RoadVitals

2004 Jayco Designer Legacy Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Newest Oct 9, 2003
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

1 campaign cover this model year — what the defect is, what it could cause, and what the remedy is

03V383000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Oct 9, 2003
6,442 units potentially affected
The defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
The risk: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
The remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR JAYCO AT 1-574-825-0608.
JAYCO, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA04019ClosedEngineering Analysis

WHEEL SEPARATIONS

Opened Jul 2, 2004
Closed May 19, 2005

JAYCO IS CONDUCTING CAMPAIGN 04V-364 TO ADDRESS 742 VEHICLES EQUIPPED WITH SIX LUG ALUMINUM WHEELS.ODI IS INITIATING A RECALL QUERY TO FURTHER INVESTIGATE VEHICLES EQUIPPED WITH EIGHT LUG ALUMINUM WHEELS SINCE THESE VEHICLES EXHIBIT A SMALL BUT PERSISTENT RATE OF WHEEL SEPARATIONS.

WHEELSLed to recall 04V364000
PE04016ClosedPreliminary Evaluation

WHEEL SEPARATION

Opened Feb 18, 2004
Closed Jul 2, 2004

IN RESPONSE TO ODI'S JUNE 1, 2004 PE INQUIRY,JAYCO ADVISED ODI OF 58 WHEEL SEPARATION INCIDENTS THAT HAVE OCCURRED IN JAYCO PRODUCTS.THREE (3) ARE MODEL YEAR 2002-2003 TRAVEL TRAILERSAND FIFTY-FIVE (55) ARE MODEL YEAR 2001-2004 FIFTH WHEEL TOWABLE RVS EQUIPPED WITH ALUMINUM WHEELS.JAYCO HAS ALSO ADVISED ODI THAT AN ADDITIONAL TWO (2) WHEEL SEPARATIONS OCCURRED DURING JUNE, 2004, FOR AN OVERALL TOTAL OF SIXTY. ODI CONDUCTED A FIELD INSPECTION OF THE JAYCO VEHICLE THAT LOST A WHEEL ON JUNE 11, 2004.THE INSPECTION FOUND EVIDENCE OF COATING MATERIAL BETWEEN THEHUB AND WHEEL MOUNTING FACES.FOREIGN MATERIAL SUCH AS COATINGS IN THE WHEEL MOUNTING JOINT CAN COMPROMISE THE ABILITY OF THE NUTS TO MAINTAIN CLAMP AND LEAD TO NUT LOOSENING AND/OR STUD BREAKAGE AND COULD RESULT IN A WHEEL SEPARATION.A WHEEL THAT SEPARATES FROM A VEHICLE AT HIGHWAY SPEEDS POSES A HAZARD TO OTHER USERS OF THE ROADWAY AND CAN AFFECT THE STABILITY AND SAFETY OF THE AFFECTED RV.THIS PE IS BEING UPGRADED TO AN ENGINEERING ANALYSIS FOR FURTHER INVESTIGATION.

WHEELS

Elsewhere on this vehicle

Data sources