2018 Hyundai Tucson Problems

​On Thursday, August 6, 2026, while driving my 2018 Hyundai Tucson on Interstate 81, the vehicle experienced sudden, severe engine vibration and a loud metallic ticking sound before losing power and stalling completely on the highway. I was stranded on the side of the highway in a high-speed traffic zone, creating an immediate and hazardous safety situation. ​Because the vehicle was completely inoperable, I was forced to pay $200 out-of-pocket to have the vehicle towed 35 miles to the nearest authorized Hyundai dealership service center. ​Upon arrival at the dealership, an on-site service technician performed an OBD-II diagnostic scan on the lot and confirmed diagnostic trouble code P1326 (Engine Knock Sensor Detection System / Connecting Rod Bearing Failure). Despite the technician confirming the presence of this critical safety defect, the dealership service desk explicitly refused to enter the diagnostic code into Hyundai’s corporate system, stating they would not process or submit the vehicle for inspection or warranty authorization for over a month. ​Hyundai Motor America Customer Care was contacted immediately and witnessed the dealership’s refusal to log the safety defect. While Corporate assigned a Case Manager, Hyundai and the dealership have continually stalled the intake process under Service Campaign 966 / T6G and refused to provide direct-bill rental transportation or loaner support while the car sits disabled on the dealer lot. ​As a direct result of this sudden highway engine failure, the manufacturer's failure to address a known safety defect, and the refusal to provide recall mobility support, I have suffered ongoing financial loss, out-of-pocket towing expenses, and forced leave from employment. I am filing this report to document the hazardous highway failure of code P1326 and the refusal of the manufacturer and dealer to process a critical safety recall intake in a timely manner. My husband is the registered owner but I am the driver.

My car had a lot of trouble accelerating it’s delayed

While driving my 2018 Hyundai Tucson Limited 1.6L Turbo with the 7-speed EcoShift dual clutch transmission (DCT), the vehicle has repeatedly failed to engage and hold gears, resulting in loss of motive power in traffic. Diagnostic scanning retrieved codes P074B (Unable to Engage Gear 3), P074B71 (Unable to Select 3rd Gear), P074B07 (Gear Dropped Out of 3rd Gear), P092177 (1st Gear System Referencing Failure), and P0921 (Gear Shift Forward Actuator Circuit Range/Performance). A Hyundai dealer diagnosed the failure as requiring transmission replacement at approximately 93,000 miles. This is the same 7-speed DCT and the same failure mode addressed by NHTSA Campaign 16V628000 (Hyundai Recall 149) and Hyundai Service Campaign T1B, which covered 2016–2017 Tucson vehicles but excluded the 2018 model year despite using the same transmission. Hyundai has acknowledged this defect in 2018 vehicles through TSB 21-AT-014H and TSB 22-AT-007H, which prescribe a TCU software update, but issued these as service bulletins rather than a recall, so owners were never notified. When I requested the TSB software update, the Hyundai dealer refused to perform it. This defect creates a serious safety hazard: the vehicle can drop out of gear or fail to accelerate without warning while in traffic, increasing the risk of a crash — the identical hazard NHTSA cited in granting recall 16V628000. I request that NHTSA review whether the existing recall scope should be expanded to include 2018 Tucson vehicles.

January 9, 2026, driver was on I25, when driver heard a loud thud and the RPMs kept rising but the vehicle would not accelerate. Was very dangerous and barely avoided a collision with other drivers on the road. Barely got it home and shut it off. Tried to drive again but would not get out of reverse. Car was towed to Hyundai dealership for inspection. EGO4 Check Engine Light Diagnostic. 120883. Transmission and rear coupler/differential replaced. Test driven and dealership said it drove as designed and shifted as designed. Cost $10,955.29.

I purchased this car [XXX] as a CPO vehicle from a Ford dealership. By [XXX] the oil pressure light would flicker and it was clear the car was burning a lot of oil between changes. On 8/22 an oil change was completed at dealer. On [XXX] the oil pressure light flickered and it was three quarts down. An oil consumption test was started at 112,000. On Sat [XXX] while driving to dealer for oil check, the car began shuddering violently and the check engine light came on, and went into limp mode. I was on a dangerous mountain pass at the time and it could have been a major issue. The day before a tractor trailer had almost run me off the road, if my car had stalled then I might not be here. Hyundais have a known issue with oil burning and engine damage. Right now I am stuck in a 14K loan with a car that is unsafe to drive. I am not sure what the dealer plans to do, or what the diagnosis is, but its clear these engines are not safe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Hyundai Tucson. The contact stated while driving 70 MPH and depressing accelerator pedal, the vehicle started to decelerate. The contact pulled over to the right side of the road and turned off the vehicle. The contact waited for two minutes and attempted to restart the vehicle; however, the vehicle failed to respond as needed. The brake warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed with a misfire in cylinders #1 and #2. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 20V543000 (SERVICE BRAKES, HYDRAULIC); however, the VIN was not included. The manufacturer was notified not notified of the failure. The failure mileage was 177,000.

While driving my 2018 Hyundai Tucson Limited 1.6L Turbo with the 7-speed EcoShift dual clutch transmission (DCT), the vehicle has repeatedly failed to engage and hold gears, resulting in loss of motive power in traffic. Diagnostic scanning retrieved codes P074B (Unable to Engage Gear 3), P074B71 (Unable to Select 3rd Gear), P074B07 (Gear Dropped Out of 3rd Gear), P092177 (1st Gear System Referencing Failure), and P0921 (Gear Shift Forward Actuator Circuit Range/Performance). A Hyundai dealer diagnosed the failure as requiring transmission replacement at approximately 93,000 miles. This is the same 7-speed DCT and the same failure mode addressed by NHTSA Campaign 16V628000 (Hyundai Recall 149) and Hyundai Service Campaign T1B, which covered 2016–2017 Tucson vehicles but excluded the 2018 model year despite using the same transmission. Hyundai has acknowledged this defect in 2018 vehicles through TSB 21-AT-014H and TSB 22-AT-007H, which prescribe a TCU software update, but issued these as service bulletins rather than a recall, so owners were never notified. When I requested the TSB software update, the Hyundai dealer refused to perform it. This defect creates a serious safety hazard: the vehicle can drop out of gear or fail to accelerate without warning while in traffic, increasing the risk of a crash — the identical hazard NHTSA cited in granting recall 16V628000. I request that NHTSA review whether the existing recall scope should be expanded to include 2018 Tucson vehicles.

While idling at a standstill (in a drive-thru queue), my 2018 Hyundai Tucson suddenly experienced a severe engine overheat, causing the vehicle's air conditioning system to immediately blow hot air and shut down. The vehicle was brought directly to an authorized Hyundai dealership (Chapman Hyundai on [XXX]) for an emergency inspection.The dealership's certified technicians confirmed that the electric Engine Cooling Fan Assembly completely failed and subsequently caused the main Front Wiring Harness and Fuse Box to physically melt. The dealership documented this catastrophic electrical and thermal meltdown under Repair Order #XXX.This is a critical safety defect. A melted engine wiring harness poses an immediate and severe risk of an electrical short circuit, sudden vehicle stalling in live traffic, or a catastrophic under-hood engine fire. Because this component controls the primary cooling of the powertrain, its failure creates an extreme hazard to the vehicle occupants and surrounding traffic. Hyundai must investigate this component failure before it results in a thermal fire incident or an accident due to sudden power loss. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car shaking, oil is burning , and drive hard. Engine and, oil light is now appearing.

This vehicle had a engine replaced by the dealership Nov 2024.Has not run the same since.Getting worse and seems like transmission issues.I was told The first and the 2nd owner which I'm the 2nd owner has a 5 year 100,000 mile warranty.It's been 4 years and since I've had the vehicle I've driven round off 60,OOO miles .The vehicle had $84,000 something miles on it when I got it.It's becoming very dangerous to drive around other cars giving out of power in the middle of streets and barely not going up hills or freeways and streets.😮

Hyundai Tucson has been jerking and shaking for over over 4 years now and either when taking to the dealership they reset the dual clutch and have replaced the same part twice in the dual clutch. This shaking has been happening since the car was bought brand new like a year after. The vehicle now will get stuck in gear and while driving will go down to 20 mph and get stuck in that speed. This is a serious safety issue. The dealer could replicate the shaking but not the gears being stuck. It has happened on more than one occasion and they just reset something but this continues to happen. There are no warning lights when the gears get stuck it just happens while driving and it has happened twice now in the last 3 weeks.

The engine and engine management system of my 2018 Hyundai Tucson experienced repeated failures resulting in loss of propulsion and unsafe drivability. In November 2025, while traveling approximately 75 mph on a freeway, the vehicle suddenly entered limp mode without any prior warning, causing an abrupt loss of power in active highway traffic. No warning lamps or messages appeared before the failure. After the loss of propulsion occurred, the check engine light, battery light, and oil light illuminated sequentially. Diagnostic trouble codes P1326 and P0326 were recorded. Initial inspection indicated severe oil consumption despite a recent oil change less than 2,000 miles earlier. A Hyundai dealership replaced knock sensors under warranty. Shortly after release (30 miles), the vehicle again exhibited severe drivability issues, including a flashing check engine light, and required immediate towing. A second Hyundai dealership replaced the short engine block under warranty. Approximately 180 miles after the engine replacement, the vehicle again developed unsafe drivability symptoms, including delayed throttle response, failure to accelerate unless the accelerator was fully depressed multiple times, jerking or lugging when slowing or stopped, and a faint whining noise. The check engine light illuminated again. These failures represent repeated loss of propulsion and unsafe operation following manufacturer-approved repairs, including full engine replacement. The vehicle has been out of service for approximately 57 days and remains in the custody of a Hyundai dealership awaiting diagnostics. The vehicle is available for inspection upon request. The sudden and unpredictable loss of power at highway speed created a significant risk of collision and serious injury to the driver and surrounding motorists.

I am filing a complaint under the NC Unfair and Deceptive Trade Practices Act (N.C. Gen. Stat. § 75-1.1) regarding Hyundai’s handling of my 2018 Hyundai Tucson (purchased new May 2018). Since 2019, the vehicle has had repeated headlight failures (at least 12 bulb replacements), persistent “bulb out” warnings, and eventually melted wiring requiring headlamp assembly replacement in 2025. These issues were first reported in April 2023 under warranty but dismissed as “could not duplicate.” Hyundai later attempted to deny coverage, only replacing the assembly after escalation to Corporate. At the April 2023 visit, I also reported a rear noise that Hyundai dismissed. After warranty expiration, it was attributed to a leaking shock. Shocks were covered under warranty; failure to act while coverage was active left me unprotected. In May 2023, the engine failed due to oil loss and lock-up. Hyundai retained my vehicle from 5/15–6/30/23 for engine replacement. From Aug–Sep 2025, the car was held an additional 24 days, with no permanent fix for the electrical defect. Overall, my Tucson has been out of service for 60+ days between 2023–2025. Examples of unfair/deceptive conduct: Dismissing documented defects under warranty, only acknowledging later after expiration. Attempting to shift labor costs onto me in Jan 2025 despite warranty obligations. Returning my vehicle with only ~39 miles of gas after requiring me to return a loaner full. Repeated misdiagnoses and delays despite video and documentation provided. These actions are deceptive and unfair, leaving me with an unsafe, unreliable vehicle and causing financial loss and hardship to my work as a self-employed pet sitter and dog groomer. I request the Attorney General investigate Hyundai’s conduct and enforce consumer protections under UDTPA. Service records, receipts, and communications are available upon request.

In the beginning of December 2024, the low headlight warning light started coming on for the right light, intermittently. I took the car to the dealership to get the light fixed, I was told there were some loose wires and they fixed it. 2 weeks later it started happening again, I returned with the car and got another appointment, before the appointment date, the left low headlight warning light came on. I returned with the car and was told that the harnesses and wiring are damaged and need replacing. I have had the drivers side light replaced on 2/26/21 and was back on 4/16/2021. The passenger side light has been replaced on 11/10/2022 and 9/21/23 all been preformed at the Towne Hyundai in Denville NJ.

On October 13th 2025, we were involved in a serious collision while driving our 2018 Hyundai Tucson. The vehicle was struck from behind and spun into a semi-truck, totalling the vehicle. Despite the forward and lateral collision to the semi-truck, no airbags deployed at all during the accident. This resulted in the Tucson driver striking his head on the steering wheel. Our 5-month old son was also on-board the vehicle in his car seat. While everyone walked away from the accident, both adults passengers had whiplash/minor neck injuries that could have been mitigated by airbags deploying. We have serious safety concerns about Hyundai's airbags because of this incident.

The paint on my 2018 Hyundai Tucson began peeling off the side mirrors and the shark-fin antenna on the roof. I have found that many other Hyundai owners are experiencing the same issue. It appears to be a widespread manufacturing defect related to improper paint adhesion, and I believe it should be addressed even though my vehicle is out of warranty.

On October 13th 2025, we were involved in a serious collision while driving our 2018 Hyundai Tucson. The vehicle was struck from behind and spun into a semi-truck, totalling the vehicle. Despite the forward and lateral collision to the semi-truck, no airbags deployed at all during the accident. This resulted in the Tucson driver striking his head on the steering wheel. Our 5-month old son was also on-board the vehicle in his car seat. While everyone walked away from the accident, both adults passengers had whiplash/minor neck injuries that could have been mitigated by airbags deploying. We have serious safety concerns about Hyundai's airbags because of this incident.

After an impact with a large buck (deer) on a main highway while traveling 70 miles per hour, the airbags failed to deploy.

While driving on a public road, the vehicle experienced multiple simultaneous, dangerous malfunctions: Dashboard Warnings: All lights illuminated, including engine (flashing), ABS, traction control, airbag, TPMS, and parking brake, which stayed on though disengaged. Engine & Transmission: Tachometer fluctuated wildly in park; engine revved without accelerator input. Shifting to drive/reverse caused unexpected “kicks.” Vehicle sometimes failed to move when pressing gas, requiring engine restart. Driving Issues: Speedometer read 0 or jumped inconsistently. RPM continued erratically while maintaining speed without accelerator. Steering became extremely difficult. I immediately determined the vehicle was unsafe to drive and returned home with it, which was only a couple miles away. Follow-Up: Hyundai advised dealership diagnosis; they suggested a backup camera module will resolve the issues I experienced in entirety, but also in the same email stated that they could not guarantee it would resolve all of the issues I experienced. This is the second major engine/powertrain failure: first approximately ~70,000 miles (full engine replacement), current approximately ~95,000 miles (approximately ~25,000 miles post-replacement). Recurrence indicates a serious, unresolved safety defect. I am deeply concerned for passenger safety, including children. Other owners report similar issues; the attorney general’s office advised reporting to NHTSA. Summary of Safety Risks: sudden loss of control/power, erratic acceleration, dashboard failures, steering resistance, unpredictable handling, recurrence of major defect. I am submitting this report to NHTSA to request investigation of these recurring defects. I do have video documentation of all of this, as well as ALL written communication with Hyundai National Consumer Affairs and the dealership. I am having a hard time uploading them because of the file limits. Please let me know if any of this will be helpful to you.

56310-D3050 Steering Column Assembly 56400-D3000 Steering Joint Assembly Steering wheel would jerk hard enough to lose grasp of it. Hyundai dealer confirmed Steering Column Assembly was "Faulty". "Faulty" Steering Column Assembly was replaced by Hyundai dealership. No warning lights.

Drivers seat seat does not go up it stays in reclined position No it has not been inspected by the manufacturer No warnings was put in recline position and could not lift up happened a week ago I have to drive to work and it is unsafe driving in this position. I did take it to an autoshop and they said that it could be electrical which they were not equipped to do.

The contact owns a 2018 Hyundai Tucson. The contact stated that while the vehicle was parked, the trunk failed to open from the inside or the outside using the key fob. The vehicle was taken to the dealer where it was diagnosed that the latch was jammed and needed to be replaced. The vehicle was not repaired. The contact linked the failure to NHTSA Campaign Number: 21V619000 (Latches/Locks/Linkages). The manufacturer was notified of the failure. The failure mileage was 23,299.

This vehicle had a engine replaced by the dealership Nov 2024.Has not run the same since.Getting worse and seems like transmission issues.I was told The first and the 2nd owner which I'm the 2nd owner has a 5 year 100,000 mile warranty.It's been 4 years and since I've had the vehicle I've driven round off 60,OOO miles .The vehicle had $84,000 something miles on it when I got it.It's becoming very dangerous to drive around other cars giving out of power in the middle of streets and barely not going up hills or freeways and streets.😮

Hello, I hope your day is going well. Recently I’ve been having an issue with the car “jerking rapidly” when in traffic and rolling slowly and when climbing relatively small hills, it began about 3 months ago but have become progressively worse over the last month. I was told by someone with a similar vehicle that it is the “lower arm control.” The car is only 4 years old. I leased it and at the end of last year or the year before decided to buy it from the dealer. My plan was to have it for the next 5 years but this issue greatly concerns me. It seems to be a manufacturing issue. My car vin is [XXX] and I’d like to correct this issues ASAP. Thanks. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 2018 HYUNDAI TUCSON. THE CONTACT STATED WHILE IDLE ANOTHER VEHICLE DRIVING APPROXIMATELY 55 MPH CRASHED INTO THEIR VEHICLE FROM THE REAR CAUSING THEM TO REAR END THE VEHICLE IN FRONT OF THEM. THE CONTACT STATED THE SEAT BELT FAILED TO RETRACT. THE AIR BAGS DID NOT DEPLOY. THE CONTACT HIT HIS FACE ON THE STEERING WHEEL. THE PASSENGER RECEIVED SHOULDER INJURIES. OTHERS INVOLVED DID NOT RECEIVED INJURIES. THE CONTACT AND THE PASSENGER RECEIVED MEDICAL ATTENTION. THE VEHICLE WAS TOWED AND HAS NOT BEEN OFFICIALLY DEEMED TOTALED AS OF YET. A POLICE REPORT WAS FILED. THE CONTACT HAD NOT CONTACTED THE DEALERSHIP. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE 24,000.

The situation I’m about to explain has happened twice—once in December 2025 and again on January 22, 2026. In December, the roads were very icy, but there was no snow on the ground. As I made a right turn into a Walmart parking lot, I heard a loud metal-breaking sound while turning. I immediately got out and looked underneath my 2018 Hyundai Tucson SEL but didn’t see anything unusual. After finishing my shopping, I started the SUV to pull out of the parking space. The car was trying to move, but the rear tires were not moving at all. A man waiting for my parking spot noticed this and told me one of the tires wasn’t turning. As I drove home, I heard extremely loud metal noises coming from the back of the vehicle—sounds like metal twisting, breaking, and falling to the ground. At no point did any warning lights come on. I took the car to a highly rated mechanic, Premier Car Care, where they did a thorough inspection and found nothing wrong. After being reassured that the vehicle was safe, I continued driving it. Then on January 22, 2026, the same issue happened again. I was driving to my internship, and the roads were slushy. Suddenly, the Tucson became unstable, slid unexpectedly, and I heard the same metal twisting and breaking noises. This time, the ABS light came on briefly and then went off. The vehicle felt unsafe and unstable, even though I was driving very slowly—around 15 miles per hour. I was terrified and nearly hit someone. I had the car towed through Triple A back to the mechanic, but once again, they were unable to find the cause after inspecting it, and it is sitting in my driveway. I am reaching out because I am on disability, I have three children with autism, and I am also currently in school. I rely on this vehicle, and I truly need help investigating what is happening so this issue can be properly identified and fixed before someone gets seriously hurt.

THE WINDSHIELD OF MY 2018 TUSCON CRACKED WITHOUT ANYTHING HITTING IT. THE CAR WAS PARKED ON MY DRIVEWAY