RoadVitals

2004 Itasca Sunrise Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Jun 27, 2022
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Oct 6, 2005

What this page shows

Our database holds 3 NHTSA owner-reported complaints for the 2004 Itasca Sunrise. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–3 of 3

Body & structureVisibility
Filed Jun 27, 2022

The windshield Carrier (frame) that the windshield sits in rusts out causing the windshield to NOT remain secure the carrier. This can be inspected upon request. I have found online, Many complaints about this issue. The safety factor is, the windshield could become loose or crack while traveling. I am not aware if this has been confirmed by a dealer. At this point, I have not had it inspected but I did have this issue fixed twice to the tune of about $1500.00. Each time this was fixed, it only lasted several years. Last time I had it addressed, I was told that it wouldn't last and that I would need to replace the Carrier or at least the rusted out sections. The warning signs were the water from the rain leaking from above the windshield to the inside of my dash.

NHTSA ID
11471092
Incident
Jun 26, 2022
Brakes
Filed Sep 28, 2010

TL*THE CONTACT OWNS A 2004 ITASCA SUNRISE. WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKES SUDDENLY LOCKED UP AND THE VEHICLE WOULD ONLY MOVE AT A VERY LOW SPEED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE AND PARKED. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN RECALL 09V110000 (SERVICE BRAKES, HYDRAULIC) BUT WHEN HE ATTEMPTED TO CALL THE MANUFACTURER, HE WAS UNABLE TO REACH A REPRESENTATIVE. THE CONTACT CALLED THE AUTHORIZED DEALER WHO STATED THAT THE PARTS FOR REPAIR WERE UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 14,000.

NHTSA ID
10358029
Incident
Sep 24, 2010
Mileage
14,000 mi
Electrical
Filed Oct 6, 2005

FUEL GAUGE WAS NOT WORKING WHEN WE TEST DROVE THE VEHICLE. FOUND OUT AFTER PURCHASE THAT THE WIRING HARNESS AND FUEL LINES WERE CRUSHED WHEN THE VEHICLE WAS MANUFACTURED. THE VEHICLE HAS BEEN IN FOR FIVE MORE REPAIR ATTEMPTS TO CORRECT ELECTRICAL FAILURES IN THE VEHICLE AND AT THIS TIME IT IS NOT CORRECTED. AT THIS TIME, WHILE WE ARE DRIVING DOWN THE ROAD THE VEHICLE'S ELECTRONICS STARTS SHUTTING DOWN. WE HAVE OTHER ELECTRICAL FAILURES THROUGHOUT THE COACH AS WELL. ORIGINALLY THE WIRING HARNESS WAS BEING SPLICED WHEN THEY FOUND SECTIONS THAT HAD MELTED TOGETHER. THE LAST REPAIR THERE WAS A NEW WIRING HARNESS INSTALLED, BUT IT HAD TO BE SPLICED AS WELL BECAUSE THE SERVICE TECHNICIAN COULD NOT REACH THE ENTIRE WIRING DUE TO IT BEING COVERED. THE FUEL LINES HAD A RECALL AND THEY WERE FIXED. THE SECOND SAFETY ITEM THAT HAS NOT BEEN ABLE TO BE REPAIRED IS THE ENGINE COVER INSIDE THE VEHICLE. IT COMES LOOSE WHEN YOU HIT A SOUTHERN WIND FLOW AND SHIFTS TOWARDS THE DRIVER. THE PASSENGER HAS TO SIT SIDEWAYS IN THERE SEAT AND HOLD THE COVER IN PLACE WITH THERE FEET OR FIND SOMETHING SMALL AND HEAVY TO PLACE ON THIS COVER TO PREVENT IT FROM COMING LOOSE. WINNEBAGO AND WORKHORSE WANTS TO KEEP REPAIRING THIS VEHICLE INSTEAD OF TAKING IT OFF THE ROAD. *JB

NHTSA ID
10138911
Incident
May 15, 2004
Mileage
1,885 mi

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .