RoadVitals

2023 Kawasaki ZX400 Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Jul 16, 2024
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Aug 5, 2023

What this page shows

Our database holds 3 NHTSA owner-reported complaints for the 2023 Kawasaki ZX400. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–3 of 3

Powertrain (other)
Filed Jul 16, 2024

The contact owns a 2023 Kawasaki ZX400 Motorcycle. The contact state while riding approximately 65 MPH and in 6th gear, the motorcycle lost motive power. In addition, while downshifting into the lower gears, the motorcycle had reduced power until 4th gear. The engine seized and the contact grabbed the clutch to slow down and pull over. The contact stated the front of the crankcase had a hole. No warning light was illuminated. The motorcycle was towed to a local dealer where it was diagnosed but the result was not available. The manufacturer was made aware of the failure. The failure mileage was approximately 64,000.

NHTSA ID
11602758
Incident
Jul 6, 2024
Mileage
64,000 mi
Engine
Filed Jul 16, 2024
Fire reported

The contact owned a 2023 Kawasaki ZX400. The contact stated that while driving at an undisclosed speed, cylinder three started shuddering and misfiring. As a result, flames were noticed coming from the front area, near the engine compartment, causing the vehicle to be burned down. No one was injured during the fire. A race track fire crew arrived and extinguished the fire. A police and fire report was not filed. The vehicle was towed to a local dealer, where it remains, and the cause of the fire has not been determined yet. The manufacturer was notified of the failure. The failure mileage was approximately 5,000.

NHTSA ID
11602735
Incident
Jul 13, 2024
Mileage
5,000 mi
Electrical
Filed Aug 5, 2023
1 injury reported

I was leaving a stop light in road mode. I took off smoothly with no rapid acceleration. I was in second gear and was going roughly 20 mph, when suddenly the bike stalled and the rpms immediately dropped. I was jerked forward but stood on the bike. However, it caused me to drop it on my right side, causing the right side fairings, exhaust pipe, even frame and bar ends to be scratched. I did get injured with a fractured hand. Luckily there was no traffic around and no others were in danger. There was no warning lamps on the dash at the time, and it hasn't happened so far. I have not got the bike checked yet, but definitely plan on it after hearing of the recall.

NHTSA ID
11536689
Incident
May 22, 2023

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .