RoadVitals

2001 Kawasaki ZRX1200-A Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Nov 16, 2009
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2001 Kawasaki ZRX1200-A, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Tires & wheels1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Tires & wheels

Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.

1
report

From owner reports, verbatim

PURCHASED IN APRIL, 2009 AND INSTALLED SET OF AVON STORM MOTORCYCLE TIRES. THE REAR TIRE, SIZE 180/55ZR17 (DOT AT8E IC 3208) LESS THAN 3000 MILES AND ABOUT 6 MONTHS SINCE INSTALL BEGAN LOSING AIR. THIS WAS A SLOW LEAK THAT LOST AIR FASTER AS PRESSURE DROPPED. INVESTIGATION FOUND THAT BEAD AREA WAS LEAKING, CAUSED BY CORROSION AT FAIRLY EVEN INTERVALS AROUND THE BEAD AREA, ALONG WITH A GOUGE INTO THE RIM AT THE SAME SPACING AS THE CORROSION. THERE APPEARS TO BE A SHARP STEEL WIRE JUST AT THE SURFACE OF THE BEAD WHERE IT MATES TO THE RIM. TIRE WAS INSTALLED USING MURPHY'S TIRE LUBE, AND IS USED ON ALL MY TIRE CHANGES WITHOUT PROBLEM. THE CORROSION SEEMS TO BE COMING FROM THE TIRE BEAD. IT CREATES AN UNSAFE CONDITION THAT COULD CAUSE TIRE PRESSURE FAILURE, POSSIBLY A LOSS OF CONTROL AND SUBSEQUENT CRASH WITH POSSIBILITY OF INJURY OR DEATH. I AM TAKING THE TIRE TO THE DISTRIBUTOR FOR EXCHANGE. I DO NOT KNOW IF THE TIRE WOULD BE AVAILABLE FROM THEM, THEY WOULD HAVE TO KEEP IT FOR EXCHANGE. *TR

NHTSA ID 10292433 · filed Nov 16, 2009

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .