2021 Intech Custom Trailer Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2021 Intech Custom Trailer, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Powertrain (other)150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
UNKNOWN There have been a few incidents of the welds on the axle and body frame failing and the axle separating during towing. These incidents happened to the owners of the RVs specifically the 2021 make and model Intech Sol Horizon. These owners reports their incidents on the Facebook page "The Official Intech Sol Horizon" group. Intech RV (The Manufacture) have been contacted and showed pictures of welds and responded that the welds are "completed correctly." I am not a certified welder or structural engineer, but several owners have the welds inspected by certified welders and was told that the welds are not sufficient. I'm reporting this on the behave of all the 2021 Intech Sol Horizon owners as it poses a safety risk on the owners and others around them. Based on the incidences that have occurred, the welds can fail at anytime. Attached are some pictures of weld failures, original welds that comes from the manufactures, welds that have been reinforced by third-party certified welders.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
The contact owns a 2021 Intech Custom Trailer. The contact stated while the trailer was parked, the contact noticed that the front driver's side tire was worn out on the inside of the wheel. The trailer was taken to an independent mechanic, where it was diagnosed with a driver's side fractured axle. The contact was informed that the front driver's side axle needed to be replaced. The trailer was not repaired. The contact related the failure to an unknown recall; however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was not available.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .