2000 Jeep Wrangler Problems

JEEP WRANGLER NV3550 MANUAL FIVE SPEED TRANSMISSION NOISE. AT 20,000 MILES THE TRANSMISSION MADE IRREGULAR NOISES THAT CHRYSLER CLAIMS ARE NORMAL. NOW, JUST AS THE WARRANTY IS RUNNING OUT THEY CLAIM THESE SAME NOISES ARE A FAILING TRANSMISSION THAT NEEDS REPAIR AT THE COST OF $2000. *JB

2000 WRANGLER SPORT, 4.0 LITER, 5-SPEED TRANSMISSION - LOUD TRANSMISSION NOISES AT IDLE WITH CLUTCH OUT. TOOK IT BACK TO DEALER (EARNHARDT'S JEEP IN TEMPE) TWICE WHEN VEHICLE STILL UNDER WARRANTY. DEALER REPLACED CLUTCH ONCE, WHICH RESOLVED PROBLEM WITH GEAR STICKING BUT NOT NOISE PROBLEM. DEALER SAID NOISE PROBLEM COMMON TO THAT YEAR AND NO FIX AS YET, BUT SAID I WOULD BE ELIGIBLE FOR FIX WHEN FACTORY DEVELOPED ONE. WENT TO TATE'S IN HOLBROOK YESTERDAY. THEY SHOWED ME ON COMPUTER THAT THERE IS NOW A FACTORY IDENTIFIED FIX INVOLVING REPLACING A SHAFT AND BUSHING OR BEARING IN THE TRANSFER CASE, BUT SAID THEY WON'T FIX MINE SINCE OUT OF WARRANTY. WROTE A LETTER TO EARNHARDT'S BUT HAVEN'T HEARD ANYTHING YET. FIX IS 21-001-01 DATED FEBRUARY, 2001. *LA

THE FRONT FRAME CAP, OR MOUNTING BRACKET HAS STARTED IS ROTTING AND DETERIORATING. THIS IS A MAJOR CONCERN WHICH HAS COURSES MANY OTHER SEVERE ISSUES. THIS IS A MAJOR SUSPENSION COMPONENT THAT IS ROTTING AWAY.

FRAME ROTTED FROM THE INSIDE OUT AROUND THE LOWER CONTROL ARMS. THE CHASSIS IS OTHERWISE RUST FREE, BUT IT SPONTANEOUSLY ROTTED FROM THE INSIDE OUT. THE LOWER CONTROL ARM DISCONNECTED WHILE DRIVING DOWN THE HIGHWAY, LEAVING THE REAR AXLE FREE FLOATING, UNSTABLE, AND VERY LIKELY TO CAUSE A CRASH. THE FRAME HAS HOLES IN IT THAT LET WATER IN. THERE IS NO DRAINAGE HOLE WHERE THE FRAME GOES FROM FLAT ON THE BOTTOM AND CURVES UP AROUND THE WHEEL WELLS. WATER GETS INTO THE FRAME, SITS THERE, AND ROTS IT FROM THE INSIDE OUT. THERE IS NO WAY TO SEE THIS ROT FROM THE OUTSIDE AND THERE IS NO WAY TO FIX IT WITHOUT CUTTING OPEN THE FRAME AND WELDING IN REPAIRS. IF YOU GOOGLE IMAGE SEARCH "JEEP TJ FRAME ROT" YOU CAN SEE OTHER CASES OF THE FRAME FAILING IN THE EXACT SAME LOCATION. HERE'S A BLOG POST WITH SEVERAL INSTANCES OF IT HTTPS://SARAHSTONESADIE.BLOGSPOT.COM/2019/05/JEEP-TJ-FRAME-RECALL.HTML IF YOU GOOGLE "TJ FRAME CAP" YOU'LL SEE THERE'S AN ENTIRE SUB MARKET OF PRODUCTS SPECIFICALLY MADE TO ADDRESS THIS FAILURE. TOYOTA HAD A FRAME RECALL, WHY CAN'T JEEP? IT'S CLEARLY FAILING IN THE EXACT SAME PLACE AND CAN CAUSE SEVERE SAFETY ISSUES. ATTACHED IS A PICTURE "PRE_ROT" THAT SHOWED IT ABOUT 6 MONTHS(?) BEFORE IT COMPLETELY ROTTED THROUGH. THE OTHER PICTURE IS AFTER IT FAILED WHILE DRIVING DOWN THE HIGHWAY. IT WAS A SMALL RUST BUBBLE THAT STARTED FROM THE INSIDE OUT THAT FAIRLY RAPIDLY RESULTED IN COMPLETE STRUCTURAL FAILURE.

WE HAVE FOUND THAT AFTER REMOVING THE BOLTS FROM THE CROSS MEMBER UNDER THE JEEP THAT THE HOLES ARE RUSTED OUT. IN FACT THE FRAME ON BOTH SIDES OF OUR JEEP ARE RUSTED THROUGH FROM NOT HAVING ANY DRAIN HOLES FOR THE WATER TO DRAIN OUT.

FRAME ROTTED FROM THE INSIDE OUT AROUND THE LOWER CONTROL ARMS. THE CHASSIS IS OTHERWISE RUST FREE, BUT IT SPONTANEOUSLY ROTTED FROM THE INSIDE OUT. THE LOWER CONTROL ARM DISCONNECTED WHILE DRIVING DOWN THE HIGHWAY, LEAVING THE REAR AXLE FREE FLOATING, UNSTABLE, AND VERY LIKELY TO CAUSE A CRASH. THE FRAME HAS HOLES IN IT THAT LET WATER IN. THERE IS NO DRAINAGE HOLE WHERE THE FRAME GOES FROM FLAT ON THE BOTTOM AND CURVES UP AROUND THE WHEEL WELLS. WATER GETS INTO THE FRAME, SITS THERE, AND ROTS IT FROM THE INSIDE OUT. THERE IS NO WAY TO SEE THIS ROT FROM THE OUTSIDE AND THERE IS NO WAY TO FIX IT WITHOUT CUTTING OPEN THE FRAME AND WELDING IN REPAIRS. IF YOU GOOGLE IMAGE SEARCH "JEEP TJ FRAME ROT" YOU CAN SEE OTHER CASES OF THE FRAME FAILING IN THE EXACT SAME LOCATION. HERE'S A BLOG POST WITH SEVERAL INSTANCES OF IT HTTPS://SARAHSTONESADIE.BLOGSPOT.COM/2019/05/JEEP-TJ-FRAME-RECALL.HTML IF YOU GOOGLE "TJ FRAME CAP" YOU'LL SEE THERE'S AN ENTIRE SUB MARKET OF PRODUCTS SPECIFICALLY MADE TO ADDRESS THIS FAILURE. TOYOTA HAD A FRAME RECALL, WHY CAN'T JEEP? IT'S CLEARLY FAILING IN THE EXACT SAME PLACE AND CAN CAUSE SEVERE SAFETY ISSUES. ATTACHED IS A PICTURE "PRE_ROT" THAT SHOWED IT ABOUT 6 MONTHS(?) BEFORE IT COMPLETELY ROTTED THROUGH. THE OTHER PICTURE IS AFTER IT FAILED WHILE DRIVING DOWN THE HIGHWAY. IT WAS A SMALL RUST BUBBLE THAT STARTED FROM THE INSIDE OUT THAT FAIRLY RAPIDLY RESULTED IN COMPLETE STRUCTURAL FAILURE.

I WAS DRIVING DOWN THE ROAD AND MY JEEP CAUGHT FIRE FROM UNDERNEATH. I HAD TO STOP AND JUMP OUT TO SURVIVE. IT BURNT COMPLETELY. NOTHING SURVIVED.

TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. AFTER PARKING AND SHUTTING OFF THE VEHICLE, SMOKE APPEARED UNDER THE HOOD WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V104000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 120,000.

WHILE DRIVING DOWN THE ROAD, SPEED DOESN'T MATTER BC IT HAS HAPPENED AT MULTIPLE SPEEDS, THE SPEEDOMETER AND TACHOMETER WILL DROP TO NOTHING, WHILE THE OTHER GAUGES LIKE GAS, OIL PRESSURE, TEMPERATURE AND SUCH DO NOT HAVE ANY ISSUES AND REMAIN WHERE THEY SHOULD BE! A FEW SECONDS AFTER THE SPEEDOMETER AND TACHOMETER DROP, THE ENGINE LIGHT COMES ON AND THE ODOMETER WILL READ 'NO BUS', A FEW SECONDS TO A MINUTE LATER THE GAUGES WILL RESUME AND THE ENGINE LIGHT AND 'NO BUS' DISAPPEAR! ANOTHER EXAMPLE OF THIS IS THE SPEEDOMETER AND TACHOMETER WILL DROP AND OTHER GAUGES NOT BE AFFECTED LIKE PREVIOUS SCENARIO ONLY WITH THIS ONE THE AIRBAG LIGHT WILL ILLUMINATE, LASTS FOR A BRIEF PERIOD AND THEN GOES BACK TO NORMAL! IT HAPPENS SPORADICALLY, BUT HAVE NOTICED IT HAPPENS MORE ON BUMPY ROADS! NONE OF THIS HAS HAPPENED WHILE THE VEHICLE IS STATIONARY AT IDLE! ALL WHILE DRIVING DOWN THE ROAD, VARIOUS SPEEDS, VARIOUS TYPES OF ROADWAYS!

OVER HEATING OF A/C - HEATER CONTROL SWITCH WHILE IN USE CAUSED THE SWITCH CONNECTOR, SWITCH AND PART OF THE HVAC CONTROL PANEL TO MELT. ON THE VERGE OF FIRE THE FAN STOPPED FUNCTIONING. RETRIEVED THE SAME UNIT OFF A DONER VEHICLE [1J4FA59S3YP733181] AND FOUND THE CONTROL TO BE MELTED/BURNT IN THE SAME FASHION. WHEN I LOOKED FOR A REPLACEMENT, THE PARTS SUPPLIERS OFFERED A READY-MADE REPLACEMENT WIRE HARNESS [POTENTIAL CLUE OF COMMON FAILURE]. THE MOPAR REPLACEMENT PART IS LISTED AS DISCONTINUED. I HAVE TAKEN PHOTOS OF THE ISSUES DESCRIBED, BUT WILL HAVE TO GET THEM DEVELOPED AND DIGITIZED [MY DIGITAL CAMERA WON'T TAKE CLOSE-UP PICS].

TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. WHILE DRIVING 60 MPH AND ATTEMPTING TO AVOID COLLIDING WITH ANOTHER VEHICLE, THE CONTACT'S VEHICLE CRASHED INTO A ROCK WALL BARRIER. THE FRONT DRIVER AND PASSENGER AIR BAGS FAILED TO DEPLOY. THE DRIVER EXPERIENCED MINOR SORENESS THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE SUSTAINED DAMAGE TO THE FRONT DRIVER SIDE BUMPER AND THE FRAME. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED AND REPAIRED. THE DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 139,000.

FOR AS LONG AS I CAN REMEMBER THE AIR BAG LIGHT HAS COME ON AND REMAINED ON. I HAVE ALWAYS FIGURED IT WAS JUST A PROBLEM WITH THE LIGHT. I WAS RECENTLY TOLD THAT IF THE WARNING LIGHT IS ON THE AIR BAG WILL NOT WORK. I DID NOT FIND ANY RECALLS REGARDING AIR BAGS BUT I SEE VARIOUS COMPLAINTS REGARDING AIR BAGS IN THE JEEP WRANGLER AND THIS CONCERNS ME. I AM PRINTING THESE COMPLAINTS AND BRINGING THE VEHICLE TO A DEALER BEFORE SELLING IT. I WANT TO ASSURE THE SAFETY OF ANY FUTURE DRIVERS. *JB

I HAVE ONGOING PROBLEM WITH SEATBELT SIMILAR TO SEVERAL I HAVE ALREADY SEEN REPORTED IN THAT THE BELT APPEARS TO LOCK BUT IS NOT ACTUALLY ENGAGED. IT THEN SLIPS OUT OF LATCH WHILE DRIVING. HAS TO BE INSERTED AT PRECISE ANGLE IN ORDER TO CATCH AND TAKES SEVERAL TRIALS TO MAKE THIS HAPPEN. *TR

1) I BOUGHT THE JEEP WRANGLER USED 2)THE LATCH SOMETIMES DOES NOT ENGAGE WHEN I PUT THE LIP OF THE SEAT BELT INTO THE SOCKET OF THE SEAT BELT. IT STICKS...IM AFRAID THAT IF I DO GET IN A WRECK IT WILL FAIL AND I WILL BE EJECTED, ESPECIALLY WITH A JEEP AND IT HAVING A HIGH ROLLOVER RISK. 3)IM SERIOUSLY THINKING OF GETTING BRAND NEW SEAT BELTS, NOT CHRYSLER BRAND BUT AFTER MARKET ONES, UNLESS CHRYLSER SOLVES THE ISSUE. *JB

The contact owns a 1994 N/A Jeep Wrangler. The contact stated that the vehicle failed the State Inspection because the VIN was included in NHTSA Campaign Number: 02V041000 (PARKING BRAKE). However, the part to do the recall repair was no longer available. The contact had not experienced a failure. The vehicle was not repaired. The manufacturer was notified of the issue. The mileage at the failure of the State Inspection was 262,384.

I OWN A 2000 JEEP WRANGLER WHICH I BOUGHT NEW. RECENTLY I BEGAN HAVING TROUBLE SHIFTING INTO SECOND GEAR AND SOMETIMES IT WOULD POP OUT WHILE DRIVING. SOON AFTER I BEGAN TO HAVE BRAKE ISSUES AND HAD A MECHANIC LOOK AT IT. HE SAID HE HAD NEVER SEEN A JEEP RUSTED OUT SO BAD WITH SO FEW MILES ON IT AND SAID IT WAS A HAZARD TO DRIVE. HE SAID THE BRAKE LINES WERE RUSTED THROUGH AS WELL AS THE SUPPORT FOR THE TRANSMISSION . HE SAID THE FRAME WAS IN TERRIBLE SHAPE AND SAID I WAS LUCKY THE THING DIDN'T FALL APART WHILE I WAS DRIVING IT. THIS VEHICLE ONLY HAS 85,000 MILES ON IT. *TR

The contact owns a 1993 N/A Jeep Wrangler. The contact stated that there was a strong fuel odor coming from the vehicle after the vehicle was refueled. Additionally, the contact stated that the vehicle was experiencing rough idling and reduced power while driving. The vehicle was taken to the dealer, where the contact was informed that the VIN was included in NHTSA Campaign Number: 94V106000 (Fuel System, Gasoline); however, the dealer later informed the contact that the recall part had been discontinued. The vehicle was not repaired. The manufacturer was contacted and confirmed that the recall part had been discontinued. The contact requested that the manufacturer replace the entire fuel pump assembly. A case was filed. The failure mileage was 172,000.

I WAS DRIVING DOWN THE ROAD AND MY JEEP CAUGHT FIRE FROM UNDERNEATH. I HAD TO STOP AND JUMP OUT TO SURVIVE. IT BURNT COMPLETELY. NOTHING SURVIVED.

THE FRONT PORTION OF THE FRAME HAS RUSTED FROM THE INSIDE OUT, NEARLY SEVERING THE STEERING GEAR BOX AND FRAME, FROM THE REST OF THE FRAME. IN ADDITION THE FRAME IN THE SAME LOCATION ON THE PASSENGER SIDE WAS ALSO SOFT TO THE POINT THAT I COULD COMPRESS THE FRAME WITH MY BARE HAND. I DISCOVERED THE PROBLEM AFTER INVESTIGATING WHY THE JEEP WAS SUDDENLY DIFFICULT TO KEEP STRAIGHT WITHIN THE TRAVELING LANE OF WASHINGTON STREET. THANKFULLY, I WAS CLOSE TO HOME AND WAS ABLE TO MAKE IT BACK. I WAS QUOTED $2,200 TO FIX BOTH SIDES OF THE FRAME THROUGH A METAL FRABRICATOR, BUT HE SUGGESTED REPLACING THE ENTIRE FRAME, AS THERE WAS FURTHER ROT CLEAR UP TO THE SPRING BUCKETS. ULTIMATELY I'LL BE FORCED TO TAKE A $4,600 LOAN TO REPLACE THE FRAME. JEEP TJ'S ARE KNOWN FOR THEIR FRAME RUST ISSUES, BUT THE FACT THAT THE RUST WAS UNSEEN JUST WEEKS BEFORE THIS INCIDENT, COMBINED WITH A SUDDEN LOSS OF STEERING STABILITY, IS WORTH TAKING NOTE OF CONCERN. TWO YEARS AGO THIS JEEP HAD NO VISIBLE RUST ANYWHERE ON THE BODY OR FRAME. THE STEERING GEAR BOX WAS REPLACED WITHIN THE LAST YEAR, AND AT THAT TIME THERE WERE NO INDICATIONS THAT THE FRAME WAS COMPROMISED.

ALL NOTES I HAVE FOUND INCLUDING ONLINE FORMS REQUESTING THIS YEAR KEEPS FRAME BE RECALLED, ROTTEN AT BUMPERS WHERE STEERING COMES INTO PLAY AND OTHER SPOTS MID FRAME... HUSBAND WAS DRIVING WHEN THE FRAME LET GO, HE WAS IN ABLE TO STEER THE VEHICLE AT ALL! THE JEEP WAS IN THE MIDDLE OF THE ROAD AND HAD TO BE TOWED WHICH CAUSED THE ROAD TO BECOME UNSAFE AS IT WAS STOPPED AT THE BOTTOM OF A HILL WITH TRAFFIC FLYING OVER THE HILL... HE ALMOST GO HIT 5 TIMES HE COULD HAVE DIED EASILY HAD HE NOT JUMPED OUT AND CALLED FOR IMMEDIATE ASSISTANCE

TREADS SEPARATED FROM TIRE AFTER 2000 MILES OF DRIVING. THIS HAPPENED ON THE HIGHWAY. *TR

TL*THE CONTACT OWNS A 2000 JEEP WRANGLER. THE VEHICLE HAS INTERCO SUPER SWAMPERS IROC TIRES, SIZE 37/12.5/15. WHILE DRIVING APPROXIMATELY 10 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE BEGAN WOBBLING EXCESSIVELY AND PULLING IN ONE DIRECTION. IMMEDIATELY, THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND INSPECTED THE VEHICLE. HE NOTICED THAT ALL FOUR TIRES EXHIBITED UNEVEN TREAD BELT AND WERE OUT OF ROUND. THE TIRES WERE RECENTLY PURCHASED IN 2009. THE MANUFACTURER WAS NOTIFIED OF THE DEFECTIVE TIRES, BUT DID NOT ASSIST. THE VIN, DOT NUMBER, AND FAILURE MILEAGE WERE UNAVAILABLE. THE CURRENT MILEAGE WAS 104,000.

TL* THE CONTACT OWNS A 2000 JEEP WRANGLER. WHILE IDLING AT A STOP LIGHT, THE VEHICLE WAS NOT OPERATIONAL AFTER THE ACCELERATOR PEDAL WAS DEPRESSED. IN ADDITION, THE VEHICLE MADE AN ABNORMAL NOISE. THE FAILURE OCCURRED WITHOUT WARNING. THE SHIFTER WAS ABLE TO BE MOVED, BUT THE VEHICLE DID NOT RESPOND. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TOWED TO A SECOND DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE HAD A DEFECTIVE TRANSFER CASE THAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 79,000.

TL*THE CONTACT OWNS A 2000 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE STARTED TO MAKE AN ABNORMAL KNOCKING AND BUCKING NOISE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE TRANSMISSION MOUNT WAS ROTTED AWAY FROM THE FRAME. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE VIN NUMBER WAS UNAVAILABLE. UPDATED 4/15/15*CN UPDATED 9/21/2017*CN

2000 JEEP WRANGLER. THE WIRING TO THE A/C CONTROL SWITCH SHORTS OUT AND CAUSES A MINOR FIRE. THE SWITCH HAS BEEN REPLACED AND IT HAPPENED AGAIN. THERE WAS EVIDENCE OF A PREVIOUS FIX IN SPLICED WIRING. THE WIRING HARNESS IS NO LONGER AVAILABLE. RESEARCH ON JEEP RELATED WEB SITES HAS PROVEN TO ME THAT THIS IS NOT AN ISOLATED INCIDENCE AND OCCURS IN MANY OF THE SURROUNDING MODEL YEARS. THERE IS A DESIGN FLAW IN THE THREE POSTS THAT CONNECT TO THE SELECTOR SWITCH, THEY ARE TO CLOSE TO EACH OTHER. *TR

MODE SELECTOR FOR THE HVAC SYSTEM HAS A MAJOR ISSUE MELTING THE SELECTOR, HARNESS AND CONTROL MODULE. AFTER RESEARCHING THIS INCIDENT ONLINE AND TO MY SURPRISE THERE IS NO RECALL ON THIS SUBJECT. HEATER NOT WORKING, POSSIBLE HEATER SYSTEM CATCHING ON FIRE DO HI VOLTAGE TO THE MODE SELECTOR WITCH CAUSES ENTIRE HVAC FAILURE AND POSSIBLE FIRE. JEEP HAS KNOWN ABOUT THIS FOR A WHILE BUT NO ONE SEEMS TO BE GETTING ON THEM ABOUT IT. AGAIN 2000 JEEP WRANGLER HEATER CONTROL FAILURE. *TR

-AT APPROXIMATELY FIFTY-FIVE TO SIXTY MILES PER HOUR, THE VEHICLE'S FRONT END BEGINS TO SHAKE VIOLENTLY. I HAVE PERSONALLY RESEARCHED THE PROBLEM AND DISCOVERED THAT IT IS COMMONLY CALLED, "DEATH WOBBLE" AMONGST OTHER JEEP OWNERS. THE ISSUE TYPICALLY OCCURS AFTER HITTING A BUMP IN THE ROAD OR DRIVING AROUND A BEND ON THE HIGHWAY. SINCE THE FIRST INCIDENT IN EARLY 2009, I HAVE TAKEN THE VEHICLE TO A NUMBER OF DIFFERENT LOCAL MECHANICS FOR A DIAGNOSIS AND HAVE HEARD DIFFERENT SUGGESTED COURSES OF ACTION FROM EACH ONE. I HAVE HAD A NUMBER OF COMPONENTS REPLACED ON THE VEHICLE INCLUDING, BUT NOT LIMITED TO THE (1) TRACKING BAR, (2) U-JOINTS, (3) STEERING DAMPENER ETC. I HAVE ALSO HAD AN ENTIRE NEW SET OF TIRES REPLACED ON THE VEHICLE. ALTHOUGH REPLACING THE TRACKING BAR WORKED TEMPORARILY, THE PROBLEM SOON RETURNED AFTER ADDING AN ADDITIONAL 10,000 - 15,000 MILES TO THE VEHICLE. -ALTHOUGH MANY OTHER JEEP OWNERS HAVE REPORTED THE SAME ISSUE OVER THE YEARS, NO ACTION HAS BEEN TAKEN IN THE FORM OF A RECALL FROM THE FORMER "DAIMLERCHRYSLER AG" OR ITS SUCCESSOR "CHRYSLER GROUP L.L.C." OR IT'S SUBSIDIARY "JEEP CORPORATION." *TR

MODE SELECTOR FOR THE HVAC SYSTEM HAS A MAJOR ISSUE MELTING THE SELECTOR, HARNESS AND CONTROL MODULE. AFTER RESEARCHING THIS INCIDENT ONLINE AND TO MY SURPRISE THERE IS NO RECALL ON THIS SUBJECT. HEATER NOT WORKING, POSSIBLE HEATER SYSTEM CATCHING ON FIRE DO HI VOLTAGE TO THE MODE SELECTOR WITCH CAUSES ENTIRE HVAC FAILURE AND POSSIBLE FIRE. JEEP HAS KNOWN ABOUT THIS FOR A WHILE BUT NO ONE SEEMS TO BE GETTING ON THEM ABOUT IT. AGAIN 2000 JEEP WRANGLER HEATER CONTROL FAILURE. *TR

200 JEEP WRANGLER - MELTING HVAC WIRE CONNECTOR (3 WIRE CONNECTOR) ON SWITCH PANEL CAUSES THE FAN SWITCH TO SHORT OUT (MELT CONTACTS). MELTING PLASTIC SMELL FILLS THE PASSENGER COMPARTMENT. *NM

HVAC SWITCH SHORTING AND MELTING PLUG AND/OR HARNESS. *NM

JEEP HEADLAMP LIGHTER/DIMMER SWITCH STARTED WORKING INTERMITTENTLY. WHEN PULLING SWITCH OUT, HEADLAMPS WOULD NOT RELIABLY TURN ON. ORDERED A NEW SWITCH. WHEN REPLACING SWITCH, NOTICED THAT HEADLAMP LIGHTER/DIMMER SWITCH PLASTIC ELECTRICAL CONNECTOR WAS MELTED. *JB

WATER ENTERED THE STEERING COLUMN THROUGH THE HAZARD SWITCH (LEAK CAUSED BY FACTORY TOP DESIGN) AND SHORTED THE MULTI FUNCTION SWITCH USED TO CONTROL BRAKE LIGHTS, TURN SIGNALS, AND HEADLIGHTS. THE SHORT CAUSED A SMALL FIRE AND MELTDOWN OF THE SWITCH. THE SWITCH HAD TO BE REPLACED. THIS IS THE SECOND TIME THIS HAS OCCURRED. *JB

I GOT MY 2000 JEEP WRANGLER SAHARA FROM PARENTS THEY BOUGHT IT NEW FROM DEALERSHIP. WHEN IT HIT ABOUT 150,000 MILES WHEN IN MOTION NO MATER HOW MUCH GAS IS IN IT, IT ACTS LIKE YOU HAVE RUN OUT . IT CUTS OUT, SLOWS DOWN, AND SOMETIMES WILL BACKFIRE THEN WILL GO AGAIN. SOMETIMES IF YOU TURN OFF THE KEY AND START IT AGAIN IT STOPS DOING IT,OTHER TIMES IT ONLY HELPS FOR A MILE THEN CUTS OUT AGAIN.I NOW HAVE 210,000 MILES ON IT, AND I NEVER KNOW WHEN IT WILL DO IT. I AM AT A LOSS CAN NOT FIGURE OUT WHAT IT IS CAUSING THE PROBLEM.I KNOW THE JEEP IS 16 YEARS OLD AND I HAVE HAD TO REPLACE A NUMBER OF PARTS ON IT AND THAT'S FINE I UNDERSTAND THAT'S NORMAL. I JUST CAN'T FIGURE OUT THE CUTTING OUT PART. ALSO WHEN ADDING GAS IT KICKS OFF THE PUMP LIKE IT FULL EVEN WHEN IT'S NOT (EVERY 4 TO 7 CENTS) SOMETIMES SPLASHING GAS BACK ON ME. THIS HAS BEEN GOING ON FOR 5 YEARS NOW.

UPON STARTING OF VEHICLE AFTER FUELING A 'POP' WAS HEARD FROM THE ENGINE COMPARTMENT AND ENGINE STALLED. RESTARTED ENGINE WITH NO DIFFICULTY AND ENCOUNTERED A HIGH IDLE SPEED. CHECKED TO SEE IF LINKAGE WAS SOMEHOW BINDING OR IF VEHICLE HAD BACKFIRED THROUGH THE THROTTLE BODY. NO EVIDENCE OF DAMAGE DUE TO BACKFIRE SO PROCEEDED TO DRIVE VEHICLE. AFTER TRAVELING APPROXIMATELY 40 MILES OF HIGHWAY ENCOUNTERED A STOP LIGHT, APPLIED BRAKES TO FIND THAT THERE WERE NONE. AT THAT POINT REALIZED THAT THE SOUND HEARD UPON STARTING WAS THAT OF THE VACUUM BOOSTER HOSE SEPERATING FROM THE MANIFOLD. NOTED THAT NEITHER HOSE INSTALLED AT THIS POINT ARE SECURED WITH A HOSE CLAMP. REINSTALLED HOSE AND HAVE HAD NO FURTHER OCCURRENCE.*AK

SITTING AT STOP LIGHT, AC QUIT BLOWING, COMPRESSOR STILL ACTIVE. HVAC MOTOR SWITCH IS MELTED FROM OVERHEATING.(POSSIBLE DASH FIRE FROM THIS) CONFIRMED BY SIGHT THIS WAS IN FACT THE PROBLEM BY MY OWN EYES. FOUND AN ARTICLE IN JP MAGAZINE OCTOBER 07 ISSUE LABELED "RETARD" TO FIX THIS PROBLEM FOR GOOD NO THANKS TO THE DEALER. *TR