RoadVitals

1997 International Harvester 9300

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Nov 4, 2001
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
4
Latest Feb 27, 2004
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 3 NHTSA owner-reported complaints for the 1997 International Harvester 9300, most frequently naming the engine, steering and transmission categories. 4 safety recalls have been issued covering this model year; and 5 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Engine133.3%
  • Steering133.3%
  • Transmission133.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

4 campaigns cover this model year

View all 4

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
04V100000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Feb 27, 2004
83,312 units potentially affected
The defect: ON CERTAIN CONVENTIONAL TRUCKS EQUIPPED WITH PRO-SLEEPER BERTHS, WATER INTRUSION CAN BE FOUND IN THE BUNK CONTROL PANEL AREA AND POOL IN THE TOPS OF THE DOME LIGHT, TV/VCR, AND OR REFRIGERATOR POWER SWITCHES.
The risk: THE CIRCUIT BOARDS IN THE SWITCHES COULD HEAT UP , POSSIBLY PRODUCE A FLAME OR FIRE, AND CAUSE PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
The remedy: DEALERS WILL INSTALL A WATER SHIELD OVER THE BACK OF THE ENTIRE BUNK CONTROL PANEL. OWNER NOTIFICATION BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK & ENGINE CORPORATIONManufacturer number 04503View on NHTSA.gov
01V023000

SERVICE BRAKES, AIR:SLACK ADJUSTERS

Feb 1, 2001
2,855 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH AIR BRAKE HALDEX AUTOMATIC SLACK ADJUSTERS, LONG STROKE BRAKE CHAMBERS, AND DANA BRAKES. THE AUTOMATIC SLACK ADJUSTER ANCHOR BRACKETS CAN FAIL DUE TO FATIGUE FRACTURE AND COMPLETELY SEPARATE, CAUSING THE SLACK ADJUSTERS TO FUNCTION AS MANUAL SLACK ADJUSTERS.
The risk: IF THE SUPPORT BRACKET FOR AN AUTOMATIC SLACK ADJUSTER FAILS, THE BRAKES AT THAT WHEEL END WILL NOT AUTOMATICALLY ADJUST. AS THE BRAKE LININGS WEAR, THE VEHICLE WILL HAVE REDUCED BRAKING CAPACITY, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSTALL A NEW BRACKET ON EACH SUSPECT SLACK ADJUSTER. OWNER NOTIFICATION BEGAN FEBRUARY 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK AND ENGINEManufacturer number 01502View on NHTSA.gov
96V181002

VEHICLE SPEED CONTROL

Dec 12, 1996
93 units potentially affected
The defect: THESE VEHICLES ARE EQUIPPED WITH A DETROIT DIESEL OPTIMIZED IDLE SYSTEM. IF THE IGNITION IS TURNED ON AND THE FUSE FOR THE ELECTRONIC CONTROL MODULE (ECM) POWER FEED LINE IS REMOVED OR BURNED OUT, UNINTENTIONAL CRANKING OF THE ENGINE WILL OCCUR..
The risk: IF UNINTENTIONAL CRANKING OF THE ENGINE OCCURS, THE SAFETY FEATURES DESIGNED TO PREVENT INJURY TO PERSONS WORKING IN THE VICINITY OF THE ENGINE WILL OCCUR AND ALSO VEHICLE MOVEMENT MAY OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.
The remedy: DETROIT DIESEL DISTRIBUTORS WILL REWIRE THE VEHICLES USING A REVISED ECM WHICH WILL ELIMINATE UNINTENTIONAL CRANKING.
INTERNATIONAL TRUCK AND ENGINEView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Engine
Filed Nov 4, 2001

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID
754079
Incident
Oct 27, 2001
Transmission
Filed Oct 19, 2000

TRANSMISSION HAS BEEN REPAIRED FIVE TIMES, ALWAYS THE SAME COMPONENTS, WHICH IS THE HIGH LOW SINCRO, FIRST TIME AT 136035 MILES JULY 24, 1998 THERE HAVE BEEN TWO OTHER BREAKDOWNS OF THE EXACT SAME PROBLEM PRIOR TO SEPT 11, 2000 ONE AT 194000 MILES AND THEN AGAIN ON OCTOBER 13, 2000 AT 302,000 MILES. THIS NORMALLY LEAVES THE TRUCK IN HIGH RANGE, BUT SOMETIMES LEAVES IT IN A NEUTRAL POSITION WHICH PRESENTS A SAFETY PROBLEM.

NHTSA ID
734700
Incident
Oct 13, 2000
Steering
Filed Dec 30, 1999

RETAINING NUTS ON SPICER YOKE ASSEMBLY BECOME LOOSE. THIS YEAR WE HAVE HAD FOUR FAILURES ON YOKES DUE TO THIS PROBLEM. THE TRUCK WE OWN WAS ORIGINALLY OWNED BY RICHARD KURTZ, WATERTOWN, WI. I HAVE BEEN THE DRIVER OF THIS TRUCK SINCE IT WAS ORDERED NEW. THE FIRST YOKE WENT OUT IN PENNSLYVANIA WHEN I WAS AT A STOP SIGN, AND NEEDED TO BE TOWED AT THAT TIME. THIS WHEN THE TRUCK WAS NEW. CAPITAL CITY INTERNATIONAL SHOULD HAVE A RECORD OF THIS ON FILE FOR THIS TRUCK. WE HAVE HAD THE YOKES REPLACED IN APRIL, JUNE, SEPT, AND NOW THIS WEEK AGAIN THIS YEAR. HEAD GASKETS WERE REPLACED IN NOV. ALL THREE HEADS WERE LEAKING. THIS CONDITION WAS NOT COVERED BY WARRANTY OR RECALL, EVEN THOUGH I UNDERSTAND THAT CUMMINS ENGINE HAS HAD A PROBLEM WITH OTHER TRUCKS, AND WITH CERTAIN ANTIFREEZE ADDITIVES. MY TRUCK DID NOT FALL UNDER EITHER OF THESE CONDITIONS. *AK

NHTSA ID
716679
Incident
Nov 9, 1999

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

IK-0400107

SERVICE BRAKES

INTERNATIONAL: AFTER LINING CONDITION AND WEAR, FASTENER TORQUE, COMPONENT LUBRICATION HAVE BEEN VERIFIED ON THE BRAKES BECAUSE OF THE CHATTER OR SQUEALING ON THE TRUCKS, A PROCEDURE WILL BE PERFORMED. NO MODEL OR MODEL YEARS ARE LISTED. *PE UPDATED 12/20/13. *PE

G98902

STRUCTURE

SERVICE PROCEDURE FOR FRAME / RIDE IMPROVEMENT. *YC

G97909

ENGINE AND ENGINE COOLING:COOLING SYSTEM

THE ENGINE COOLING FAN CAN CONTACT THE RADIATOR DURING NORMAL DRIVING CONDITIONS RESULTING IN COOLING FAN FAILURE AND POSSIBLE RADIATOR DAMAGE. *YC

971001G96903

STRUCTURE:BODY

SERVICE PROCEDURES ON REPLACEMENT OF PANEL ABOVE PASSENGER SEAT. *YC

970601G97902

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

CONDITIONS REGARDING FAN BELT MISALIGNMENT. *YC

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

International Harvester 9300 by model year
YearComplaintsRecallsInvestigationsIssue Index
2001020—
2000030—
1999130—
1998130—
1997Viewing340—
1996150—
1995030—
1994010—
1993000—
1992010—
1991010—
1989010—
1988020—
1987010—
1985100—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.