RoadVitals

2003 International 4400 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Jan 18, 2010
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
2

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2003 International 4400, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes375.0%
  • Engine125.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

3
reports

From owner reports, verbatim

IT WAS RAINING BRAKES FAILED I REARENDED A CAR ON 8-16-04 AN INTERNATIONAL DEALER FOUND FAULTS IN THE ABS AND NOTHING WAS DONE TO REPAIR THEY FOUND A VALVE RELAY SHORTED TO GROUND OUTPUT PIN SHORTED TO GROUND NOTHING WAS DONE TO REPAIR. *AK REFERENCE NO 10097158 THIS TRUCK MY COMPANY VOULANTEERLY PUT OUT SERVICE BECAUSE IT IS NOT REPAIRED

NHTSA ID 10098891 · filed Nov 15, 2004

THE CONSUMER STATED THAT HE HAS BEEN HAVING PROBLEMS WITH HIS BRAKES. HE STATED THAT WHEN IT IS RAINING THE BRAKES FAILED. HE ALSO STATED THAT ONCE HE WENT STRAIGHT THROUGH A STOP SIGN. THE CONSUMER STATED THAT THIS TRUCK WITH THESE FAULTY BRAKES HAS CAUSED HIM TO HAVE A ACCIDENT. HE SAYS HE TOOK THE TRUCK TO THE DEALER AND WAS TOLD ALL THEY COULD FIND IS WHEN IT RAINS THE RELAY VALVE GETS WET, SO THEY THINK IT IS A SHORT SOMEWHERE. *JB

NHTSA ID 10097158 · filed Oct 19, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

1
report

From owner reports, verbatim

WE'VE HAD TWO ENGINE FAILURES WITH THIS TRUCK. THE FIRST OCCURRED AT 121,000 MILES WHEN AN O-RING ON A CYLINDER SLEEVE FAILED LETTING COOLANT FILL THE CRANKCASE AND REQUIRING A COMPLETE ENGINE OVERHAUL THAT COST US OVER $6,000 DOLLARS. THE TRUCK WAS MORE THAN 3 YEARS OLD SO WE HAD TO PAY FOR THE REPAIRS. AFTER PUTTING ONLY 40,000 MILES ON THE REBUILT ENGINE IT HAS THROWN A ROD OUT THE SIDE OF THE BLOCK COMPLETELY RUINING THE ENGINE. IT WILL HAVE TO BE REPLACED AT AN ESTIMATED COST OF $16,000. WE HAVE CONTACTED NAVISTAR BECAUSE THE SERVICE TECHNICIAN SAID BOTH FAILURES WERE CAUSED BY POOR WORKMANSHIP, DEFECTIVE MATERIALS, OR FAULTY DESIGN. NAVISTAR HAS REFUSED TO STAND BEHIND THEIR PRODUCT. *TR

NHTSA ID 10300120 · filed Jan 18, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .