2003 Jeep Wrangler Problems

The factory weld on the front end driver's side stabilizer was bad and it came apart on the highway while driving , from the severe shaking it caused, and it could've killed us. The weld was not hot enough to penetrate the steel. I am a mechanic so I can attest , and be a witness , to claim it was a certifiably bad weld in the factory, and this should warrant a recall.

AT 55 MPH THE JEEP SHAKES VIOLENTLY, FROM SIDE TO SIDE, UNTIL VEHICLE IS SLOWED TO 35MPH.

TL*THE CONTACT OWNS A 2003 JEEP WRANGLER. THE CONTACT STATED THAT WHEN HE DEPRESSED THE CLUTCH PEDAL, HIS FOOT WOULD STRIKE THE CLUTCH PIN AND KNOCK IT LOOSE. THIS CAUSED CLUTCH FAILURE AND PREVENTED HIM FROM SHIFTING GEARS. HE WOULD HAVE TO EXIT THE VEHICLE TO PUT THE PIN BACK IN PLACE. THE FAILURE ONLY OCCURRED WHEN HIS FOOT STRUCK THE CLUTCH PIN. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER; HOWEVER, THE DEALER STATED THAT THEY WOULD INSPECT THE VEHICLE. THE CONTACT FURTHER STATED THAT THE HYDRAULIC CLUTCH PEDAL BIN WOULD FALL STRAIGHT DOWN AS IF HIS FOOT SLIPPED OFF THE PEDAL. THE CURRENT MILEAGE WAS APPROXIMATELY 57,000 AND FAILURE MILEAGE WAS APPROXIMATELY 49,000.

I HAVE A 2003 JEEP WRANGLER WITH 48,000 MILES. I AM EXPERIENCING INTERMITTENT STICKING OF THE SHIFTING LEVER WHEN ENTERING 3RD FROM 2ND GEAR. AT OTHER TIMES THERE IS NO PROBLEM SHIFTING. I HAD IT IN TO THE DEALER THIS WEEK. WE CHANGE THE OIL. THE PROBLEM IS NOT A BAD. *JB

The contact owns a 2003 Jeep Wrangler. The contact stated while driving 30-40 MPH, the vehicle hit a bump in the roadway and the steering wheel started shaking significantly and the vehicle seemed to be at risk of a rollover. There was no warning light illuminated. The contact veered to the side of the road. The vehicle was towed to an independent mechanic where it was diagnosed that the steering column needed to be replaced. The vehicle was repaired; however, the failure reoccurred while driving. The dealer was notified of the failure and advised the contact to take the vehicle to be repaired. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 141,999.

Violent shaking after hitting holes in the road during acceleration-less tan 30 MPH. My vehicle has been inspected by my mechanic, who has knowledge of the “Death Wobble”. Safety was at risk due to front end shaking violently and almost losing control of the vehicle. The problem has been confirmed by mechanic. They started to manifest about 8 months ago.

FUEL TANK OVER FLOWS AT EVERY FILL UP. *TR

GAS TANK OVERFLOW ON JEEP WRANGER. *TR

The contact owns a 2003 Jeep Wrangler. The contact stated that while her daughter was attempting to park the vehicle, the brake pedal was extremely difficult to depress, and the vehicle did not immediately stop. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet notified of the failure. The failure mileage was 217,000.

AIRBAG COVER PLASTIC ON STEERING WHEEL WAS BREAKING DOWN. THE PLASTIC BECAME VERY STICKY, AS IF SOMEONE POURED A SODA ON IT. IT WOULD NOT CLEAN OFF WITH CLEANERS OR PLASTIC PRESERVERS. I WAS NOT CONFIDENT IT WOULD WORK AS DESIGNED IF AIRBAG DEPLOYED SO I BOUGHT NEW AIRBAG UNIT FOR THE STEERING WHEEL. PARKING BRAKE WILL NOT HOLD VEHICLE ON MINOR GRADE. IT ALWAYS WORKED UNTIL THE LAST 2-3 YEARS. I HAVE HAD IT ADJUSTED, THE CABLES REPLACED, AND THE BRAKE PADS REPLACED. IT DOES NOT MATTER WHETHER MY BRAKE PADS ARE NEW OR OLD. IF I DO NOT PARK THE VEHICLE WITH THE MANUAL TRANSMISSION IN GEAR, IT WILL MOVE ON ITS OWN, OR IF IT DOES NOT ROLL BACKWARDS, IT WILL, IF ANY LIGHT FORCE IS APPLIED TO IT. I HAD TO INSTALL INSTALL A HYDRAULIC BRAKE LINE LOCK ON THE REAR BRAKES TO MAKE SURE MY VEHICLE WILL NOT MOVE ON A GRADE I KNOW IT IS AN 'OLD' VEHICLE, BUT I LIKE IT A LOT, IT IS WELL MAINTAINED AND LOOKS NEW. IT IS MECHANICALLY SIMPLE TO AND INEXPENSIVE TO MAINTAIN. HOWEVER I SHOULD NOT BE HAVING TO BUY THINGS LIKE AIRBAGS WHO'S PLASTIC DEGRADES. I AND MY MECHANIC HAVE NO IDEA WHY THE PARKING BRAKE STOPPED WORKING AS IT HAD BEFORE. HE IS A MASTER MECHANIC AND AN EXPERT MACHINIST.

TL* THE CONTACT OWNS A 2003 JEEP WRANGLER. WHEN ATTEMPTING TO START THE VEHICLE, IT WOULD HESITATE TO START. SEVERAL ATTEMPTS HAD TO BE MADE IN ORDER TO START THE VEHICLE. ONCE THE VEHICLE WAS ABLE TO START, THE RADIO WOULD FAIL. WHEN THE BRAKES WERE APPLIED, THE VEHICLE WOULD STALL WITHOUT WARNING. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THAT THE FAILURE ONLY OCCURRED WHEN OPERATING THE VEHICLE IN THE RAIN. THE CONTACT HAD NOT NOTIFIED A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 38,425.

THERE IS NO LOW, MED OR HIGH FAN SETTINGS ON MY HEATER FAN. REPLACED HEATER RESISTOR, AND WIRING HARNESS DUE TO MELTED HARNESS. STILL NO HEATER FAN. SO AS THE LOCAL JEEP DEALERSHIP PARTS DEPARTMENT HAD ADVISED THAT THERE WAS AN ON GOING ISSUE THE HEATER FAN SWITCH. REPLACED THE SWITCH, FAN WORKED FOR ABOUT 2 HOURS DURING MY MAIL ROUTE... AFTER THE OVER WHELMING SMELL OF BURNING WIRES COMING FROM INSIDE THE DASH THE FAN QUIT WORKING. SO I CONTINUED TO FREEZE THE REST OF MY ROUTE AND HOPING THAT THE JEEP WAS NOT GOING TO CATCH FIRE. I HAD CONTACTED JEEP'S CUSTOMER SERVICE LINE TO VOICE MY CONCERNS, THE LADY TOLD ME THAT THERE WAS NOT MUCH THEY COULD DO FOR ME WHERE MY VEHICLE WAS OUT OF WARRANTY. I HAVE DONE SOME RESEARCH ONLINE AND THERE SEEMS TO BE QUITE AN ISSUE... I BELIEVE THAT JEEP SHOULD ADDRESS THE ISSUE EVEN THOUGH SOME JEEPS ARE OUT OF THE "FACTORY WARRANTY". THIS IS A HUGE SAFETY PROBLEM, AS TO ALL OF THE WIRES ARE FACTORY INSTALLED AND SHOULD BE CHANGED AND ADDRESSED QUICKLY. *TR

2013 JEEP WRANGLER. CONSUMER WRITES IN REGARDS TO INTERMITTENT ENGINE PROBLEMS, WHILE DRIVING UP HILLS ACCELERATION SPEEDS DECREASE. *SMD THE CONSUMER STATED UPON DRIVING UP HILLS, THE CHECK ENGINE LIGHT ILLUMINATED. THE CONSUMER STATED AFTER DOING SOME RESEARCH ONLINE, IT APPEARED THAT ANOTHER MODEL WAS RECALLED FOR THE SAME PROBLEM. OWNERS INDICATED THE CAM SHAFT SENSORS AND DYNAMIC SENSOR CONTROL NEEDED A TCM UPDATE. *JB

TL* THE CONTACT OWNS A 2003 JEEP WRANGLER. WHEN ATTEMPTING TO START THE VEHICLE, IT WOULD HESITATE TO START. SEVERAL ATTEMPTS HAD TO BE MADE IN ORDER TO START THE VEHICLE. ONCE THE VEHICLE WAS ABLE TO START, THE RADIO WOULD FAIL. WHEN THE BRAKES WERE APPLIED, THE VEHICLE WOULD STALL WITHOUT WARNING. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THAT THE FAILURE ONLY OCCURRED WHEN OPERATING THE VEHICLE IN THE RAIN. THE CONTACT HAD NOT NOTIFIED A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 38,425.

MY JEEP WRANGLER HAS HAVE THE PASSENGER SAFETY AIRBAG ALARMING SINCE ABOUT A YEAR AGO. I CONTACT THE MANUFACTURER AND I WAS TOLD THAT BECAUSE THERE IS NOT A RECALL FOR MY CAR MODEL, THEY CANNOT REPAIR IT AND THAT I HAVE TO PAY OUT OF MY POCKET. THIS IS AN ISSUE OUT OF THE MANUFACTURER. JEEP MUST CORRECT THESE SAFETY CONCERNS FROM THE OWNERS!

AIRBAG COVER PLASTIC ON STEERING WHEEL WAS BREAKING DOWN. THE PLASTIC BECAME VERY STICKY, AS IF SOMEONE POURED A SODA ON IT. IT WOULD NOT CLEAN OFF WITH CLEANERS OR PLASTIC PRESERVERS. I WAS NOT CONFIDENT IT WOULD WORK AS DESIGNED IF AIRBAG DEPLOYED SO I BOUGHT NEW AIRBAG UNIT FOR THE STEERING WHEEL. PARKING BRAKE WILL NOT HOLD VEHICLE ON MINOR GRADE. IT ALWAYS WORKED UNTIL THE LAST 2-3 YEARS. I HAVE HAD IT ADJUSTED, THE CABLES REPLACED, AND THE BRAKE PADS REPLACED. IT DOES NOT MATTER WHETHER MY BRAKE PADS ARE NEW OR OLD. IF I DO NOT PARK THE VEHICLE WITH THE MANUAL TRANSMISSION IN GEAR, IT WILL MOVE ON ITS OWN, OR IF IT DOES NOT ROLL BACKWARDS, IT WILL, IF ANY LIGHT FORCE IS APPLIED TO IT. I HAD TO INSTALL INSTALL A HYDRAULIC BRAKE LINE LOCK ON THE REAR BRAKES TO MAKE SURE MY VEHICLE WILL NOT MOVE ON A GRADE I KNOW IT IS AN 'OLD' VEHICLE, BUT I LIKE IT A LOT, IT IS WELL MAINTAINED AND LOOKS NEW. IT IS MECHANICALLY SIMPLE TO AND INEXPENSIVE TO MAINTAIN. HOWEVER I SHOULD NOT BE HAVING TO BUY THINGS LIKE AIRBAGS WHO'S PLASTIC DEGRADES. I AND MY MECHANIC HAVE NO IDEA WHY THE PARKING BRAKE STOPPED WORKING AS IT HAD BEFORE. HE IS A MASTER MECHANIC AND AN EXPERT MACHINIST.

05 & 06 wrangler has recall for the exact problem my 03 has. Parking pawl slides out of the brackets and then vehicle won't go into park allowing it to roll into danger and possibly kill someone. I have watched several videos on this issue and the 03 is the same as a 05 and 06. This is just as dangerous on the 03 as it is a 05 and 06 and potentially cause an accident and kill individuals.

2013 JEEP WRANGLER. CONSUMER WRITES IN REGARDS TO INTERMITTENT ENGINE PROBLEMS, WHILE DRIVING UP HILLS ACCELERATION SPEEDS DECREASE. *SMD THE CONSUMER STATED UPON DRIVING UP HILLS, THE CHECK ENGINE LIGHT ILLUMINATED. THE CONSUMER STATED AFTER DOING SOME RESEARCH ONLINE, IT APPEARED THAT ANOTHER MODEL WAS RECALLED FOR THE SAME PROBLEM. OWNERS INDICATED THE CAM SHAFT SENSORS AND DYNAMIC SENSOR CONTROL NEEDED A TCM UPDATE. *JB

I HAVE NOTICED THAT THE DRIVER SIDE SEATBELT WILL DISENGAGE WHILE DRIVING DOWN THE ROAD. TO REMEDY THE PROBLEM I HAVE PAID EXTRA ATTENTION WHEN BUCKLING IN TO MAKE SURE THAT IT IS LATCHED PROPERLY. HOWEVER, THE SEATBELT SOMETIME STILL RELEASES ON IT'S OWN. THIS CONCERNS ME BECAUSE I FEAR THAT WHEN I DO NEED THE SEATBELT IN THE COURSE OF AN ACCIDENT IT WILL NOT PERFORM AS INTENDED. *TR

RESEARCHING THE INTERNET, I SEEN SEVERAL OTHERS HAVE HAD SIMILAR COMPLAINS ON THE 2003 JEEP WRANGLER SEAT BELT SYSTEM. MY JEEP SEAT BELT, AS I WAS UN-BUCKLING A FEW WEEKS BACK, CAME APART, THE SPRING AND ORANGE PUSH BUTTON CAME FLYING OUT AND I CAN NOT GET IT BACK TOGETHER. I WENT TO DEALERSHIP AND IT WILL COST ME $150 FOR A REPLACEMENT PART ALONE ON SOMETHING THAT WAS NO FAULT OF MY OWN. THE OTHER ISSUE IS THE LACK OF RETRACTION IN THE SEAT BELT CAUSING IT TO GET CAUGHT IN THE DOOR SOMETIMES AND THIS CAN CAUSE SAFETY ISSUES. SINCE IT IS A LAW TO WEAR YOUR SEAT BELT AND ITS IN THE SAFE INTEREST OF THE PUBLIC TO WEAR ONE, THIS POSSES A PROBLEM AND SHOULD BE INVESTIGATED AND FIXED IMMEDIATELY.. *TR

2003 TJ frame rust all tjs have frame rust.

2003 JEEP WRANGLER TJ, THE CONTACT POINTS FOR THE 3RD BRAKE LIGHT ARE OPEN TO THE CARGO COMPARTMENT. HAD A HOCKEY STICK BLADE (MADE OF FIBERGLASS) TOUCH THESE CONTACTS AND CATCH THE STICK AND THE CARPET ON FIRE WHILE DRIVING. NOTICED BURNING SMELL WHEN SITTING AT A STOP LIGHT, THOUGHT IT WAS FROM ANOTHER VEHICLE, PULLED AWAY FROM INTERSECTION, LOOKED IN BACK AND THERE WAS A FIRE INSIDE THE RIGHT REAR CORNER. *TR

REAR WINDOW POPS OPEN WHEN THE FORWARD DOORS ARE CLOSED. ALSO POPS OPEN WHEN DRIVING DOWN THE ROAD. LETS THE RAIN IN AND RATTLES. POOR ENGINEERING AND DESIGN. *JB

I PURCHASED A NEW 2003 JEEP WRANGLER RUBICON IN MAY OF 2003 WITH THE DUAL TOP OPTION. SINCE DAY ONE, WHENEVER THE FULL HARD DOOR IS SHUT WITH THE WINDOWS ROLLED UP AND THE HARDTOP ON, THE REAR GLASS POPS OPEN. THE REAR GLASS ALSO POPS OPEN WHEN YOU HIT A BUMP IN THE ROAD. THEN THE REAR GLASS JUST FLOPS AROUND AND HITS THE SPARE TIRE AND YOU HAVE TO GET OUT AND PUSH IT SHUT, OTHERWISE I'M AFRAID IT MIGHT BREAK THE REAR GLASS. MY MAIN CONCERN IS THAT IT IS A SAFETY HAZARD AS THE OWNER'S MANUAL SAYS TO NEVER DRIVE WITH THE REAR WINDOW OPEN (ON SOFT TOP) UNLESS YOU ALSO HAVE THE FRONT WINDOWS ROLLED DOWN OR EXHAUST FUMES MAY ENTER THE DRIVER/PASSENGER COMPARTMENT AND CAUSE CARBON MONOXIDE POISIONING! I ASSUME THE SAME THING CAN HAPPEN WITH THE HARD TOP ON WHEN THE REAR GLASS IS OPEN 2-3 INCHES AND FLOPPING AROUND! I HAVE TAKEN IT TO THE DEALER TWICE AND THEY TRIED LOWERING THE REAR GLASS BY ADJUSTING THE HINGES ON THE GLASS BUT THE PROBLEM STILL EXISTS. I CONTACTED JEEP "STAR" TECH SUPPORT ON 3 SEPARATE OCCASSIONS AND FILED A COMPLAINT (FILE # 11586375) THE SERVICE MANAGER AT OUR DEALERSHIP SAID THAT HE HAS SEEN THIS PROBLEM ON SOME OTHER HARD TOP JEEPS AND I ALSO HAVE SEEN THE SAME COMPLAINT ON THE INTERNET ON JEEP FORUM CHAT ROOMS. APPARENTLY JEEP DOES'T TAKE THE PROBLEM SERIOUSLY SINCE I HAVE OWNED THE VEHICLE FOR 1 1/2 YEARS AND IT HASN'T BEEN FIXED YET. MAYBE WHEN SOMEONE DIES FROM CARBON MONOXIDE POISONING THEY WILL TAKE ACTION! I BELIEVE THIS IS A DESIGN FLAW. THE 2003 HARDTOP RELIES ON THE REAR TAILGATE TO KEEP THE REAR GLASS CLOSED AND THERE ISN'T ENOUGH OVERLAP TO SECURELY HOLD THE REAR GLASS IN PLACE.*AK

REAR WINDOW POPS OPEN WHEN THE FORWARD DOORS ARE CLOSED. ALSO POPS OPEN WHEN DRIVING DOWN THE ROAD. LETS THE RAIN IN AND RATTLES. POOR ENGINEERING AND DESIGN. *JB

THE DEALER STATES THAT I HAVE PROBLEM WITH MY HEATING AND COOLING SYSTEM.WHEN THE AIR CONDITIONER,OR THE DEFROSTER IS IN USE,A NOISE THAT WOULD SOUND LIKE A DROP OF WATER DROPPING PRECISELY EVERY 4 TO 5 SECONDS,STEREOS,AND ROAD NOISE DO NOT HIDE IT.THE AFFECT IS LIKE BEING IN A TORTURE CHAMBER.IT LITTERY DRIVES YOU CRAZY.

I STOPPED AT A RED LIGHT BEHIND A FORD EXPEDITION. WHEN THE LIGHT TURNED GREEN, I LIGHTLY DEPRESSED THE GAS PEDAL AND THE CAR IMMEDIATELY ACCELERATED OUT OF CONTROL. THIS HAD NEVER OCCURRED BEFORE. I HIT THE CAR IN FRONT OF ME AND WAS ABLE TO AGGRESSIVELY HIT THE BRAKES TO SLOW DOWN ENOUGH TO SLOW THE CAR AND SHIFT INTO NEUTRAL. THE CAR WAS TAKEN TO A JEEP DEALERSHIP AND THEY KEPT THE CAR FOR A NUMBER OF DAYS. THEY STATED THEY COULD NOT FIND ANYTHING WRONG AND THEY BLAMED THE INCIDENT ON AN AFTER MARKET FLOOR MAT. THIS WOULD MAKE SENSE TO ME IF THE ACCELERATOR WAS JUS STUCK AT THE CURRENT SPEED, BUT THE ENGINE KEPT SPEEDING UP AND THE TIRES WERE SPINNING WHEN I WAS DEPRESSING THE BRAKES. THE CAR ACTED LIKE I HAD THE GAS PEDAL FULLY DEPRESSED. *TR

I WAS INVOLVED IN AN ACCIDENT ON 7/31/03. I DEPRESSED THE BRAKE IN A HARD MANOR BUT SINCE THE GAS PEDAL IS SO CLOSE TO THE BRAKE, MY FOOT WAS HALF ON THE BRAKE AND HALF ON THE GAS PEDAL. I CHECKED OTHER MAKES AND MODELS AND THEY HAVE MORE DISTANCE BETWEEN THE BRAKE AND THE GAS PEDAL. THIS SEEMS TO BE INDICITIVE OF CHRYSLER PRODUCTS. I HAVE BEEN DRIVING FOR OVER 24 YEARS AND HAVE A VERY GOOD DRIVING RECORD. NOT ONCE IN ALL THOSE YEARS HAS THIS HAPPENED. THIS IS THE SECOND TIME IN TWO MONTHS THIS HAS NOW HAPPENDED TO ME. I PURCHASE MY JEEP JUST TWO MONTHS AGO. PLEASE CHECK THE SPACING OF THE BREAK AND GAS PEDALS FOR YOURSELVES.*AK

2003 JEEP WRANGLER RUBICON. THE FACTORY FOG LAMPS SUDDENLY CAME ON WHILE THE SWITCH WAS IN THE OFF POSITION. PROBLEM PERSISTED EVEN AFTER NUMEROUS ATTEMPTS TO GET THEM TO GO OFF. THE ONLY WAY FOUND WAS TO DISCONNECT THE WIRING HARNESS UNDER THE FRONT FENDERS. THE DASH INDICATOR LAMP REMAINS LIT. *TR

TURN SIGNALS WILL NOT WORK. *TR

MY 2003 JEEP WRANGLER HAS DEVELOPED A SEVERE SHAKE AT 55 MPH, AND IS CUPPING ITS TIRES. I HAVE REQUESTED HELP FOR THIS PROBLEM FROM MY DEALER AND CHRYSLER CUSTOMER SERVICE. THE DEALER ACKNOWLEDGES SOME JEEPS HAVE THIS PROBLEM, CUSTOMER SERVICE SAYS THEY HAVE NEVER HEARD OF IT. THEY OFFER NO CURE BUT FREQUENT TIRE ROTATIONS. I DO ROTATE MY TIRES FREQUENTLY BUT THIS DOES NOT HELP. WHEN THE SHAKING STARTS THE VEHICLE BECOMES UNCONTROLLABLE, AND THE ONLY CURE IS RAPID DECELERATION. I AM HOPING YOU HAVE SOME RECORD OF THIS PROBLEM WITH JEEPS AND CAN OFFER A REMEDY. *NM

TIRE FAILURE, BLOW OUT OF REAR DRIVERS TIRE, VERY NEAR TO ROLLOVER CONDITION.*AK

WHEN I WAS DRIVING AROUND 50 MPH I HIT A POTHOLE AND THE VEHICLE START SHAKING VIOLENTLY. I HAD TO HOLD THE STEERING WHEEL SO HARD IT ALMOST WENT TO THE OTHER SIDE OF THE ROAD. THIS HAPPENED ALREADY 5 TIMES, I AM SO SCARED TO TAKE IT ON THE HIGHWAY, BECAUSE I MIGHT GET INTO A WRECK. I HAVE TO COME TO A COMPLETE STOP FOR IT TO STOP SHAKING. *TR