RoadVitals

2004 Kawasaki VN1600-A2

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jun 10, 2017
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Feb 18, 2004
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 2 NHTSA owner-reported complaints for the 2004 Kawasaki VN1600-A2, most frequently naming the fuel system and powertrain (other) categories. 1 safety recall has been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Fuel system150.0%
  • Powertrain (other)150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
04V063000

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

Feb 18, 2004
5,850 units potentially affected
The defect: ON CERTAIN MOTORCYCLES, THE MUFFLER BRACKETS COULD CRACK ALLOWING THE MUFFLER TO BECOME LOOSE AND POTENTIALLY SEPARATE FROM THE MAIN EXHAUST PIPES.
The risk: THIS COULD RESULT IN A CRASH.
The remedy: DEALERS WILL REINFORCE THE MUFFLER BRACKETS. OWNER NOTIFICATION BEGAN ON FEBRUARY 17, 2004. OWNERS SHOULD CONTACT KAWASAKI AT 1-866-802-9381.
KAWASAKI MOTORS CORP., U.S.A.View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Fuel system
Filed Jun 10, 2017

FUEL TANK WELDS ARE BAD, CAUSING FUEL TO LEAK OUT OF THE TANK ONTO ELECTRICAL COMPONENTS, SEAT AND ENGINE. GAS LEAKS ONTO CLOTHING CAUSING A SAFETY CONCERN DUE TO POSSIBLE EXPLOSION. THIS IS MY SECOND TANK, AND IT LEAKS OUT OF THE SAME AREA AS THE ORIGINAL. FACTORY REFUSES TO ADDRESS THIS. THE NATURE OF THESE LEAKS CAN CAUSE BODILY HARM TO BOTH THE DRIVER AN PASSENGER. THIS MODEL BIKE SOMEHOW SLIPPED THOUGH THE CRACKS ON THE RECALL. THE LEAK HAPPENS BOTH IN USE OR PARKED. GAS ALSO LEAKS ON THE GROUND.

NHTSA ID
10994301
Incident
Aug 10, 2016
Mileage
50,000 mi
Powertrain (other)
Filed Aug 31, 2004

THE REAR SEALS ON THE WHEEL LEAKED. IT WAS DISCOVERED WHEN OIL WAS SEEN ON THE GROUND. THE VIBRATION INCREASED AND A PASSENGER COULD NOT RIDE. THE MOTORCYCLE WAS TORN DOWN, AND THE DEALER WOULD NOT REPAIR IT. THE DEALER INSISTED THAT THE MOTORCYCLE WAS NOT REPAIRABLE. THE MANUFACTURER REFUSED TO REIMBURSE THE CONSUMER. *AK *SC *JB

NHTSA ID
10087315
Incident
Jul 16, 2004
Mileage
2,300 mi