RoadVitals

2004 Kawasaki VN1600-A2 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jun 10, 2017
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Kawasaki VN1600-A2, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Fuel system150.0%
  • Powertrain (other)150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

1
report

From owner reports, verbatim

FUEL TANK WELDS ARE BAD, CAUSING FUEL TO LEAK OUT OF THE TANK ONTO ELECTRICAL COMPONENTS, SEAT AND ENGINE. GAS LEAKS ONTO CLOTHING CAUSING A SAFETY CONCERN DUE TO POSSIBLE EXPLOSION. THIS IS MY SECOND TANK, AND IT LEAKS OUT OF THE SAME AREA AS THE ORIGINAL. FACTORY REFUSES TO ADDRESS THIS. THE NATURE OF THESE LEAKS CAN CAUSE BODILY HARM TO BOTH THE DRIVER AN PASSENGER. THIS MODEL BIKE SOMEHOW SLIPPED THOUGH THE CRACKS ON THE RECALL. THE LEAK HAPPENS BOTH IN USE OR PARKED. GAS ALSO LEAKS ON THE GROUND.

NHTSA ID 10994301 · filed Jun 10, 2017

Too few reports in this category for a page of its own — they appear in the full complaint list.

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

1
report

From owner reports, verbatim

THE REAR SEALS ON THE WHEEL LEAKED. IT WAS DISCOVERED WHEN OIL WAS SEEN ON THE GROUND. THE VIBRATION INCREASED AND A PASSENGER COULD NOT RIDE. THE MOTORCYCLE WAS TORN DOWN, AND THE DEALER WOULD NOT REPAIR IT. THE DEALER INSISTED THAT THE MOTORCYCLE WAS NOT REPAIRABLE. THE MANUFACTURER REFUSED TO REIMBURSE THE CONSUMER. *AK *SC *JB

NHTSA ID 10087315 · filed Aug 31, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .