1997 Jeep Wrangler Problems

RIGHT AFTER I BOUGHT THE JEEP I STARTED HAVING PROBLEMS BUT WHEN I CALLED THE OWNER HE SAID ITS A BUY AS IS, NO WARRANTY, HE DIDN'T OFFER TO HELP WITH ANYTHING AND BEING DISABLED I HAD NO OTHER CHOICE BUT TO GET ENGINE FIXED, TRANSMISSION, CLUTCH, THE ENTIRE ELECTRIC SYSTEM, NO AC, NO HEAT OR DEFROST EITHER ALL THESE THINGS I FIXED BUT NOW AGAIN IN 2020 I STILL HAVE NO HEAT, NO DEFROST, JEEP IS IN YARD NOT RUNNING AND I STILL OWE RIGHT AT 900 ON THE JEEP, THE OWNER HAS BEEN VERY RUDE, MADE THREATS, AND NOW NOT TAKING MY FINAL 3 PYMTS ON JEEP, NEVER BEEN LATE, EVER!!!! HE RUNS A SHADY BUY HERE PAY HERE LOT AND I HAVE A TOP MECHANIC THAT LEFT HIS BUSINESS TO VOUCH FOR THE ODOMETER TAMPERING AS WELL AS HAVING THE MECHANIC TO FIX ALL THE LIGHTS ON PANEL THAT SHOWED ENGINE RUNNING HOT, HE TOLD THE MECHANIC TO FIX IT OR HE WAS NOT GETTING HIS PAY CHECK, I HAVE THE MECHANICS STATEMENT AND HE WILL TESTIFY IN PERSON. I HAVE SEVERAL EMPLOYEES THAT HAVE SINCE QUITE TO VOUCH HE SOLD LEMONS, AND SALVAGED CARS. HE LOST HIS DMV LICENSE BUT STILL CONTINUES TO FRAUD PEOPLE.

WHEN COLD, JEEP STARTS AND RUNS FINE. AFTER ENGINE WARMS UP, OIL PRESSURE WOULD DROP AND JEEP WOULD ALMOST DIE. IF I SHUT IT OFF AND TRY TO RESTART WHILE STILL WARM, JEEP WOULD HAVE A HARD TIME STARTING AND IF IT DID START, IT WOULD IDLE EXTREMELY ROUGH AND BARELY ACCELERATE. ONCE I GOT SPEED UP, IT RAN FINE UNTIL I STOPPED AT A RED LIGHT AND IT WOULD ACT LIKE IT WAS GOING TO DIE AND THE OIL PRESSURE GAUGE WOULD BOTTOM OUT. DEALER PUT MANUAL GAUGES ON IT AND DETERMINED IT WAS THE OIL SENDING UNIT. OIL PRESSURE NOW HOLDS AT 20 WHEN AT IDLE. THE ISSUE WITH THE ROUGH IDLE AND LOSS OF POWER STILL PERSISTS AFTER THE ENGINE WARMS UP. AFTER READING ALL OF THE COMPLAINTS, THIS SEEMS TO BE A RECURRING ISSUE WITH THIS MODEL. REALLY DON'T WANT TO WASTE MONEY TRYING TO GUESS AT WHAT IS THE ISSUE. AS MANY PEOPLE THAT THERE ARE HAVING SIMILAR ISSUES, JEEP SHOULD STAND BEHIND THEIR PRODUCT AND ISSUE A RECALL. VERY DISAPPOINTED.

FUEL GUACHE GOVEA INACCURATE READING AND DROPS TO EMPTY WHEN THE TANK IS HALF FULL. CONTACTED THE LOCAL JEEP DEALER TWICE ON HAVING THIS PART REPLACED AND EACH TIME THEY TELL ME THEY WILL CALL ME BACK BUT THEY HAVE NOT.

I EXPERIENCED SUDDEN ACCELERATION WHEN AT A COMPLETE STOP WITH FOOT ON BREAK. THROTTLE WENT VERY HIGH AND PROPELLED CAR FORWARDED EVEN WHEN PUSHING THE BREAKS PENAL DOWN AS HARD AS I COULD. THERE IS NO WAY I PUSHED DOWN ON THE WRONG PEDAL. THE BREAKS COULD NOT HOLD THE CAR STOPPED. THIS IS EXTREMELY DANGEROUS!

TL* THE CONTACT OWNS A 1997 JEEP WRANGLER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 97V080000 (AIR BAGS). THE AIR BAG WARNING INDICATOR ILLUMINATED AND THE CONTACT WAS CONCERNED THAT THE AIR BAG MIGHT DEPLOY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO GANLEY VILLAGE CHRYSLER DODGE JEEP RAM FIAT (2115 MENTOR AVE, PAINESVILLE, OH 44077, (440) 354-4358) WHERE IT WAS DIAGNOSED, BUT THE PART WAS NOT AVAILABLE FOR THE REPAIR. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 196,000. PARTS DISTRIBUTION DISCONNECT.

BOUGHT A JEEP WRANGLER AND FOUND TWO OUTSTANDING RECALLS #97V-808 AND 974-194.THE LATER ONE THEY FOUND PARTS FOR . THE AIRBAG MODULE THEY SAY THE PART IS DISCONTINUED AND THEY CAN'T ADDRESS THE RECALL DUE TO PART UNAVAILABLE. MOPAR SAYS THERE ARE PARTS AVAILABLE ??

MY VEHICLE HAS RUN ROUGH, IDLING ROUGH, "BUCKING", LOSING COOLANT AND DRIPPING FROM THE TAILPIPE ABOUT A WEEK AFTER THE EXTENDED WARRANTY EXPIRED. I HAVE HAD MAJOR VALVE TRAIN PROBLEMS AND HAD TO HAVE THE CAMSHAFT REPLACED ALONG WITH THE GASKET, CYLINDER HEAD, CORE RETURN, RADIATOR AND NOW THE LATEST IS OIL PRESSURE GAUGE SENDING UNIT. OIL PRESSURE STILL SHOWING ZERO EVEN AFTER REPLACING SENDING UNIT! *AK

THE CLUTCH PEDAL QUIT WORKING AND THE THROW OUT BEARING WAS BROKEN. *PH *JB

THE SEATBELTS IN MY CAR DO NOT FASTEN PROPERLY. THERE IS A GAP, NEXT TO THE CLIP, THAT IT GETS STUCK IN DUE TO ITS BAD DESIGN. FOR FEAR OF FAILURE, IN THE EVENT OF AN ACCIDENT, I AM REPLACING ALL OF THEM.

WHEN DRIVING DRIVER'S SIDE SEAT BELT UNLATCHED. CONSUMER NOTIFIED THE DEALERSHIP ABOUT THIS ISSUE. *AK

FRAME WAS ROTTED THROUGH FROM CONTROL ARM TOWARDS THE BACK OF THE VEHICLE. THE VEHICLE BRAKING ABILITY BECAME DIFFICULT AND HARD TO STEER. *TR

WHILE DRIVING MY JEEP ON A PUBLIC ROAD GOING ABOUT 45, THE VEHICLE BEGAN TO SHAKE UNCONTROLLABLY. I HAD TO PULL OVER AND STOP THE VEHICLE IN ORDER FOR THE SHAKING TO STOP. IT WAS INCREDIBLY DANGEROUS, AND I WAS LUCKY THAT I WASN'T INVOLVED IN AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 1997 JEEP WRANGLER. WHILE INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE WHEEL WELL WAS VISIBLY CORRODED. THE VEHICLE WAS TAKEN TO MANAHAWKIN CHRYSLER DODGE JEEP RAM (500 NEW JERSEY 72 WEST, MANAHAWKIN, NJ 08050) WHERE IT WAS DIAGNOSED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COST. THE FAILURE MILEAGE WAS 63,000.

I HAVE OWNED THIS VEHICLE SINCE IT WAS BRAND NEW. IT HAS BEEN GARAGE KEPT FOR APPROX. 20 OF ITS 21YRS. THE REAR FRAME WHERE THE TRAILING ARMS ARE ATTACHED TO THE BRACKETS RUSTED OUT. THE DRIVER SIDE TRAILING ARMS WERE ALMOST READY TO SEPARATE FROM THE FRAME DUE TO THE FRAME RUSTING FROM THE INSIDE OUT. I HAD TO CUT OUT THE SECTION AND REPLACE IT WITH A SAFE T CAP PATCH. CUTTING OPEN THE FRAME SHOWED EXTENSIVE RUST ON THE INSIDE OF THE FRAME. I CHECKED MY PASSENGER SIDE LUCKILY NOT AS BAD AS THE DRIVER SIDE BUT WILL HAVE TO BE REPLACED BECAUSE IT DOES HAVE SIGNS OF RUSTING FROM THE INSIDE OUT IN THE EXACT SAME PLACE. AFTER DOING SOME RESEARCH IT APPEARS THIS IS A COMMON PROBLEM FOR THE JEEP TJ'S. JEEP CUT SEVERAL HOLES IN THE SIDES OF THE FRAME THAT ALLOWED WATER AND DEBRIS ACCESS TO THE INSIDE OF THE FRAME RAIL BUT DID NOT PUT ANT DRAIN HOLES IN THE BOTTOM OF THE FRAME TO ALLOW THE WATER/DEBRIS TO ESCAPE.

AFTER HITTING BUMPS IN THE ROAD THE STEERING SEEMS LIKE IT WOBBLES ENTIRE VEHICLE.

THE REAR OF THE FRAME CAN RUST THROUGH DUE TO LACK OF DRAIN HOLES TO LET WATER AND DEBRIS OUT CAUSING THE REAR CONTROL ARMS TO SEPARATE FROM THE FRAME.

DRIVING DOWN THE ROAD THE REAR UPPER CONTROL ARM BRACKETS SEPARATED FROM THE FRAME AS A RESULT OF THE FRAME CORRODING FROM THE INSIDE OUT. THIS CAUSED THE REAR BRAKE LINE TO BRAKE DRAINING THE MASTER CYLINDER. *TR

FRAME WAS ROTTED THROUGH FROM CONTROL ARM TOWARDS THE BACK OF THE VEHICLE. THE VEHICLE BRAKING ABILITY BECAME DIFFICULT AND HARD TO STEER. *TR

I'M THE ORIGINAL OWNER AND SOLE DRIVER OF A 1997 JEEP WRANGLER WITH 34,000 MILES. I NOTICED THE WINDSHIELD DEFROSTER WASN'T WORKING WHEN I DROVE HOME IN A SNOW STORM LAST WEEK. FORTUNATELY, THE DRIVE WAS A SHORT DISTANCE. *JB I EASILY DETERMINED THAT A PLASTIC BELL CRANK BROKE OFF ITS SHAFT THAT GOES INTO THE HEATER HOUSING. I ACTIVATED THE DEFROSTER CONTROL TO CONFIRM THAT THIS PART IS THE DEFROSTER BELL CRANK. NOTHING HAS FALLEN DOWN THE DEFROSTER DUCT TO JAM THE DOOR AND CAUSE THE BREAK. THE DOOR MOVES FREELY WHEN TURNING THE SHAFT BY HAND. I BELIEVE THE BREAK HAPPENED WHEN THE DEFROSTER WAS ACTUATED DURING MAX HEATER FAN, CAUSING MAX AIR PRESSURE ON THE DEFROSTER DOOR WITH MAX TORQUE ON ITS SHAFT. THE REPAIR ESTIMATE FROM MY LOCAL DEALER IS $855. I HAVE A STRONG SUSPICION THIS IS A COMMON PROBLEM AND DOUBT IF MANY PEOPLE GO TO THIS EXPENSE TO FIX IT. I DONT WANT TO SPEND THIS AMOUNT OF MONEY ON A DEFECT THAT MAY BREAK AGAIN. SINCE DRIVING WITH FROSTED WINDSHIELDS CREATES A CONSIDERABLE SAFETY HAZARD, I THINK A RECALL SHOULD BE INITIATED TO MAKE THIS SYSTEM MORE ROBUST. A WINDSHIELD DEFROSTER SHOULD LAST MUCH LONGER THAN 34,000 MILES.

THE 1997 JEEP WRANGLER HAS A PROBLEM WITH THE HVAC DAMPERS LITERALLY FALLING APART AND BECOMING UNUSABLE. THE PLASTIC ENDS BREAK OFF AND THE ACTUATORS WILL NOT OPERATE THEM. THE PART HAS BEEN UPGRADED BY CHRYSLER SO THEY NOW THIS EXISTS. IT IS A FAIRLY EXPENSIVE REPAIR (OVER $700). MY IS DONE. THE DEALER DID JUST FINE BUT I HAVE ASK CHRYSLER TO MAKE THIS A SAFETY RECALL. THE DEFROSTERS ARE VIRTUALLY NON USABLE WHEN THIS OCCURS. THIS IS A DANGEROUR SITUATION, DRIVING WITH NO DEFROSTERS. THIS PROBLEMS HAS OCCURRED ON MANY WRANGERS AND AS MY DEALER SAID CHEREKEE AS WELL.

BOTH EXTERNAL RUBBER SIDE LATCHES FAILED ON 1997 JEEP WRANGLER. THE HOOD FLIPPED UP AND OBSCURED THE DRIVER'S VISIBILITY. THE HOOD WAS DESTROYED BY ITS IMPACT AGAINST THE ROOF. THIS VEHICLE HAD BEEN MANUFACTURED W/O THE STANDARD INTERNAL LATCH DUE TO SEVERAL PARTS CHANGES DURING THE MANUFACTURING YEAR. AN INTERNAL LATCH COULD NOT BE FITTED TO THE MIS-MATCHED HOOD AND GRILL. *JB

MY HUSBAND WAS REAR-ENDED WHILE DRIVING THE 1997 JEEP WRANGLER. HIS SEAT COLLAPSED BACKWARD DURING THE IMPACT RESULTING IN HITTING HIS HEAD ON THE ROLL BAR AND AN EXAGGERATED FLEXION-EXTENSION OF HIS NECK AND BACK AS HIS THE SUPPORT (THE SEAT) BASICALLY DISAPPEARED. *NM

RIGHT AFTER I BOUGHT THE JEEP I STARTED HAVING PROBLEMS BUT WHEN I CALLED THE OWNER HE SAID ITS A BUY AS IS, NO WARRANTY, HE DIDN'T OFFER TO HELP WITH ANYTHING AND BEING DISABLED I HAD NO OTHER CHOICE BUT TO GET ENGINE FIXED, TRANSMISSION, CLUTCH, THE ENTIRE ELECTRIC SYSTEM, NO AC, NO HEAT OR DEFROST EITHER ALL THESE THINGS I FIXED BUT NOW AGAIN IN 2020 I STILL HAVE NO HEAT, NO DEFROST, JEEP IS IN YARD NOT RUNNING AND I STILL OWE RIGHT AT 900 ON THE JEEP, THE OWNER HAS BEEN VERY RUDE, MADE THREATS, AND NOW NOT TAKING MY FINAL 3 PYMTS ON JEEP, NEVER BEEN LATE, EVER!!!! HE RUNS A SHADY BUY HERE PAY HERE LOT AND I HAVE A TOP MECHANIC THAT LEFT HIS BUSINESS TO VOUCH FOR THE ODOMETER TAMPERING AS WELL AS HAVING THE MECHANIC TO FIX ALL THE LIGHTS ON PANEL THAT SHOWED ENGINE RUNNING HOT, HE TOLD THE MECHANIC TO FIX IT OR HE WAS NOT GETTING HIS PAY CHECK, I HAVE THE MECHANICS STATEMENT AND HE WILL TESTIFY IN PERSON. I HAVE SEVERAL EMPLOYEES THAT HAVE SINCE QUITE TO VOUCH HE SOLD LEMONS, AND SALVAGED CARS. HE LOST HIS DMV LICENSE BUT STILL CONTINUES TO FRAUD PEOPLE.

HORN DOESN'T WORK AND AIRBAG LIGHT IS ON. SHOWING THAT THE AIRBAGS WERE INOPERABLE AS WELL. *TR

NOTICED WOBBLE UNDERNEATH WHILE DRIVING. INSPECTED UNDERNEATH AND NOTICED LIGHT SHOWING BETWEEN TRANSFER CASE SKID PLATE AND FRAME (SHOULD BE TIGHT) AND BOLT HANGING DOWN. TOOK INTO SHOP AND LOWER MID FRAME ON BOTH SIDES IS COMPLETELY RUSTED THROUGH ALLOWING SKID PLATE BOLTS TO FALL OUT WITH NUTS STILL ATTACHED. SKID PLATE ALSO SERVES AS TRANSFER CASE MOUNT AND WHEN IT DROPS THE DRIVESHAFT WOBBLES. ULTIMATELY IF IT HAD COMPLETELY LET GO ON THE HIGHWAY THE REAR DRIVESHAFT WOULD HAVE LOCKED UP AND LOCKED THE REAR WHEELS CAUSING UNCONTROLLED SKID, OR THE DRIVESHAFT WOULD BREAK CAUSING DANGER TO THE PASSENGERS.

I BOUGHT THIS 1997 JEEP WRANGLER FROM A USED CAR DEALER IN JUNE 2002 WITH A LIMITED WARRANTY AND WAS TOLD THE VEHICLE PASED INSPECTION AND HAD NO PROBLEMS. SINCE THEN I HAVE HAD TO HAVE THE WIRING HARNESS REPAIRED, THE FUEL PUMP REPLACED, THE TRANSMISSION REPLACED, IT HAS A FAULTY FUEL GAUGE READING, THE INTAKE AND EXHAUST MANIFOLD NEED TO BE REPLACED AND NOW THE STEERING LINKAGE OR STABILIZER BARS ARE FAULTY.

RIGHT AFTER I BOUGHT THE JEEP I STARTED HAVING PROBLEMS BUT WHEN I CALLED THE OWNER HE SAID ITS A BUY AS IS, NO WARRANTY, HE DIDN'T OFFER TO HELP WITH ANYTHING AND BEING DISABLED I HAD NO OTHER CHOICE BUT TO GET ENGINE FIXED, TRANSMISSION, CLUTCH, THE ENTIRE ELECTRIC SYSTEM, NO AC, NO HEAT OR DEFROST EITHER ALL THESE THINGS I FIXED BUT NOW AGAIN IN 2020 I STILL HAVE NO HEAT, NO DEFROST, JEEP IS IN YARD NOT RUNNING AND I STILL OWE RIGHT AT 900 ON THE JEEP, THE OWNER HAS BEEN VERY RUDE, MADE THREATS, AND NOW NOT TAKING MY FINAL 3 PYMTS ON JEEP, NEVER BEEN LATE, EVER!!!! HE RUNS A SHADY BUY HERE PAY HERE LOT AND I HAVE A TOP MECHANIC THAT LEFT HIS BUSINESS TO VOUCH FOR THE ODOMETER TAMPERING AS WELL AS HAVING THE MECHANIC TO FIX ALL THE LIGHTS ON PANEL THAT SHOWED ENGINE RUNNING HOT, HE TOLD THE MECHANIC TO FIX IT OR HE WAS NOT GETTING HIS PAY CHECK, I HAVE THE MECHANICS STATEMENT AND HE WILL TESTIFY IN PERSON. I HAVE SEVERAL EMPLOYEES THAT HAVE SINCE QUITE TO VOUCH HE SOLD LEMONS, AND SALVAGED CARS. HE LOST HIS DMV LICENSE BUT STILL CONTINUES TO FRAUD PEOPLE.

WHILE STARTING. ENGINE STARTS ACCELERATES AND DIES.

There have been 2 instances of the stem leaking air seemingly out of nowhere on 2 of the 5 tires within a year of installation. Both leaks were noticed after I had finished a drive. The service center we purchased the tires from has repaired 1 of them a few months ago and is currently repairing the second one. They told me that this is a somewhat common problem with this new tire design. 4wheelparts in Waipahu Hawaii can confirm that these repairs were necessary.

1997 JEEP WRANGLER FRONT DRIVER SIDE TIRE SEPARATED FROM THE VEHICLE AND HIT ANOTHER VEHICLE. *KB (OHIO TRAFFIC CRASH REPORT) *JB

DT: ON THE HEADLIGHT PLUG A GREASE WAS USED AND IT DISSOLVED THE INSULATION AROUND THE WIRING AT THE PLUG ,AND BLEW THE FUSE. THIS WAS ON BOTH HEADLIGHTS. DEALER HAD NOT BEEN CONTACTED YET. MANUFACTURER SAID THERE WERE NO RECALLS OR TSBS ON THIS, AND CALLER FILED A COMPLAINT WITH THEM, FILE #13888043.*AK

DRIVERS SEAT BELT COMES UNDONE AT ANY SPEED EVERY TIME YOU DRIVE IT - A FEW TIMES EACH TIME YOU DRIVE IT, REAR CENTER MOUNTED TAIL LIGHT DOES NOT WORK, TAILGATE HINGES ARE EXTRREMELY DIFFICULT TO SHUT CAUSING THE TAILGATE TO NOT BE CLOSED PROPERLY ALL THE TIME, FRONT TURN SIGNAL SOMETIMES DOES NOT WORK, ESPECIALLY IF IT IS WET OUT- DEALER NOTIFIED AND WAS TOLD THAT THEY CANNOT REPLACE THE SOCKET (NOT A STOCK ITEM), THE BULBS ARE FINE IN THE BRAKE LIGHT AND TURN SIGNAL. *AK

STANDARD STEEL WHEELS HAVE CORRODED AND ONE HAS STARTED TO LEAK AIR. METAL REMAINING ON OTHER WHEELS HAVE ALSO DETERIORATED TO A POINT THAT THEY MAY FAIL. NO INDICATION OF FAILURE IS EVIDENT TO THE DRIVER. WHEEL COULD RUPTURE AND FAIL CAUSING LOSS OF CONTROL TO STEERING. 15X7 STEEL * 5 BOLT ON 4.5BOLT PATTERN BACKSPACING = 5.5 OFFSET = +38 MM. *KB

1997 JEEP WRANGLER FRONT DRIVER SIDE TIRE SEPARATED FROM THE VEHICLE AND HIT ANOTHER VEHICLE. *KB (OHIO TRAFFIC CRASH REPORT) *JB

A/C EVAPORATOR LEAK, REPLACED BY DEALER. *AK

A/C FAILED. YH