2000 Jeep Wrangler Electrical Problems

WHILE DRIVING DOWN THE ROAD, SPEED DOESN'T MATTER BC IT HAS HAPPENED AT MULTIPLE SPEEDS, THE SPEEDOMETER AND TACHOMETER WILL DROP TO NOTHING, WHILE THE OTHER GAUGES LIKE GAS, OIL PRESSURE, TEMPERATURE AND SUCH DO NOT HAVE ANY ISSUES AND REMAIN WHERE THEY SHOULD BE! A FEW SECONDS AFTER THE SPEEDOMETER AND TACHOMETER DROP, THE ENGINE LIGHT COMES ON AND THE ODOMETER WILL READ 'NO BUS', A FEW SECONDS TO A MINUTE LATER THE GAUGES WILL RESUME AND THE ENGINE LIGHT AND 'NO BUS' DISAPPEAR! ANOTHER EXAMPLE OF THIS IS THE SPEEDOMETER AND TACHOMETER WILL DROP AND OTHER GAUGES NOT BE AFFECTED LIKE PREVIOUS SCENARIO ONLY WITH THIS ONE THE AIRBAG LIGHT WILL ILLUMINATE, LASTS FOR A BRIEF PERIOD AND THEN GOES BACK TO NORMAL! IT HAPPENS SPORADICALLY, BUT HAVE NOTICED IT HAPPENS MORE ON BUMPY ROADS! NONE OF THIS HAS HAPPENED WHILE THE VEHICLE IS STATIONARY AT IDLE! ALL WHILE DRIVING DOWN THE ROAD, VARIOUS SPEEDS, VARIOUS TYPES OF ROADWAYS!

NHTSA ID

11348742

Incident

Aug 11, 2020

Mileage

171,150 mi

OVER HEATING OF A/C - HEATER CONTROL SWITCH WHILE IN USE CAUSED THE SWITCH CONNECTOR, SWITCH AND PART OF THE HVAC CONTROL PANEL TO MELT. ON THE VERGE OF FIRE THE FAN STOPPED FUNCTIONING. RETRIEVED THE SAME UNIT OFF A DONER VEHICLE [1J4FA59S3YP733181] AND FOUND THE CONTROL TO BE MELTED/BURNT IN THE SAME FASHION. WHEN I LOOKED FOR A REPLACEMENT, THE PARTS SUPPLIERS OFFERED A READY-MADE REPLACEMENT WIRE HARNESS [POTENTIAL CLUE OF COMMON FAILURE]. THE MOPAR REPLACEMENT PART IS LISTED AS DISCONTINUED. I HAVE TAKEN PHOTOS OF THE ISSUES DESCRIBED, BUT WILL HAVE TO GET THEM DEVELOPED AND DIGITIZED [MY DIGITAL CAMERA WON'T TAKE CLOSE-UP PICS].

NHTSA ID

11053803

Incident

Nov 5, 2017

Mileage

53,500 mi

2000 JEEP WRANGLER. THE WIRING TO THE A/C CONTROL SWITCH SHORTS OUT AND CAUSES A MINOR FIRE. THE SWITCH HAS BEEN REPLACED AND IT HAPPENED AGAIN. THERE WAS EVIDENCE OF A PREVIOUS FIX IN SPLICED WIRING. THE WIRING HARNESS IS NO LONGER AVAILABLE. RESEARCH ON JEEP RELATED WEB SITES HAS PROVEN TO ME THAT THIS IS NOT AN ISOLATED INCIDENCE AND OCCURS IN MANY OF THE SURROUNDING MODEL YEARS. THERE IS A DESIGN FLAW IN THE THREE POSTS THAT CONNECT TO THE SELECTOR SWITCH, THEY ARE TO CLOSE TO EACH OTHER. *TR

NHTSA ID

10373803

Incident

Dec 1, 2010

Mileage

145,000 mi

MODE SELECTOR FOR THE HVAC SYSTEM HAS A MAJOR ISSUE MELTING THE SELECTOR, HARNESS AND CONTROL MODULE. AFTER RESEARCHING THIS INCIDENT ONLINE AND TO MY SURPRISE THERE IS NO RECALL ON THIS SUBJECT. HEATER NOT WORKING, POSSIBLE HEATER SYSTEM CATCHING ON FIRE DO HI VOLTAGE TO THE MODE SELECTOR WITCH CAUSES ENTIRE HVAC FAILURE AND POSSIBLE FIRE. JEEP HAS KNOWN ABOUT THIS FOR A WHILE BUT NO ONE SEEMS TO BE GETTING ON THEM ABOUT IT. AGAIN 2000 JEEP WRANGLER HEATER CONTROL FAILURE. *TR

NHTSA ID

10371872

Incident

Dec 20, 2010

Mileage

65,000 mi

TL*THE CONTACT OWNS A 2000 JEEP WRANGLER. WHILE DRIVING 30 MPH, THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL THEN BOTH THE SPEEDOMETER AND RPM GAUGE DROPPED TO 0. AFTER ONE MINUTE, THE GAUGES BEGAN FUNCTIONING CORRECTLY AND THE AIR BAG LIGHT TURNED OFF. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BUT THE MECHANIC COULD NOT DIAGNOSE THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE WAS INTERMITTENT. THE FAILURE MILEAGE WAS 67,750 AND THE CURRENT MILEAGE WAS 67,900. THE CONSUMER STATED NO LONGER OWNS THE VEHICLE. UPDATED 12/30/10

NHTSA ID

10359451

Incident

Sep 29, 2010

Mileage

67,750 mi

HVAC WIRING HARNESS AND SWITCH MELTED DUE TO FAULTY BLOWER MOTOR COMPOUNDED BY INADEQUATE SIZE WIRE. CHRYSLER DOES NOT EVEN SELL A REPAIR KIT EVEN THOUGH THERE ARE NEW CASES CONSTANTLY ON THE WRANGLER TJ ON INTRANET FORUMS. SOME ARE EVEN VEHICLE CATCHING FIRE. *TR

NHTSA ID

10295529

Incident

Nov 12, 2009

INSTRUMENT CLUSTER WILL INTERMITTENTLY GO OUT, LEAVING NO SPEEDOMETER, ODOMETER, OR RPM GAGE. THIS CAN GO OUT FOR SEVERAL MILES, OR JUST BLINK ON AND OFF. IT HAS BEEN DOING THIS FOR A COUPLE OF YEARS, AND HAVE ALREADY ATTEMPTED TO HAVE IT FIXED ONCE BY A DEALERSHIP AND SEVERAL TIMES WITH MY SON WORKING ON IT. SO FAR NOTHING HAS CORRECTED THE PROBLEM. DEALERSHIP KNEW WHAT THE PROBLEM WAS WHEN FIRST BROUGHT TO THEM ABOUT 2 1/2 YEARS AGO BUT COULD NOT FIX THE PROBLEM. BEING ON THE COMMUNITY EMERGENCY RESPONSE TEAMS, I NEED A RELIABLE VEHICLE. *JB

NHTSA ID

10199968

Incident

May 11, 2004

Mileage

70,543 mi

CONSUMER PURCHASED A 2000 JEEP WRANGLER AND WAS INFORMED THAT BRAKES WERE NEW AND IN GOOD CONDITION. UPON PUTTING VEHICLE IN PARK PARKING BRAKE DID NOT HOLD AND HAD TO BE ADJUSTED. *TS THE CONSUMER STATED HE WAS INVOLVED IN AN ACCIDENT WHEN HE ATTEMPTED TO APPLY THE BRAKES, BUT THE VEHICLE DIDN'T STOP. THE FRONT PINION SEAL WAS REPLACED AND THE BATTERY WAS REPLACED BECAUSE IT WAS LEAKING. *JB

NHTSA ID

10154092

Incident

Dec 6, 2005

DT: YESTERDAY THE AIR BAG LIGHT CAME ON I AND THE HORN STOPPED WORKING. I WAS NOT UNDER RECALL, DEALER GOING TO CHARGE CONSUMER FOR REPAIRS. LAST WEEK THE SAME THING HAPPENED WITH DODGE CARAVAN. THEY WERE BOTH CHRYSLER PRODUCTS ,AND THE DODGE HAD A RECALL. HOWEVER THE JEEP DID NOT. *AK

NHTSA ID

10126261

Incident

Jun 21, 2005

Mileage

54,000 mi

WHILE VEHICLE WAS PARKED AND WITHOUT WARNING CONSUMER SAW SMOKE UNDER HOOD. LIFTED HOOD AND SAW A FIRE ON TOP OF ENGINE. DEALER WAS NOTIFIED .MECHANIC KEPT VEHICLE FOR ABOUT 5 DAYS; HOWEVER, WAS UNABLE TO REPAIR VEHICLE.*AK

NHTSA ID

8012756

WHILE VEHICLE WAS PARKED AND WITHOUT WARNING IT CAUGHT ON FIRE. THIS WAS THE SECOND JEEP, WRANGLER THAT HAD CAUGHT ON FIRE. VEHICLE WAS TOTALED. *AK

NHTSA ID

8010337

VEHICLE WAS CUTTING OFF WHILE IN 1ST GEAR WITH PARKING BRAKE ON. HALF AN HOUR LATER, CONSUMER HEARD A DOOR BANG, VEHICLE HAD HIT HOUSE, AND CAUGHT ON FIRE. CONSUMER FELT VEHICLE STARTED ON ITS OWN. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK

NHTSA ID

8006665

Incident

Mar 28, 2002

THE CONSUMER SMELLED LED BURNING/ PLASTIC PRIOR TO STOPPIN, THE FIRE ORIGINATED IN THE POWER DISTRIBUTION BOX. CLAIM NUMBER 17-9135-135. *YH

NHTSA ID

6900781

Incident

Jul 12, 2000

THE CONSUMER'S VEHICLE REAR BOLT FELL OFF OF THE REAR STABILIZER TWICE. FIRST, DUE TO MANUFACTURER DEFECT, AND SECOND DUE TO MECHANIC'S FAULT RESULTED IN LOSS OF CONTROL, WHICH WAS ALMOST FATAL. *YH

NHTSA ID

561289

AN UNDER HOOD FIRE WHILE TRAVELING. VEHICLE AT DEALER FOR INSPECTION. CAUSES HAVE NOT BEEN DETERMINED AT THIS TIME. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK

NHTSA ID

879919

Incident

Jan 31, 2001

WHILE THE VEHICLE WAS PARKED, THE HORN SOUNDED ON ITS OWN ACCORD, AND CONTINUED FOR OVER 6 HOURS UNTIL THE BATTERY RAN DOWN. WHEN I JUMP STARTED THE VEHICLE, THE HORN STARTED AGAIN, THEN STOPPED. SEVERAL MILES LATER, IT WENT OFF AGAIN, AND DIDN'T STOP UNTIL I DISCONNECTED IT. THE JEEP REPAIR TELLS ME THAT THERE IS A NATIONAL BACK ORDER ON THIS PART. DOESN'T THAT WARRANT A RECALL?*AK

NHTSA ID

737409

Incident

Dec 3, 2000

UPON STARTING OF VEHICLE AFTER FUELING A 'POP' WAS HEARD FROM THE ENGINE COMPARTMENT AND ENGINE STALLED. RESTARTED ENGINE WITH NO DIFFICULTY AND ENCOUNTERED A HIGH IDLE SPEED. CHECKED TO SEE IF LINKAGE WAS SOMEHOW BINDING OR IF VEHICLE HAD BACKFIRED THROUGH THE THROTTLE BODY. NO EVIDENCE OF DAMAGE DUE TO BACKFIRE SO PROCEEDED TO DRIVE VEHICLE. AFTER TRAVELING APPROXIMATELY 40 MILES OF HIGHWAY ENCOUNTERED A STOP LIGHT, APPLIED BRAKES TO FIND THAT THERE WERE NONE. AT THAT POINT REALIZED THAT THE SOUND HEARD UPON STARTING WAS THAT OF THE VACUUM BOOSTER HOSE SEPERATING FROM THE MANIFOLD. NOTED THAT NEITHER HOSE INSTALLED AT THIS POINT ARE SECURED WITH A HOSE CLAMP. REINSTALLED HOSE AND HAVE HAD NO FURTHER OCCURRENCE.*AK

NHTSA ID

733553

Incident

Oct 2, 2000

ENGINE CHECK LIGHT CAME ON/VEHICLE STARTED SMOKING. CONSUMER COULD SMELL GAS.TURNED VEHICLE OFF AND HAD IT TOWED. DEALER SAID SAID IT WAS THE PCM. ALSO, MANUAL TRANSMISSION MAKES NOISE AND IT IS DIFFICULT TO CHANGE GEARS.*AK

NHTSA ID

868196

Incident

Jun 3, 2000

CONSUMER WENT TO PRESS THE HORN WHEN IT DID NOT SOUND. KEPT PRESSING THE HORN PAD WHEN AIRBAG FELL OFF. APPARENTLY AIRBAG WAS NEVER BOLTED DOWN AT THE FACTORY WHICH CAUSED IT TO FALL. CONSUMER CALLED MANUFACTURER, AND WAS TOLD THAT MISTAKE HAPPENED, AND THERE WAS A WARRANTY TO CORRECT IT. *AK

NHTSA ID

859521