2001 Isuzu Vehicross

RIGHT POWER WINDOW STARTED TO MALFUNCTION, WINDOW GLASS GOING DOWN AND UP MISALIGNED. EMISSIONS OF STRONG FUEL ODOR WHENEVER THE VEHICLE IS PARKED AND THE ENGINE TURNED OFF. THIS IS A ROUGHLY 33K MILE VEHICLE, AND CAREFULLY MAINTAINED. THE "ISUZU RODEO SPORT SAFETY RECALL CONCERNING FUEL SYSTEMS" CAN BE ATTRIBUTED TO THIS SAME PROBLEM AS THEY SHARE THE SAME/MOST MECHANICAL FEATURES AND FACTORY EQUIPMENTS. *TR

NHTSA ID

10478820

Incident

Oct 1, 2012

Mileage

32,418 mi

IN RAPID SUCCESSION I NOTICED THE FAILURE OF MY TURN SIGNALS, MY CRUISE CONTROL, MY POWER WINDOWS AND MY ELECTRONICALLY CONTROLLED AUTOMATIC TRANSMISSION (SHIFTING FROM 1ST TO 2ND IS ROUGH). IN RESEARCHING THIS ON THE VEHICROSS. INFO FORUMS WEBSITE, I READ WHERE OTHER OWNERS HAD THE SAME PROBLEMS AND TRACED THEM TO ELECTRICAL WIRING FRAYED WHEN IT PASSED THROUGH COMPARTMENTS WITHIN THE VEHICLE. *TR

NHTSA ID

10446181

Incident

Dec 9, 2011

Mileage

101,658 mi

TL*THE CONTACT OWNS A 2001 ISUZU VEHICROSS. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN THE ANTI-LOCK BRAKE SYSTEM INDICATOR LIGHT WAS ILLUMINATED. THE ABS LIGHT THEN BEGAN TO ILLUMINATE INTERMITTENTLY. THE VEHICLE WAS TAKEN TO TWO AUTHORIZED DEALERSHIPS WHERE THE CONTACT WAS INFORMED THAT THE ABS MODULE NEEDED TO BE REPLACED AT HIS EXPENSE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000. THE CURRENT MILEAGE WAS APPROXIMATELY 60,000.

NHTSA ID

10324514

Incident

Jan 29, 2010

Mileage

55,000 mi

DRIVERS SIDE WINDOW SLOWS, TILTS FORWARD, AND WILL NOT CLOSE ALL THE WAY. *JB

NHTSA ID

10170256

Incident

Oct 9, 2005

Mileage

25,000 mi

I OWN A 2001 ISUZU VEHICROSS AND WOULD LIKE ISUZU TO OWN UP TO A DESIGN FLAW. I HAVE HAD THIS FIXED 3 TIMES WHILE UNDER WARRANTY AND THE PROBLEM COMES RIGHT BACK SOON AFTER THEY REPLACE THE "WINDOW REGULATOR". AT THE MOMENT BOTH OF MY WINDOWS ARE UNABLE TO ROLL UP WITHOUT MY ASSISTANCE. THIS IS A MAJOR PROBLEM IN THE COLD OF ALASKA AS IF I NEED TO ROLL MY PASSENGER WINDOW DOWN I NEED TO LEAN INTO THE PASSENGER SEAT IN ORDER TO ROLL IT UP AND I FIND MYSELF DOING THIS AT UNWANTED/UNSAFE TIMES DUE TO THE COLD. ALSO IF A FRIEND IS IN THE CAR THEY TEND TO SMASH THEIR FINGERS IN THE WINDOW WHEN PULLING IT UP. I AM SICK OF ISUZU SAYING THERE IS NOTHING WRONG WITH IT.... IT IS OBVIOUSLY A DESIGN FLAW AS EVERY VEHICROSS I HAVE EVER SEEN HAS HAD THE SAME PROBLEM!!!!!!!!! AND AS FOR THE INCIDENT DATE THIS HAS HAPPENED FIVE TIMES (SINCE DATE I SAID WAS THE INCIDENT) SO THERE IS NOT JUST A SINGLE INCIDENT. *JB

NHTSA ID

10145142

Incident

Dec 1, 2001

Mileage

30,000 mi

I OWN TWO 2001 ISUZU VEHICROSS'S. I BOUGHT THEM USED 1 AND 2 YEARS AGO, RESPECTIVELY. MY FIRST ONE WAS PURCHASED WITH 11,000 MILES ON IT, AND THE SECOND ONE WITH 36,000 MILES ON IT. UPON PURCHASE OF MY FIRST ONE, THE POWER WINDOW MECHANISM ON BOTH SIDES HAD TO BE REPLACED DUE TO A FAILURE OF THE TRACK ALIGNMENT. I'M SEEING SIMILAR ISSUES WITH MY SECOND VEHICROSS AS WELL. MY FIRST VEHICROSS WAS FIXED BY A DEALER, UNDER WARRANTY, ON FOUR SEPARATE OCCASIONS. AFTER THE WARRANTY RAN OUT, THE ISSUE AGAIN PRESENTED ITSELF, AND I HAD TO PAY OVER $600 TO GET THE ISSUE FIXED. EVEN THEN, THE ISSUE REAPPEARED AFTER ONLY A FEW MONTHS. MY SECOND VEHICROSS HAS THE SAME EXACT ISSUES WITH THE WINDOW BINDING, AND TRACK MISALIGNMENT, CAUSING THE MOTORS TO WEAR. UPON COMING IN CONTACT WITH AN ORGANIZATION OF SEVERAL HUNDRED VEHICROSS ENTHUSIASTS I DISCOVERED THAT THIS TYPE OF WINDOW FAILURE IS EPIDEMIC WITH THIS MODEL CAR. SOME OF THE OWNERS HAVE HAD MULTIPLE FAILURES -- I.E., THE WINDOWS HAVE BEEN FIXED ONLY TO FAIL AGAIN, SOMETIMES THREE OR FOUR TIMES. I HAVE CONTACTED ISUZU BUT THEY DENY THERE IS A PROBLEM. ON THE OTHER HAND I UNDERSTAND THERE ARE OFFICIAL DOCUMENTS BY ISUZU THAT DO RECOGNIZE THIS PROBLEM. SINCE THERE WAS A LIMITED DISTRIBUTION OF THIS PARTICULAR MODEL CAR -- SOMEWHERE IN THE AREA OF 4000 PLUS OVER A FOUR YEAR PERIOD -- IT APPEARS THE WINDOW FAILURE RATE IS A HIGH PERCENTAGE OF THAT TOTAL NUMBER. I WOULD ASK THAT THE DEPARTMENT INVESTIGATE THIS PROBLEM, INCLUDING INVESTIGATION OF THE INTERNAL ISUZU DOCUMENT MENTIONED ABOVE. IF THERE IS, AS IT APPEARS, A DESIGN FLAW IN THE WINDOW MECHANISM, THEN THERE ARE HUNDREDS OF VEHICROSS OWNERS WHO HAVE IMPROPERLY BEEN CHARGED TO REPAIR IT, SOMETIMES MULTIPLE TIMES. *JB

NHTSA ID

10145131

Incident

May 1, 2004

Mileage

11,000 mi

I OWN A 2001 VEHICROSS BY ISUZU. THE PASSENGER SIDE WINDOWIS STARTING TO BIND AS IT GOES UP TO CLOSE PUTTING A SEVERE STRAIN ON THE WINDOW MECHANISM. UPON COMING IN CONTACT WITH AN ORGANIZATION OF SEVERAL HUNDRED VEHICROSS ENTHUSIASTS I DISCOVERED THAT THIS TYPE OF WINDOW FAILURE IS EPIDEMIC WITH THIS MODEL CAR. SOME OF THE OWNERS HAVE HAD MULTIPLE FAILURES -- I.E., THE WINDOWS HAVE BEEN FIXED ONLY TO FAIL AGAIN, SOMETIMES THREE OR FOUR TIMES. AT THE MOMENT I HAVE 39000 MILES ON THE CAR AND NOW THE PASSENGER'S SIDE WINDOW IS BEGINNING TO FAIL. ISUZU DENNIES THERE IS A PROBLEM. ON THE OTHER HAND I UNDERSTAND THERE ARE OFFICIAL DOCUMENTS BY ISUZU THAT DO RECOGNIZE THIS PROBLEM. SINCE THERE WAS A LIMITED DISTRIBUTION OF THIS PARTICULAR MODEL CAR -- SOMEWHERE IN THE AREA OF 4000 PLUS OVER A FOUR YEAR PERIOD -- IT APPEARS THE WINDOW FAILURE RATE IS A HIGH PERCENTAGE OF THAT TOTAL NUMBER. I WOULD ASK THAT THE DEPARTMENT INVESTIGATE THIS PROBLEM, INCLUDING INVESTIGATION OF THE INTERNAL ISUZU DOCUMENT MENTIONED ABOVE. IF THERE IS, AS IT APPEARS, A DESIGN FLAW IN THE WINDOW MECHANISM, THEN THERE ARE HUNDREDS OF VEHICROSS OWNERS WHO HAVE IMPROPERLY BEEN CHARGED TO REPAIR IT, SOMETIMES MULTIPLE TIMES AND IT LOOKS LIKE I WILL BE JOINING THEIR RANKS.

NHTSA ID

10127712

Incident

Jul 6, 2005

Mileage

39,200 mi

BOTH POWER WINDOWS FAILED WITHIN A WEEK OF EACH OTHER. WINDOW WOULD JAM AND COME OUT OF THE TRACK WHEN ATTEMPTING TO RAISE FROM A DOWN POSSITION.

NHTSA ID

10127378

Incident

May 6, 2005

Mileage

48,465 mi

This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The Exchange Program must be used when any Alpine radio or other component covered by this bulletin is repaired under warranty and may also be used for radio and component repairs not covered under warranty. Contact Alpine directly for pricing and payment methods applicable to radio and component repairs not covered under warranty.

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback. This bulletin was revised to add a Parts Warranty Form

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback.

The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. A TAC case number will be issued solely for information tracking purposes and future contact reference.

The following is a list of the Isuzu-recommended Threebond product part numbers identified in the various Isuzu Workshop Manuals and bulletins. If a Threebond product is unavailable, we recommend that you utilize the chart below to find equivalent of similar products (when available) from Loctite and Permatex.

THROTTLE BODY MOUNTING BOLT TORQUE SPECIFICATIONS. *TT