRST WHEN SLOWING OR BRAKING. FOLLOWING THIS, THE VEHICLE WILL STALL IF IT GETS SLOW ENOUGH OR YOU COME TO A STOP. I FEAR BEING REARENDED OR LEFT IN A LANE TO RESTART WITH TRAFFIC BEARING DOWN. THE INTERNET HAS SEVERAL INSTANCES OF THE SAME PROBLEM WITH NO RESOLUTION FROM HYUNDAI. I ADD MY INFORMATION, IN HOPE IT WILL SAVE SOMEONE AND SOLVE THE PROBLEM. I HAVE OWNED THE VEHICLE 4 MONTHS AND I'M THE 3RD OWNER, BOUGHT FROM HYUNDAI LOT.*DT

The contact owns a 2006 Hyundai Tucson. The contact stated that while attempting to start the vehicle, the vehicle hesitated. The vehicle was taken to an independent mechanic, where it was diagnosed; however, the cause of the failure was not yet determined. The contact stated while driving at an undisclosed speed, the vehicle stalled. The check engine warning light and the TPMS warning light were illuminated. Additionally, the engine overheated. The contact related the failure to an unknown recall and Technical Service Bulletin: 952. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

THE POWER WINDOWS ON THE VEHICLE WERE NOT WORKING. THE VEHICLE WAS TAKEN TO A MECHANIC, WHO FOUND A BLOWN FUSE. THE FUSE WAS REPLACED, AND ALMOST IMMEDIATELY, THE TIRE PRESSURE MONITOR COMPUTER LOCATED UNDER THE CENTER CONSOLE STARTED TO BURN. THE MECHANIC DISCONNECTED THE FUSE AND CUT THE WIRES TO THE TPMS MODULE. I THEN TOOK THE CAR TO THE DEALERSHIP TO EXPLAIN THE PROBLEM. AT FIRST THEY ACTED LIKE THEY DIDN'T HAVE ANY IDEA WHAT I WAS TALKING ABOUT. I LEFT THE CAR WITH THEM. SEVERAL HOURS LATER, THEY ADVISED THE TPMS MODULE HAD INDEED SHORT CIRCUITED AND THEREFORE THE MODULE AND ENTIRE HARNESS WOULD HAVE TO BE REPLACED AT A COST OF $3,000. THEY COULD NOT ADVISE ME WHY THIS HAPPENED. IN FACT, THE SERVICE REP COULD NOT UNDERSTAND WHY REPLACING A WINDOW FUSE WOULD CAUSE THE TPMS MODULE TO BURN SINCE THEY ARE ON DIFFERENT CIRCUITS. ALSO, I BELIEVE THE TPMS MODULE HAS IT'S OWN FUSES WHICH SHOULD HAVE BLOWN PRIOR TO BURNING. I REPORTED THIS TO HYUNDAI USA AND THEY INVESTIGATED. THEY EMAILED ME TO ADVISE THE PROBLEM WAS BETWEEN MYSELF AND THE DEALERSHIP. WHEN I TRIED TO REPLY TO THEM, THEY BLOCKED MY EMAIL ADDRESS COMPLETELY, SO I EMAILED THEM UNDER A DIFFERENT EMAIL ADDRESS. THEY HAVE NOT RESPONDED. I BELIEVE THIS COULD HAVE BEEN A SERIOUS PROBLEM RESULT IN A CAR FIRE HAD THE MECHANIC NOT DISCONNECTED THE SYSTEM WHEN HE DID. I AM REPORTING THIS TO YOU IN CASE OTHERS HAVE HAD SIMILAR PROBLEMS. THIS MAY BE A DESIGN FLAW AS A FUSE SHOULD HAVE BLOWN ON THE TPMS MODULE (A DIAGRAM INDICATES A SLOW FUSE SHOULD BE PRESENT). *TR

TL-THE CONTACT OWNS A 2006 HYUNDAI TUCSON. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH. THE VEHICLE SUNROOF DISENGAGED FROM THE VEHICLE AND FLEW OFF. THE VEHICLE HAD NOT BEEN TAKEN TO AN DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSIS OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.LJ

THE POWER WINDOWS ON THE VEHICLE WERE NOT WORKING. THE VEHICLE WAS TAKEN TO A MECHANIC, WHO FOUND A BLOWN FUSE. THE FUSE WAS REPLACED, AND ALMOST IMMEDIATELY, THE TIRE PRESSURE MONITOR COMPUTER LOCATED UNDER THE CENTER CONSOLE STARTED TO BURN. THE MECHANIC DISCONNECTED THE FUSE AND CUT THE WIRES TO THE TPMS MODULE. I THEN TOOK THE CAR TO THE DEALERSHIP TO EXPLAIN THE PROBLEM. AT FIRST THEY ACTED LIKE THEY DIDN'T HAVE ANY IDEA WHAT I WAS TALKING ABOUT. I LEFT THE CAR WITH THEM. SEVERAL HOURS LATER, THEY ADVISED THE TPMS MODULE HAD INDEED SHORT CIRCUITED AND THEREFORE THE MODULE AND ENTIRE HARNESS WOULD HAVE TO BE REPLACED AT A COST OF $3,000. THEY COULD NOT ADVISE ME WHY THIS HAPPENED. IN FACT, THE SERVICE REP COULD NOT UNDERSTAND WHY REPLACING A WINDOW FUSE WOULD CAUSE THE TPMS MODULE TO BURN SINCE THEY ARE ON DIFFERENT CIRCUITS. ALSO, I BELIEVE THE TPMS MODULE HAS IT'S OWN FUSES WHICH SHOULD HAVE BLOWN PRIOR TO BURNING. I REPORTED THIS TO HYUNDAI USA AND THEY INVESTIGATED. THEY EMAILED ME TO ADVISE THE PROBLEM WAS BETWEEN MYSELF AND THE DEALERSHIP. WHEN I TRIED TO REPLY TO THEM, THEY BLOCKED MY EMAIL ADDRESS COMPLETELY, SO I EMAILED THEM UNDER A DIFFERENT EMAIL ADDRESS. THEY HAVE NOT RESPONDED. I BELIEVE THIS COULD HAVE BEEN A SERIOUS PROBLEM RESULT IN A CAR FIRE HAD THE MECHANIC NOT DISCONNECTED THE SYSTEM WHEN HE DID. I AM REPORTING THIS TO YOU IN CASE OTHERS HAVE HAD SIMILAR PROBLEMS. THIS MAY BE A DESIGN FLAW AS A FUSE SHOULD HAVE BLOWN ON THE TPMS MODULE (A DIAGRAM INDICATES A SLOW FUSE SHOULD BE PRESENT). *TR

REAR HATCH WINDOW, BOTH HINGES BROKEN (CORRODED) WINDOW FALLS OUT, HELD IN ONLY BY GAS STRUTS. *TR